Professional Documents
Culture Documents
BX-32ND3
EU Directive See the “EU Directive” topic in the Help File A B
Sink/Source
1C 1C
8 12
9 13
10 14
11 15
2C 2C
16 20
17 21
18 22
19 23
3C 3C
24 28
25 29
26 30
27 31
4C 4C
BX-32ND3
I/O Terminal
ZIPLinkBlocks
Cable sold
Required.
separately.
(See Terminal
(See Connector
Block Connection
OptionsOptions
table). tables).
Input Specifications WARNING: To minimize the risk of potential safety problems, you should
follow all applicable local and national codes that regulate the installation and
Input Type Sink/Source operation of your equipment. These codes vary from area to area and it is your
responsibility to determine which codes should be followed, and to verify that the
Total Inputs per Module 32
equipment, installation, and operation are in compliance with the latest revision
Commons 4 (8 points/common) Isolated of these codes.
Equipment damage or serious injury to personnel can result from the
Nominal Voltage Range 12 - 24 VDC failure to follow all applicable codes and standards. We do not guarantee the
Input Voltage Range 9 - 30 VDC products described in this publication are suitable for your particular applica-
tion, nor do we assume any responsibility for your product design, installation,
Maximum Voltage 30 VDC or operation.
If you have any questions concerning the installation or operation of this
Input Impedance 8kΩ @ 24VDC
equipment, or if you need additional information, please call Technical Support at
Input Current (typical) 3mA @ 24VDC 770-844-4200.
This publication is based on information that was available at the time it was
Maximum Input Current 6mA @ 30VDC printed. At AutomationDirect.com® we constantly strive to improve our products
ON Voltage Level > 9.0VDC and services, so we reserve the right to make changes to the products and/or
publications at any time without notice and without any obligation. This publica-
OFF Voltage Level < 2.0VDC tion may also discuss features that may not be available in certain revisions of
Minimum ON Current 2.0mA (9V required to guarantee ON state) the product.
IMPORTANT!
Hot-Swapping Information
Note: This device cannot be Hot Swapped.
ZL-D24-CBL40-X
45-degree connector angle, 1.6ft/0.5m cable length.
TX
RX
Dimensional Information
ZL-RTB40-1 ZIPLink Three Level Feedthrough Module, 40-pole, 35mm, DIN mount.
Note: D
rawings are for reference only.
ZL-LTB32-24-1 ZIPLink sensor input module, 32-point, LED indication, 24 VDC, DIN mount. Shown without terminal blocks.
3.25″
[82.6mm] 1.08″
[27.5mm]
4.57″ 4.24″
[116.2mm] [107.8mm]
1.00″
[25.4mm]
2X Ø #8 Thru all
0 4
1 5
2 6
3 7
1C 1C
8 12
9 13
10 14
11 15
2C 2C
16 20
17 21
18 22
19 23
3C 3C
24 28
25 29
26 30
27 31
4C 4C
Source
+
+12-24V
+
Sink