Professional Documents
Culture Documents
ENGINEERING DRAWING
MEC1008S
A set of working drawings has been requested for a steel frame for a factory table.
You are required to design the steel frame to the following requirements:
Overall length : 2m.
Width : 1,2m.
Height : 1,1m
Choose suitable structural steel profiles (I-Beam, Channel and RSA) to design this table.
Supports and Gussets: Mild steel plate
Fasteners: Bolt, nut and washer or Studs to suit. A standard block found on VULA may be used and adjusted to your bolt
choice size.
Back mark information SANS10162-1.
DETAILED DRAWINGS
• Generate detailed drawings of the components that make up the structure.
• Each component must be fully dimensioned to show bolt hole positions and overall sizes.
• Isolate each detail in a block and add the title, part number and scale to each component.