Professional Documents
Culture Documents
50/60Hz
Range: 6 TR to 40 TR
(21 kW to 140 kW)
Since
1974
SKM 100% FA Package Air Conditioning Units PAC4A Series
Contents Introduction
SKM PAC4A Series 100% Fresh Air (FA)
Legend ...................................... 2 Fan Performance ................... 11-20 Packaged Air Conditioners are designed and
Nomenclature ............................ 2 Electrical Data .............................. 21 manufactured to meet the requirements of Gulf’s
Introduction ............................... 2 Typical Wiring Diagram .......... 22-24 severe climatic conditions and are built specifically
General Features ..................... 3 Dimensional Data ................... 25-33 for High Energy Efficiency ducted systems which
Main Component Features ....... 3 Weights and Loading Points ...34-35
will enable them to be installed easily on rooftop or
Factory Installed Options ...... 5-6 Recommended Clearances ......... 36
on ground, treat and supply fresh air to maintain
General Data ......................... 7-8 Guide Specifications .................... 37
the indoor air quality within the required level.
Capacity Ratings ................. 9-10
The PAC4A series Packaged Air Conditioners are
compact, quiet, most efficient and self contained
units are ideal for fresh air applications.
Legend
Available in 13 different sizes from 6 to 40 TR
The following legends are used throughout this manual: (21 to 140 kW) in 50/60 Hz.
AFR ........... Air Flow Rate L/s.......... Liters per second
BPF............ By Pass Factor MBh........BTUHx1000 As the indoor air pollution is a major problem,
CFM........... Cubic feet per minute Pa........... Pascal affecting human health and productivity. Bringing
EER............ Energy Efficiency Ratio Ph........... Phase treated fresh air from outside is absolutely critical
ESP............. External Static Pressure PI .......... Power Input of Compressor to maintain indoor air quality within the acceptable
Hz ............... Hertz in kW range. SKM PAC4A series deliver clean, cooled
in. wg......... Inch water gauge RPM .......Revolutions Per Minute and dehumidified fresh air to improve the indoor
kW.................Kilowatts RPS........ Rated Power Supply air quality and meet with ASHRAE requirements
kg..................Kilogram TR.......... Tons of Refrigeration for fresh air and energy efficiency.
lbs.................Pounds weight V............. Volts
PAC4A series units from SKM are completely
assembled, leak tested, vacuumed, internally
wired and fully charged with R-410A refrigerant
at factory. Each unit is fully factory tested before
dispatch and is ready for installation. All that is
Nomenclature required on the site is to connect ducts, drain
lines, main power supply and field wiring to the
thermostat. This greatly reduces the installation
PAC 4A 5 1 006 Y work and cost.
5 = 50 Hz
6 = 60Hz 1 : Single Circuit
2 : Double Circuit
SKM Air Conditioning LLC
2
R410-A
REFRIGERANT
What makes PAC4A series yet another model in the top class
range of SKM products is the use of: Condenser Coil
Evaporator Coil
Evaporator coils are designed specially for fresh air application, Casing and Structure
to handle the high entering air temperature and it is manufactured
of seamless copper tubes mechanically bonded to aluminium fins The unit casing used in PAC4A 100% FA Packaged units is made
to ensure optimum heat transfer. All evaporator coils are tested of zinc coated galvanized steel sheets conforming to JIS-G 3302
against leakage by air pressure of 450psig (3103kPa) under and ASTM A653 which is phosphatized before application of an
water. The DX evaporator coils are complete with headers of electrostatic powder coat of approximately 60 microns and then
seamless copper tubing. Supply headers incorporate a correctly oven-baked for tough and lasting weather resistant finish. This
sized distributor. finish and coating can pass a 1000 hour in 5 % salt spray testing
at 95°F (35°C) and 95% relative humidity as per ASTM B117.
For different application requirements, other evaporator coil
material and/or treatment are available on request : The evaporator section is double skin and insulated from all the
sides with 2” thick fiber glass insulation with extremely tough and
• Copper fins. durable black compositesurface .
• Precoated Aluminum fins. The insulation-cum-sound liner meets the fire requirements of
NFPA90A & 90B and is secured with mechanical fasteners in
The pre-coated is hydrophobic polyurethane resin. This option addition to water resistant adhesive.
provides substantial corrosion protection beyond standard coil
construction.
• Aeris Guard Coil Coating.
Control Panel
The Aeris Guard Coil is a dip-coated and self etching high The PAC4A package air conditioners are provided with control
performance modified epoxy finish that is specifically designed panel enclosure comprising all starting, operationg & safety
to coat and protect Aluminum and Copper surfaces. In addition, controls. The panel is factory wired in accordance with NEC
the coating is ideal for the protection of ferrous and non ferrous 430 & 440, labelled, tagged and features 220v / 240v controls.
materials.
• Starting contactors for compressors and motors.
• Internal overload protection for compresors.
Evaporator coils are rated in accordance with AHRI-410.
• Internal or external overload protection for the motors
Evaporator coil supplied with suitable size expansion valve(s)
(depending on the model).
and multi-circuited distributors providing capacity modulation to
match the compressors. The cross wave fins and staggered tubes • Electronic control board for unit operation.
design uses the evaporator surface effectively by creating uniform • Diagnostic LEDs on the control board for easy troubleshooting.
air turbulance and optimum heat transfer over the entire finned • Compressor short cycling protection.
surface. Moisture eliminators used as standard feature for • Control based on supply air temperature sensor.
PAC4A Series. • Control circuit for unit on/off switch.
• Control circuit breaker.
• Power and control circuit termination blocks.
Evaporator Fan & Drive • High pressure protection.
• Low pressure protection.
Standard evaporator fan is backward curved centrifugal DIDW, • 24V digital thermostat.
statically and dynamically balanced complete with shaft, self-
• Duct temperature sensor.
aligning, lubricated for lifetime bearings.
4
R410-A
REFRIGERANT
52040 / 62040 48
6
R410-A
REFRIGERANT
GENERAL DATA
50Hz
Model PAC4A 51006 52008 52010 52011 52013 52015 52018
MBH 55.0 93.5 108.3 124.5 148.2 189.4 214.8
Actual Capacity ( 1 )
kW 16.1 27.4 31.7 36.5 43.4 55.5 63.0
Refrigerant Type - R410A
Type - HERMETIC SCROLL
Quantity - 1 2 2 2 2 2 2
Compressor
US Gal 0.47 0.33/0.33 0.47/0.47 0.47/0.47 0.47/0.47 0.86/0.86 0.86/0.86
Oil Charge
Liter 1.77 1.24/1.24 1.77/1.77 1.77/1.77 1.77/1.77 3.25/3.25 3.25/3.25
Type - Hi-X 3/8" Tubes
Condenser Coil ft² 13.5 18.0 18.0 21.3 21.3 30 30.0
Face Area
m² 1.3 1.7 1.7 2.0 2.0 2.8 2.8
Type - Propeller Direct Drive Fan
Condenser Fan
Code / Quantity - 450/2 550/2 550/2 630/2 630/2 710/2 710/2
Condenser Motor Type - Class-F insulation, IP-55 Protected
Type - Hi-X 3/8" Tubes
Evaporator Coil ft² 1.7 2.8 3.3 3.9 4.4 6 6.0
Face Area
m² 0.2 0.3 0.3 0.4 0.4 0.6 0.6
Type - Centrifugal DIDW Belt Drive
Evaporator Fan
Size (I / II ) - 225 225 225 225 225/250 225/250 250/280
Type - Totally Enclosed Fan Cooled, Class-F insulation, IP55 Protected.
Evaporator Motor
Size (I / II / III) kW 0.75/1.1 1.1/1.5 1.1/1.5 1.5/2.2 1.5/2.2 1.5/2.2 2.2/3/4
lbs 13.0 8.3/8.3 10.9/10.9 12.3/12.3 15.1/15.1 18.2/18.2 18/18
Refrigerant Operating Charge Ckt (A / B)
kg 5.9 3.7/3.7 5/5 5.6/5.6 6.8/6.8 8.3/8.3 8.2/8.2
Number of Refrigerant Circuits - 1 2 2 2 2 2 2
lbs 1351 1573 1692 1957 2024 2511 2550
Unit Operating Weight
kg 613 713 767 888 918 1139 1157
Table 2
Table 3
Notes:
(1). Evaporator entering air conditions of 115°F/85°F (46.1°C/29.4°C) dry bulb/wet bulb and condenser entering air temperature
of 115°F (46.1°C) dry bulb.
(2). Capacity for all conditions are gross capacity which does not include the effect of evaporator fan motor heat.
(3). Evaporator motor size “I” shows standard motor size and “II” & “III” shows the alternate motor size as per ESP
GENERAL DATA
60Hz
Model PAC4A 61006 62008 62010 62011 62013 62015 62018
MBH 55.9 96.7 111.4 134.3 143.2 185.9 220.1
Actual Capacity ( 1 )
kW 16.4 28.3 32.6 39.4 42.0 54.5 64.5
Refrigerant Type - R410A
Type - HERMETIC SCROLL
Quantity - 1 2 2 2 2 2 2
Compressor
US Gal 0.33 0.33/0.33 0.33/0.33 0.44/0.44 0.47/0.47 0.47/0.47 0.86/0.86
Oil Charge
Liter 1.24 1.24/1.24 1.24/1.24 1.66/1.66 1.77/1.77 1.77/1.77 3.25/3.25
Type - Hi-X 3/8" Tubes
Condenser Coil ft² 13.5 18.0 18.0 21.3 21.3 30 30.0
Face Area
m² 1.3 1.7 1.7 2.0 2.0 2.8 2.8
Type - Propeller Direct Drive Fan
Condenser Fan
Code / Quantity - 450/2 550/2 550/2 630/2 630/2 710/2 710/2
Condenser Motor Type - Class-F insulation, IP-55 Protected
Type - Hi-X 3/8" Tubes
Evaporator Coil ft² 1.7 2.8 3.3 3.9 4.4 6 6.0
Face Area
m² 0.2 0.3 0.3 0.4 0.4 0.6 0.6
Type - Centrifugal DIDW Belt Drive
Evaporator Fan
Size (I / II ) - 225 225 225 225 225/250 225/250 250/280
Type - Totally Enclosed Fan Cooled, Class-F insulation, IP55 Protected.
Evaporator Motor
Size (I / II / III) kW 0.75/1.1 1.1/1.5 1.1/1.5 1.5/2.2 1.5/2.2 1.5/2.2 2.2/3/4
lbs 13.0 8.3/8.3 10.9/10.9 12.3/12.3 15.1/15.1 18.2/18.2 18/18
Refrigerant Operating Charge Ckt (A / B)
kg 5.9 3.7/3.7 5/5 5.6/5.6 6.8/6.8 8.3/8.3 8.2/8.2
Number of Refrigerant Circuits - 1 2 2 2 2 2 2
lbs 1317 1573 1624 1952 2024 2414 2550
Unit Operating Weight
kg 597 713 737 886 918 1095 1157
Table 4
Notes:
(1). Evaporator entering air conditions of 115°F/85°F (46.1°C/29.4°C) dry bulb/wet bulb and condenser entering air temperature
of 115°F (46.1°C) dry bulb.
(2). Capacity for all conditions are gross capacity which does not include the effect of evaporator fan motor heat.
(3). Evaporator motor size “I” shows standard motor size and “II” & “III” shows the alternate motor size as per ESP
8
R410-A
REFRIGERANT
Notes: Table 6
(1). Ratings are based on fresh air application, in which the ambient temperature is same as on coil temperature.
(2). Capacity is gross capacity which does not include the effect of evaporator fan motor heat.
(3). Direct interpolation is permissible. Do not extrapolate.
(4). For other conditions , please consult SKM.
* Power input mentioned in this page is for compressor only, and should not be used for cable or
fuse selection. MCA and MFA values given in the electrical data page (21) should be
referred for the same.
Table 7
Notes:
(1). Ratings are based on fresh air application, in which the ambient temperature is same as on coil temperature.
(2). Capacity is gross capacity which does not include the effect of evaporator fan motor heat.
(3). Direct interpolation is permissible. Do not extrapolate.
(4). For other conditions , please consult SKM.
* Power input mentioned in this page is for compressor only, and should not be used for cable or fuse selection.
MCA and MFA values given in the electrical data page (21) should be referred for the same.
10
R410-A
REFRIGERANT
FAN PERFORMANCE
50Hz
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
450 212 2301 0.13 2451 0.14 2600 0.15 2734 0.17 2867 0.19 2988 0.21 3109 0.23 3221 0.26 3333 0.28 3439 0.30
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
51006
600
CFM
700
283
L/S
330
I
2783 0.19
RPM BKW
3155 0.28
2909 0.21 3034 0.23 3151 0.26 3267 0.28 3376 0.31 3484 0.34
RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3268 0.3 3381 0.33 3487 0.36 3593 0.39 3693 0.42 3793 0.45
3586 0.37
RPM BKW
3887 0.48
3688 0.39
RPM BKW
3982 0.51
3785 0.42
RPM BKW
4166 0.59
Model
51006
450
800
600
AIR FLOW
212
378
283
2301 0.13
3526 0.36
2783 0.19
2451 0.14 2600 0.15 2734 0.17 2867 0.19 2988 0.21 3109 0.23
3627 0.39 3727 0.42 3823 0.46 3918
EXTERNAL
2909 0.21 3034 0.23 3151 STATIC
0.26 3267
0.49 4010 0.52 4101 0.55
PRESSURE-inch
0.28 3376 0.31 wg.(Pa)
3484 0.34
3221 0.26
4189 0.59 4276 0.62
3586 0.37 3688 0.39
3333 0.28
Ii 3439 0.30
-
3785 0.42
-
Region
PAC4A“I” shows 700 standard
330 motor
3155 size
0.2 (50)0.28 0.75kw
0.4 (100) 0.6 (150) 0.8 (200) 1 (250)
3268 0.3 3381 0.33 3487 0.36 3593 0.39 3693 0.42 3793 0.45 38871.2 (300) 1.4 (350) 1.6 (400) 1.8 (450)
0.48 3982 0.51 2 (500)
4166 Table
0.59 8
Region “II” shows800 alternate
CFM L/S
378 motorBKW
RPM
3526 size RPM
0.36 0.75kw
3627 BKW 0.39 RPM
3727 BKW 0.42 RPM
3823 BKW 0.46 RPM
3918 BKW 0.49 RPM
4010 BKW 0.52 RPM
4101 BKW 0.55 RPM
4189 BKW 0.59 RPM
4276 BKW 0.62 RPM- BKW-
450 212 2301 0.13 2451 0.14 2600 0.15 2734 0.17 2867 0.19 2988 0.21 3109 0.23 3221 0.26 3333 0.28 3439 0.30
600 283 2783 0.19 2909 0.21 3034 0.23 3151EXTERNAL EXTERNAL
0.26 3267STATIC
STATIC PRESSURE-inch
0.28PRESSURE-inch
3376 0.31 wg.(Pa)wg.(Pa)
3484 0.34 3586 0.37 3688 0.39 3785 0.42
Model
51006 AIR FLOW
AIR FLOW
Model 0.2(50)
(50) 0.4(100)
(100) 0.6(150)
(150) 0.8(200)
(200) 1(250)
(250) 1.2(300)
(300) 1.4(350)
(350) 1.6(400)
(400) 1.8(450)
(450) 2 (500)
PAC4A 700 330 31550.2 0.28 0.4
3268 0.3 0.6
3381 0.33 0.8
3487 0.36 1
3593 0.39 1.2
3693 0.42 1.4
3793 0.45 38871.6 0.48 39821.8 0.51 2 (500)
4166 0.59
PAC4A CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
CFM
800 L/S
378 RPM BKW
3526 RPM BKW
0.36 3627 RPM BKW
0.39 3727 RPM EXTERNAL
0.42 3823 BKW RPM
0.46 3918 BKW
STATIC RPM BKW
0.49 PRESSURE-inch
4010 RPM
0.52 4101
wg.(Pa) BKW RPM BKW
0.55 4189 RPM BKW
0.59 4276 0.62 RPM
- BKW -
Model 700
AIR FLOW330 - - 2075 0.20 2191 0.22 2303 0.26 2411 0.29 2514 0.33 2613 0.36 2710 0.39 2805 0.43 - -
450 212 23010.2 (50) 0.13 2451 0.14 2600
0.4 (100) 0.15 2734
0.6 (150) 0.17 28671 (250)
0.8 (200) 0.19 2988 0.21 3109
1.2 (300) 0.23 3221
1.4 (350) 0.26 3333
1.6 (400) 0.28
1.8 (450) 34392 (500)
0.30
PAC4A 800 378 - - 2239 0.26 2349 0.29 2455 0.32 2558 0.36 2657 0.40 2752 0.43 2844 0.47 2935 0.51 3024 0.55
600 283 2783
RPM 0.19 BKW 2909RPM 0.21 BKW 3034
RPM 0.23 BKW 3151
RPM 0.26 BKW 3267
RPM 0.28 BKW 3376
RPM 0.31 BKW 3484
RPM 0.34 BKW 3586
RPM 0.37 BKW 3688
RPM 0.39 3785
RPM 0.42
51006 CFM
1000 L/S
472 2493 0.36 2592 0.40 2688 0.44 2781 0.48 2870 0.53 2957 0.57 3042 0.61 3126 0.66 3207 BKW 0.71 3286 0.75
BKW
52008 700
700 330
330 3155 - 0.28 2075 0.3
- 3268 0.20 3381
2191 0.330.22 3487
2303 0.36 0.26 3593
2411 0.390.29 3693
2514 0.42 0.33 3793
2613 0.45 0.36 3887
2710 0.48 0.39 3982
2805 0.51 0.43 4166- 0.59-
Model
1200
800
800
1400
1000
566
378
378
AIR FLOW661
472
3526- I
2844 0.55 2931 0.59 3015 0.64 3097 0.69 3178 0.74 3256 0.79 3331 0.84 3406 0.89 3480 0.94
0.36 2239 0.39
- 3627 0.26 3727
2349 0.420.29 3823
0.6 (150)
2455 0.32 3918
EXTERNAL
0.46
0.8 (200)
0.44 2781
2558
STATIC 0.36
0.49 2657 0.52
PRESSURE-inch
4010
3259 0.83 3335 0.88 3409 0.93 3481 0.98 3553 1.04 3624 1.09 3693 1.15 3760 1.20 3825 1.26
2493
0.2 (50)0.36 2592 0.40 2688
0.4 (100) 1 (250)0.53 2957
0.48 2870 1.2 (300)
4101
2752 0.55
0.40 wg.(Pa)
1.4 (350)
0.57 3042
0.43 4189
2844 0.59
1.6 (400)
0.61 3126
0.47 4276
2935 0.62
1.8 (450)
0.66 3207
0.51
0.71
3553 0.99
3024
-
3890 1.32
0.55
-
2 (500) 0.75
3286
PAC4A
52008 1500 708 3459 0.99 3530 1.05 3600 1.11 3669 1.16 3737 1.22 3803 1.28 - - - - - - - -
CFM
1200 L/S
566 RPM
2844 BKW 0.55 RPM
2931 BKW 0.59 RPM
3015 BKW 0.64 RPM
3097 BKW 0.69 RPM
3178 BKW 0.74 RPM
3256 BKW 0.79 RPM
3331 BKW 0.84 RPM
3406 BKW 0.89 RPM
3480 BKW 0.94 RPM
3553 BKW 0.99
700
1400 330
661 -
3259 -
0.83 2075
3335 0.200.88 2191
3409 0.220.93 2303
3481 0.26 0.98 2411
3553 0.291.04 2514
3624 0.33 1.09 2613
3693 0.36 1.15 2710
3760 0.39 1.20 2805
3825 0.43 1.26 -
3890 -
1.32
Model
800
1500
AIR FLOW
1000
378
708
472
-
3459
24930.2 (50)
-
0.99 2239
3530 0.26
0.36 2592
1.05 2349
3600 0.29
0.40 2688
0.4 (100)
1.11 2455
3669
0.44 2781
0.6 (150)
0.32
1.16 2558
EXTERNAL
0.8 (200)
3737
STATIC
0.48 2870
0.36
1 (250)
1.22 2657
3803 0.40
PRESSURE-inch
0.53 2957
2752
0.57 3042
1.2 (300)
- 0.43- 2844
1.28 wg.(Pa)
0.61 3126
1.4 (350)
- 0.47- 2935
0.66 3207
1.6 (400)
- 0.51-
0.71
1.8 (450)
Ii
3024
3286
- 0.55-
2 (500)0.75
Region
52008“I” shows standard motor size 1.1kw
PAC4A
1200 566 2844 0.55 2931 0.59 3015 0.64 3097 EXTERNAL
0.69 3178STATIC0.74 PRESSURE-inch
3256 wg.(Pa)
0.79 3331 0.84 3406 0.89 3480 0.94 3553 Table
0.99 9
Model CFM L/S
AIR FLOW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
Region
PAC4A
“II” shows
1400
700
alternate
661
330
motor
3259
-
size
0.2 (50)
0.83
-
1.5kw
0.4 (100)
3335
2075 0.88 2191
0.20
0.6 (150)
3409 0.93 2303
0.22 34810.8 (200) 35531 (250)
0.98 2411
0.26 1.04 2514
0.29 36241.2 (300)
1.09 3693
0.33
1.4 (350) 3760
2613 1.15
1.6 (400) 3825
0.36 2710 1.20
1.8 (450)
0.39 2805 1.26 0.43 3890
-
2 (500)
1.32
-
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
1500
800 708
378 3459
- 0.99
- 2239
3530 0.261.05 2349
3600 0.291.11 2455 0.32
1.16 2558
3669 EXTERNAL 3737 0.36
STATIC1.22 PRESSURE-inch
3803
2657 1.28 -
0.40 2752
wg.(Pa) -
0.43 -
2844 -
0.47 -
2935 -
0.51 -
3024 -
0.55
Model 850
AIR FLOW401 - - 2184 0.24 2294 0.27 2404 0.30 2507 0.34 2609 0.38 2704 0.42 2799 0.45 2890 0.49 2980 0.53
1000 472 24930.2 (50) 0.36 2592 0.40 2688
0.4 (100) 0.44 2781
0.6 (150) 0.48 28701 (250)
0.8 (200) 0.53 2957 0.57 3042
1.2 (300) 0.61 3126
1.4 (350) 0.66 3207
1.6 (400) 0.71
1.8 (450) 32862 (500)
0.75
52008
PAC4A 1000 472 2339 0.31 2442 0.35 2544 0.38 2640 0.42 2736 0.46 2825 0.51 2914 0.55 3000 0.59 3085 0.63 3166 0.68
1200
CFM 566
L/S 2844
RPM 0.55 BKW 2931RPM 0.59 BKW 3015
RPM 0.64 BKW 3097
RPM 0.69 BKW 3178
RPM 0.74 BKW 3256
RPM 0.79 BKW 3331
RPM 0.84 BKW 3406
RPM 0.89 BKW 3480
RPM 0.94 BKW 3553
RPM 0.99 BKW
52010 1200 566 2662 0.46 2755 0.50 2844 0.55 2931 0.59 3015 0.64 3097 0.69 3178 0.74 3256 0.79 3331 0.84 3406 0.89
1400
850 661
401 3259- 0.83- 3335
2184 0.880.24 3409
2294 0.930.27 3481
2404 0.98 0.30 3553
2507 1.040.34 3624
2609 1.09 0.38 3693
2704 1.15 0.42 3760
2799 1.20 0.45 3825
2890 1.26 0.49 3890
2980 1.32 0.53
1400 661 2978 0.65 3061 0.70 3141 0.75 3221 0.80 3297 0.85 3373 0.90 3445 0.96 3517 1.01 3588 1.07 3659 1.12
1000
1500 472
708 2339 0.99
3459 0.31 3530
2442 1.050.35 3600
2544 1.110.38 3669
2640EXTERNAL
1.16 STATIC
0.42 3737
2736 1.22PRESSURE-inch
0.46 2825 1.28
3803 0.51 wg.(Pa)
2914
- 0.55
- 3000
- 0.59
- 3085
- 0.63
- 3166
- 0.68
-
Model 1600
AIR FLOW755 3364 0.94 3437 1.00 3509 1.05 3580 1.11 3649 1.17 3716 1.23 3782 1.29 - - - - - -
52010 1200 566 0.2 (50)0.46 2755
2662 0.4 (100) 0.6 (150)
0.50 2844 0.8 (200)
0.55 2931 1 (250)0.64 3097
0.59 3015 1.2 (300) 1.4 (350)
0.69 3178 1.6 (400)
0.74 3256 1.8 (450)
0.79 3331 0.84 2 (500) 0.89
3406
PAC4A
CFM
1400 L/S
661 RPM
2978 BKW 0.65 RPM
3061 BKW 0.70 RPM
3141 BKW 0.75 RPM
3221 BKW 0.80 RPM
3297 BKW 0.85 RPM
3373 BKW 0.90 RPM
3445 BKW 0.96 RPM
3517 BKW 1.01 RPM
3588 BKW 1.07 RPM
3659 BKW 1.12
850
1600 401
755 -
3364 -
0.94 2184
3437 0.241.00 2294
3509 0.271.05 2404
3580 0.30 1.11 2507
3649 0.341.17 2609
3716 0.38 1.23 2704
3782 0.42 1.29 2799- 0.45- 2890 - 0.49- 2980- 0.53-
1000 472 2339 0.31 2442 0.35 2544 0.38 2640EXTERNAL 0.42 2736
STATIC 0.46PRESSURE-inch
2825 0.51 wg.(Pa)
2914 0.55 3000 0.59 3085 0.63 3166 0.68
Model
52010
Model
PAC4A
AIR FLOW
1200
1400
566
AIR FLOW
661
2662
2978
I
0.2 0.46
(50)
0.2 (50)
0.65
2755
0.4 0.50
(100)
0.4 (100)
3061 0.70
2844
0.6 0.55
(150)
0.6 (150)
3141 0.75
2931
0.8
3221
EXTERNAL
0.59
(200)
0.8 (200)
0.80
1
STATIC
3015
3297
0.64
(250)
1 (250)
0.85
PRESSURE-inch
3097
1.2
3373
0.69
(300)
1.2 (300)
0.90
wg.(Pa)
3178 0.74 3256
1.4 (350)
34451.4 (350)
0.79 3331
1.6 (400)
0.96 3517 1.6 (400)
0.84
1.8 (450)
1.01 3588 1.8 (450)
1.07
3406
2 (500)0.89
3659 2 (500)
1.12
PAC4A CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
Model
CFM
1600
850
1000
1000
755
401
AIR FLOW472
472
RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
L/S 3364
-
23390.2 (50)
0.94
- 3437 0.24
2184
0.31 2442
1.00 2294
3509 0.27
0.35 2544
1.05 2404
3580 EXTERNAL
0.38 2640
1.11 2507
0.30 3649
STATIC1.17 PRESSURE-inch
0.34 3716
2609 1.23
2228 0.27 2339 0.31 2442 0.35 2544 0.38 2640 0.42 2736 0.46 2825 0.51 2914 0.55 3000 0.59
0.42 27361 (250)
0.46 2825
0.38 3782
wg.(Pa)1.29
2704
0.51 2914
-
0.42 2799
0.55 3000
-
0.45 -
2890
0.59 3085
-
0.49
0.63
Ii RPM BKW
-
2980
3085 0.63
-
0.53
31662 (500)
0.68
0.4 (100) 0.6 (150) 0.8 (200) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450)
Region
PAC4A“I” shows1200standard
1200
566 motor
2519 size
2662
0.39 1.1kw
2615 0.44 2710 0.48 2800 0.53 2889 0.57 2973 0.62 3057 0.66 3138 0.71 3218 0.76 Table0.81
3294 10
52010 CFM 566
L/S RPM 0.46 BKW 2755RPM 0.50 BKW 2844
RPM 0.55 BKW 2931
RPM 0.59 BKW 3015
RPM 0.64 BKW 3097
RPM 0.69 BKW 3178
RPM 0.74 BKW 3256
RPM 0.79 BKW 3331
RPM 0.84 BKW 3406
RPM 0.89 BKW
Region “II” shows1400 alternate
661 motor
2851 size 0.58 1.5kw
2937 0.63 3020 0.68 3101 0.73 3181 0.78 3259 0.83 3335 0.88 3409 0.93 3481 0.98 3553 1.04
52011 1400
1000 661
472 2978
2228 0.27 2339 0.70
0.65 3061 0.31 3141
2442 0.750.35 3221
2544 0.80 0.38 3297
2640 0.850.42 3373
2736 0.90 0.46 3445
2825 0.96 0.51 3517
2914 1.01 0.55 3588
3000 1.07 0.59 3659
3085 0.631.12
1600 755 3173 0.80 3252 0.85 3327 0.91 3401 0.97 3473 1.03 3545 1.08 3614 1.14 3683 1.20 3749 1.26 3815 1.32
1600
1200 755
566 2519 0.94
3364 0.39 3437
2615 1.000.44 3509
2710 1.050.48 3580
2800EXTERNAL
1.11 STATIC
0.53 3649
2889 1.17PRESSURE-inch
0.57 3716
2973 1.23 0.62 wg.(Pa)
3782
3057 1.29 -
0.66 3138 -
0.71 -
3218 -
0.76 -
3294 -
0.81
Model AIR FLOW850
1800 3489 1.06 3559 1.13 3628 1.19 3697 1.26 3763 1.32 3828 1.38 3892 1.44 3957 1.51 4020 1.57 4081 1.64
1400 661 0.2 (50)0.58 2937
2851 0.4 (100) 0.6 (150)
0.63 3020 0.8 (200)
0.68 3101 1 (250)0.78 3259
0.73 3181 1.2 (300) 1.4 (350)
0.83 3335 1.6 (400)
0.88 3409 1.8 (450)
0.93 3481 0.98 2 (500) 1.04
3553
PAC4A
52011 2000 944 3831 1.42 3896 1.49 3959 1.56 4021 1.63 4083 1.70 4144 1.77 4203 1.84 - - - - - -
CFM
1600 L/S
755 RPM
3173 BKW 0.80 RPM
3252 BKW 0.85 RPM
3327 BKW 0.91 RPM
3401 BKW 0.97 RPM
3473 BKW 1.03 RPM
3545 BKW 1.08 RPM
3614 BKW 1.14 RPM
3683 BKW 1.20 RPM
3749 BKW 1.26 RPM
3815 BKW 1.32
1000
1800 850 2228
472 3489 0.27 1.06 2339
3559 0.311.13 2442
3628 0.351.19 2544
3697 0.38 1.26 2640
3763 0.421.32 2736
3828 0.46 1.38 2825
3892 0.51 1.44 2914
3957 0.55 1.51 3000
4020 0.59 1.57 3085
4081 0.63 1.64
1200
2000 944 2519
566 3831 0.39 1.42 2615
3896 0.441.49 2710
3959 0.481.56 2800
4021 0.53
1.63 2889
EXTERNAL STATIC
4083 0.57 2973
4144 0.62
PRESSURE-inch
1.70 3057
4203 0.66
1.77 wg.(Pa) 1.84 3138- 0.71- 3218 - 0.76- 3294- 0.81-
Model AIR FLOW
1400 2851 0.58 2937 0.63 3020 0.68 3101 0.73 3181 0.78 3259 0.83 3335 0.88 3409 0.93 3481 0.98 3553
52011
661 0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)1.04
PAC4A
1600
CFM 755
L/S 3173
RPM BKW 0.80 3252
RPM BKW 0.85 3327
RPM BKW 0.91 3401
RPM BKW 0.97 3473
RPM BKW 1.03 3545
RPM BKW 1.08 3614
RPM BKW 1.14 3683
RPM BKW 1.20 3749
RPM BKW 1.26 3815
RPM 1.32
BKW
1800
1000 850
472 3489 0.27
2228 1.06 2339
3559 0.311.13 2442
3628 0.351.19 2544
3697 0.38 1.26 2640
3763 0.421.32 2736
3828 0.46 1.38 3892
2825 1.44 0.51 3957
2914 1.51 0.55 4020
3000 1.57 0.59 4081
3085 1.64
0.63
2000
1200 944
566 2519
3831 0.39 1.42 2615
3896 0.441.49 2710
3959 0.481.56 4021
2800 1.63 0.53 4083
2889 1.700.57 4144
2973 1.77 0.62 4203
3057 1.84 -
0.66 3138 -
0.71 -
3218 -
0.76 -
3294 -
0.81
1400 661 2851 0.58 2937 0.63 3020 0.68 3101 0.73 3181 0.78 3259 0.83 3335 0.88 3409 0.93 3481 0.98 3553 1.04
52011
1600 755 3173 0.80 3252 0.85 3327 0.91 3401 0.97 3473 1.03 3545 1.08 3614 1.14 3683 1.20 3749 1.26 3815 1.32
1800 850 I 3489 1.06 3559 1.13 3628 1.19 3697 1.26 3763 1.32 3828 1.38 3892 1.44 3957 1.51 4020 1.57 4081 1.64
2000 944 3831 1.42 3896 1.49 3959 1.56 4021 1.63 4083 1.70 4144 1.77 4203 1.84 - - - - Ii - -
Notes:
(1). For data specified in BOLD, kindly consult for drive set selection.
(2). Internal static pressure is based on pressure drops through the evaporator coil, fan casing, droplet eliminator, 1” flat filter G2 and F8
15” bag filter.
(3). USM option for region III, please consult SKM.
FAN PERFORMANCE
Model
PAC4A
1400
AIR FLOW
1600
661
755 I
2718 0.50 2807 0.55 2895 0.60 2978
0.2 (50)0.71 3134
3053 0.4 (100) 0.6 (150)
0.77 3213 0.82 3289
EXTERNAL
0.8 (200)
STATIC
0.65 3061 PRESSURE-inch
0.70 3141 0.75 wg.(Pa)
1 (250)0.94 3437
0.88 3364 1.2 (300)
3221 0.80
1.4 (350)
1.00 3509 1.05
3297 0.85
1.6 (400)
3580 1.11
3373 0.90
1.8 (450)
3649 1.17
3445 0.96
2 (500)1.23
3716
52013 CFM
1800 L/S 850 RPM
2665 BKW 0.81 RPM
2739 BKW0.88 RPM
2811 BKW0.94 RPM
2881 BKW1.01 RPM
2950 BKW1.07 RPM
3017 BKW1.14 RPM
3083 BKW1.20 RPM
3148 BKW1.27 RPM
3211 BKW1.34 RPM
3272 BKW1.41
1200
2000 566 944 2417
2913 0.35 1.07 2519
2980 0.39
1.14 2615
3046 0.44
1.21 2710
3110 0.48
1.28 2800
3174 0.53
1.35 2889
3236 0.57
1.42 2973
3298 0.62
1.49 3057
3358 0.66
1.57 3138
3417 0.71
1.64 3218
3476 0.76
1.72
Model
PAC4A
1400
2200
AIR FLOW
1600
2400 755
1038 2718
661 3185 0.50
0.2 (50)
1133 3053
3447
Ii
1.40 2807
0.71
3247 0.55
1.77 3134
3505
1.48 2895
0.4 (100)
0.77
3308 0.60
1.86 3213
3562
1.55 2978
0.6 (150)
0.82
3367
1.94 3289
3617
EXTERNAL
0.65
0.8 (200)
0.88
STATIC
1.63 3061
3425 0.70
1 (250)
1.90 3364
3671 0.94
PRESSURE-inch
1.70 3141
3483 0.75
1.2 (300)
1.86 3437
3662 1.00
wg.(Pa)
1.78 3221
3541 0.80
1.86
1.4 (350)
1.99 3509
3652 1.05
2.11
3297
3597 0.85
1.94
1.6 (400)
3580
3768 1.11
2.10
3373
3652 0.90
2.02 3445
1.8 (450)
3649
3883 1.17
3706 0.96
Iii
2.10
2 (500)
2.45 3716
3934 1.23
2.27
52013 CFM
1800 L/S
850 RPM BKW
2665 RPM BKW
0.81 2739 RPM BKW
0.88 2811 RPM BKW
0.94 2881 RPM BKW
1.01 2950 RPM 1.14
1.07 3017 BKW 3083
RPM 1.20BKW RPM
3148 BKW
1.27 RPM 1.34
3211 BKW 3272
RPM 1.41
BKW
Region “I” shows
1200 standard
566 motor
2417 1.07 size 1.5kw
0.35 2980
2519 1.14
0.39 3046
2615 1.21
0.44 3110
2710 1.28
0.48 3174
2800 1.35
0.53 3236
2889 1.42
0.57 3298
2973 1.49
0.62 3057 0.66 3138 1.64
0.71 3476
Table
3218 1.72
12
0.76
2000 944 2913 3358 1.57 3417
Region “II” shows
2200 alternate
1400 661
1038 motor1.40
2718
3185 size3247
0.50 2.2kw1.48
2807 0.55 3308
2895 1.55
0.60 3367
2978 1.63
0.65 3425
3061 1.70
0.70 3483
3141 1.78
0.75 3541
3221 1.86
0.80 3297
3597 0.85
1.94 3373 0.90 3445
3652 2.02 3706 2.10 0.96
Region “III” shows
2400 alternate
1600 755
1133 motor1.77
3053
3447 0.71size3505
3.0kw
3134 0.77
1.86 3213 1.94
3562 0.82 3617
3289 1.90
0.88 3671
3364 1.86
EXTERNAL
0.94 3662
3437 1.99
1.00 3652
STATIC PRESSURE-inch
3509 2.11
wg.(Pa)
3580 2.10
1.05 3768 1.11 3883
3649 2.45
1.17 3934
3716 2.27
1.23
Model
52013 AIR FLOW
1800 850 26650.2 (50)
0.81 2739 0.88 2811 0.94 2881 1.01 2950 1.07 3017 1.14 3083 1.20 3148 1.27 3211 1.34 3272 1.41
0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A 2000 944 2913 1.07 2980 1.14 3046 1.21 3110 1.28 3174 1.35 3236 1.42 3298 1.49 3358 1.57 3417 1.64 3476 1.72
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
2200 3185 1.40 3247 1.48 3308 1.55 3367 1.63
1500 1038 708 2732 0.52 2825 0.57 2910 0.62 2995 0.67 3425
3076 1.70
0.72 3483
3157 1.78
0.78 3541
3234 1.86
0.83 3597
3311 1.94
0.89 3652
3385 2.02
0.94 3706
3459 2.10 0.99
2400
1600 1133 755 3447
2841 1.77 0.58 3505
2931 1.86
0.63 3562
3013 1.94
0.69 3617 1.90
0.74 3671
EXTERNAL
3094 STATIC
3173 1.86 3662
3252 1.99
PRESSURE-inch
0.80 3652
3327 2.11
0.85 wg.(Pa) 0.91 3768
3401 2.10
0.97 3883
3473 2.45
1.03 3934
3545 2.27 1.08
Model AIR FLOW
1800 850 0.2 (50)0.79 3229
3150 0.4 (100) 0.6 (150)
0.85 3308 0.91 0.8 (200)
3381 1 (250)1.03 3524
0.97 3454 1.2 (300) 1.4 (350)
1.10 3594 1.6 (400)
1.16 3663 1.23 1.8 (450)
3731 1.29 2- (500) -
PAC4A
2000 L/S
CFM 944 2664 BKW
RPM 0.83 RPM
2737 BKW0.90 RPM
2808 BKW0.97 2878 BKW
RPM 1.04 RPM
2946 BKW1.11 RPM
3013 BKW1.18 RPM
3078 BKW1.25 RPM
3142 BKW1.32 3205 BKW
RPM 1.39 3267 BKW
RPM 1.46
52015
1500
2200 708 1038 2732
2891 0.52 1.05 2825
2959 0.57
1.13 2910
3025 0.62
1.20 2995
3090 0.67
1.28 3076
3153 0.72
1.36 3157
3216 0.78
1.44 3234
3277 0.83
1.51 3311
3337 0.89
1.59 3385
3396 0.94
1.66 3459
3454 0.99 1.74
Model
PAC4A
1600
2400 755
AIR FLOW
1800
2600 850
1133
1227
2841
3114 0.58
0.2 (50)
3150
3336
I
1.32 2931
0.79
3178 0.63
1.63 3229
3396
1.40 3013
0.4 (100)
0.85
3240 0.69
1.72 3308
3455
1.48
0.6 (150)
0.91
1.81
3094
3301EXTERNAL
0.74
0.8 (200)
3381
3513 0.97
STATIC
1.57 3173
3360 0.80
1 (250)
1.90 3454
3569 1.03
PRESSURE-inch
1.65 3252
3418 0.85
1.2 (300)
1.99 3524
3624 1.10
wg.(Pa)
1.73 3327
3476 0.91
1.81 3401
1.4 (350)
2.08 3594
3678 1.16
3533 0.97
1.90
1.6 (400)
2.17 3663
3732 1.23
2.23
3473
3589 1.03
1.92
1.8 (450)
3731
3785 1.29
2.26
3545
3644 1.08 1.88
- -2 (500)- -
CFM
2000
2800 944L/S
1321 RPM
3581 BKW
2664 0.83 RPM
3638 BKW
2.01 2737 0.90 RPM
3693 BKW
2.10 2808 0.97 RPM
3747 BKW
2.20 2878 1.04 RPM
3798 BKW
2.30 2946 1.11 RPM
2.40 3013 BKW
3849 1.18 RPM
2.49 3078 BKW
3901 1.25 RPM
2.59 3142 BKW
3952 1.32 RPM
2.68 3205 BKW
- 1.39- RPM
3267
- BKW
1.46
-
52015
1500
2200 708
1038 2732 0.52 2959
2891 1.05 2825 1.13
0.57 3025
2910 1.20
0.62 3090
2995 1.28
0.67 3153
3076 1.36
0.72 3216
3157 1.44
0.78 3277
3234 1.51
0.83 3337
3311 1.59
0.89 3396
3385 1.66
0.94 3454
3459 0.99
1.74
2841 0.58 2931 1.40
0.63 3240
1600
2400
1800
2600
755
1133
850
1227
3114
3150
3336 Ii 1.32
0.79
1.63
3178
3229 1.72
3396
3013
0.85 3455
3308
0.69 3301
1.48 3094 1.57
0.91 3513
1.81
0.74 3360
3381 1.90
3173 1.65
0.97 3569
0.80 3418
3454 1.99
3252 1.73
1.03 3624
0.85 3476
3524 2.08
3327 1.81
1.10 3678
0.91
3594 2.17
1.16
3401 1.90
3533 0.97 3589
3663 2.23
3732
3473
1.23 3785
3731
1.03
1.92
1.29
2.26
3545
3644
Iii
-- --
1.08
1.88
2000
2800 944
1321 2664
3581 0.83
2.01 2737 2.10
3638 0.90 3693
2808 0.97 3747
2.20 2878 EXTERNAL
1.04 3798
2.30 2946 1.11PRESSURE-inch
2.40
STATIC 3013 2.49
3849 1.18 3901
3078 1.25
wg.(Pa)2.59 3142 2.68
3952 1.32 3205
- 1.39
- 3267
- 1.46
-
52015
Model AIR FLOW
2200 1038 28910.2 (50)
1.05 2959 1.13 3025
0.4 (100) 1.20
0.6 (150) 3090 1.28
0.8 (200) 3153 1.36
1 (250) 3216 1.44
1.2 (300) 3277 1.51
1.4 (350) 3337 1.59 3396
1.6 (400) 1.66 3454
1.8 (450) 2 (500)1.74
Region “I” shows
PAC4A
2400
standard motor size 1.5kw Table 13
CFM 1133 L/S 3114
RPM 1.32 BKW 3178
RPM 1.40BKW 3240
RPM 1.48
BKW 3301
RPM 1.57
BKW 3360
RPM 1.65
BKW 3418
RPM 1.73
BKW 3476
RPM 1.81
BKW 3533
RPM BKW 1.90 3589
RPM BKW 1.92 3644
RPM BKW 1.88
Region “II” shows
2600 alternate
1600 1227
motor
755 3336
2239 1.63
size 2.2kw
0.49 3396
2327 1.72
0.54 3455
2410 1.81
0.60 3513
2492 1.90
0.66 3569
2570 1.99
0.72 3624
2647 2.08
0.77 3678
2722 2.17
0.83 3732
2796 2.23
0.89 3785
2866 2.260.95 2935- 1.01-
Region “III” shows
1800 alternate
2800 motor2.01
2473
850 3581
1321 size 3638
0.66 3.0kw
2551 2.10
0.72 2628 2.20
3693 0.78 3747
2702 0.85 3798
2.30
EXTERNAL 2776 0.91
2.40
STATIC 2846 2.49
3849 0.98 wg.(Pa)
PRESSURE-inch 2916 2.59
3901 1.04 2983 2.68
3952 1.11 3050
- 1.17
- 3115
- 1.24-
Model AIR FLOW
2000 944 2664
0.2 (50)0.83 2737 0.90 2808
0.4 (100) 0.97 2878
0.6 (150) 1.04 2946
0.8 (200) 1 (250)1.11 3013 1.18 3078
1.2 (300) 1.25
1.4 (350) 3142 1.32 3205
1.6 (400) 1.39 3267
1.8 (450) 2 (500)1.46
PAC4A
2200 L/S
CFM 1038 2891 BKW
RPM 1.05 RPM
2959 BKW
1.13 RPM
3025 BKW
1.20 RPM
3090 BKW
1.28 RPM
3153 BKW
1.36 RPM
3216 BKW
1.44 RPM
3277 BKW
1.51 3337 BKW
RPM 1.59 RPM
3396 BKW 1.66 RPM
3454 BKW 1.74
2400 755
1600 1133 3114 0.49
2239 1.32 2327
3178 0.54
1.40 2410
3240 0.60
1.48 2492
3301 0.66
1.57 2570
3360 0.72
1.65 2647
3418 0.77
1.73 2722
3476 0.83
1.81 3533 0.89
2796 1.90 2866
3589 0.951.92 2935
3644 1.01 1.88
52018 2600 850
1800 1227 2483 0.66
2473 1.10 2551
2542 0.72
1.18 2628
2600 0.78
1.26 2702
2657 1.34 2776
0.85
EXTERNAL 2712
STATIC 1.42
0.91 2765 0.98
2846 1.50 2916
PRESSURE-inch 2817 1.04
wg.(Pa) 1.58 2869 1.11
2983 1.66 3050
2920 1.171.74 3115
2970 1.24 1.82
Model AIR FLOW
2800 944
2000 1321 2663
2664 1.37 2737
0.83
0.2 (50) 2719 1.45 2808
0.90
0.4 (100) 2773 0.97
1.54 2878
0.6 (150) 2827 1.62 2946
1.04
0.8 (200) 2878 1.71 3013
1.11
1 (250) 2929 1.79 3078
1.18
1.2 (300) 2979 1.88
1.25
1.4 (350) 3028
3142 1.96 3205
1.32
1.6 (400) 3076 2.05 3267
1.39
1.8 (450) 3123 2.13
1.46
2 (500)
PAC4A
3000 1038
2200
CFM 1416
L/S 2812 BKW
2891
RPM 1.62 2959
1.05 2865 BKW
RPM 1.71 3025
1.13 2918 BKW
RPM 1.80 3090
1.20 2968 BKW
RPM 1.89 3153
1.28 3018 BKW
RPM 1.98 3216
1.36 3065 1.44
RPM 2.07 3277
BKW 3113 1.51
RPM 2.16
BKW 3159 1.59
3337
RPM 2.24 3396
BKW 3205 1.66
RPM 2.33 3454
BKW 3249 1.74
RPM 2.42
BKW
3200
2400
1600 1510
1133
755 2239
3114 0.49
2986 1.32 2327
1.95 3178 0.54
3036 1.40 2410
2.04 3240 0.60
3085 1.48 2492
2.14 3301 0.66
3132 1.57 2570
2.23 3360 0.72
3178 1.65 2647
2.33 3418 0.77
3223 1.73 2722
2.42 3476 2.50 3533
0.83
3267 1.81 3311 1.90
2796 2.59 3589
0.89 3353 1.92
2866 2.69 3644
0.95 3396 1.88
2935 2.79
1.01
52018 1800
3400
2600 850
1605
1227 2473
2483 0.66
3156 1.10 2551
2.31 2542 0.72
3203 1.18 2628
2.41 2600 0.78
3247 1.26 2702
2.52 2657 0.85
3291 1.34 2776
2.62 2712 0.91
3334 1.42 2846
2.70 2765 0.98
3376 1.50 2916
2.78 2817 1.04
3417 1.58 2983
2.88 2869 1.11
3458 1.66 3050
2.99 2920 1.17
3498 1.74 3115
3.09 2970 1.24
3538 1.82
3.20
2000
2800
3600 944
1321
1699 2664
2663 0.83
3321 1.37 2737
2.72 2719 0.90
3363 1.45 2808
2.83 2773 0.97
3404 1.54 2878
2.92 2827 1.04
3444 1.62 2946
2.99 2878 1.11
3484 1.71 3013
3.09 2929 1.18
3523 1.79 3078
3.20 2979 1.25
3562 1.88 3142
3.31 3028 1.32
3600 1.96 3205
3.42 3076 1.39
3619 2.05 3267
3.48 3123 1.46
3619 2.13
3.48
2200
3000
2400
3200
1038
1416
1133
1510
I
2891
2812
3114
2986
1.05
1.62
1.32
1.95
2959 1.71
2865 1.13 2918
3178 2.04
3036
3025 1.80
1.40 3085
1.20 2968
3240 2.14
3090 1.89
1.48 3132
1.28 3018
3301 2.23
3153 1.98
1.57 3178
1.36 3065
3360 2.33
3216 2.07
1.65 3223
1.44 3113
3418 2.42
3277 2.16
1.73 3267
1.51
3476 2.50
1.81
3337 2.24
3159 1.59 3205
3533 2.59
3311 1.90
3396 2.33
1.66
3589 2.69
3353 1.92
3454
3249
3644 2.79
3396 1.88
1.74
2.42
52018 2600
3400 1227
1605 2483
3156 1.10
2.31 2542 2.41
3203 1.18 3247
2600 2.52
1.26 3291
2657 2.62
1.34 3334
2712 2.70
1.42 3376
2765 2.78
1.50 3417
2817 2.88
1.58 2869 2.99
3458 1.66 2920 3.09
3498 1.74 2970 3.20
3538 1.82
2800
3600 1321
1699 2663
3321 1.37
2.72 2719 2.83
3363 1.45 3404
2773 2.92
1.54 3444
2827 EXTERNAL
1.62 3484
2.99 2878 1.71PRESSURE-inch
STATIC
3.09 2929 3.20
3523 1.79 3562
2979 1.88
wg.(Pa)3.31 3028 3.42
3600 1.96 3076 3.48
3619 2.05 3123 3.48
3619 2.13
Model AIR FLOW
3000 1416 28120.2 (50)
1.62 2865 1.71 2918
0.4 (100) 1.80 2968
0.6 (150) 1.89 3018
0.8 (200) 1.98 3065
1 (250) 2.07 3113
1.2 (300) 2.16
1.4 (350) 3159 2.24
1.6 (400) 3205 2.33
1.8 (450) 3249
2 (500)2.42
PAC4A
3200
CFM 1510 L/S 2986
RPM 1.95 BKW 3036RPM 2.04
BKW 3085
RPM 2.14BKW 3132
RPM 2.23BKW 3178
RPM 2.33BKW 3223
RPM 2.42BKW 3267
RPM 2.50BKW 3311
RPM BKW 2.59 3353
RPM BKW 2.69 3396
RPM BKW 2.79
2000 1605
3400 Ii
1891 2.31
944 3156 0.49 3203
1971 2.41
0.55 3247
2043 2.52
0.61 3291
2115 2.62
0.67 3334
2182 2.70
0.74 3376
2249 2.78
0.80 3417
2313 2.88
0.86 2376 2.99
3458 0.92 2437 3.09
3498 0.99 2498 3.20
3538 1.06
Model
2200 1699
3600
AIR FLOW
2024 2.72
1038 3321 0.61 3363
2098 2.83
0.67 3404
2169 2.92
0.74 3444
2237 0.80 3484
2.99
EXTERNAL 2302
STATIC 0.87
3.09 2365 3.20
3523 0.94 wg.(Pa)
PRESSURE-inch 2426 3.31
3562 1.01 2485 3.42
3600 1.08 2544 3.48
3619 1.15Iii 2601 3.48
3619 1.22
2400 1133 2159
0.2 (50)0.73 2227
0.4 0.80 2295
(100) 0.6 0.87 2359
(150) 0.8 0.95 2422
(200) 1 (250)1.02 2482
1.2 1.09 2541
(300) 1.4 1.16
(350) 2597 1.24
1.6 (400) 2653 1.31
1.8 (450) 2707
2 (500)1.39
Region
PAC4A“I” shows standard motor size 2.2kw
2600 L/S 2290 BKW 0.88 RPM
2357 BKW
0.95 RPM
2422 BKW1.03 RPM
2483 BKW1.10 RPM
2542 BKW1.18 RPM
2600 BKW1.26 RPM
2657 BKW1.34 2712 BKW1.42 2765 BKW 1.50
Table
2817 BKW
14
1.58
CFM 1227 RPM RPM RPM RPM
Region “II” shows
2800 alternate
2000
motor
2420 0.49
1321 1891
944
size
1.04 3.0kw
2486 0.55
1971 1.12 2043
2546 0.61
1.20 2115
2606 0.67
1.28 2182
2663 0.74
1.37 2249
2719 0.80
1.45 2313
2773 0.86
1.54 2827 0.92
2376 1.62 2878 0.99
2437 1.71 2929
2498 1.06 1.79
Region “III” shows
3000 alternate
2200 motor0.61
1975
1416 2024
1038 size 2098
1.01 4.0kw
2032 0.67
1.10 2169
2089 0.74
1.18 2237
2144EXTERNAL STATIC PRESSURE-inch wg.(Pa) 1.53
1.27
0.80 2199
2302 1.35
0.87 2252
2365 1.44
0.94 2305
2426 1.01 2358 1.08
2485 1.62 2410 1.15
2544 1.71 2461 1.22
2601 1.80
Model AIR FLOW
3200 2065
1510 2159 1.16 2227
2120 1.25 2295
2175 1.34 2359
2228 1.43 2422
2280 1.52 2482
2331 1.61 2541
2381 1.71 2431 1.80 2481 1.90 2530 1.99
52020 2400 1133 0.73
0.2 (50) 0.80
0.4 (100) 0.87
0.6 (150) 0.95
0.8 (200) 1.02
1 (250) 1.09
1.2 (300) 1.16
1.4 (350) 2597 1.24
1.6 (400) 2653 1.31
1.8 (450) 2707 1.39
2 (500)
PAC4A 3400 1227 2184 BKW
1605 2290 1.38 2357
2237 BKW
1.47 2422
2289 BKW1.57 2483
2340 BKW1.66 2542
2389 BKW1.76 2600
2439 1.26
1.86 2657
2487 1.34
1.96 2535 1.42
2.06 2582 1.502.16 2629 1.582.26
2600
CFM L/S RPM 0.88 RPM 0.95 RPM 1.03 RPM 1.10 RPM 1.18 RPM BKW RPM BKW 2712
RPM BKW 2765
RPM BKW 2817
RPM BKW
3600
2800
2000 13212275 1.04
1699
2420
1891
944 1.56 2486
0.49 2325 1.12
1971 1.66 2546
0.55 2376 1.20
2043 1.76 2606
0.61 2424 1.28
2115 1.86 2663
0.67 2473 1.37
2182 1.97
0.74 2520 1.45
2719
2249 2.07 2773
0.80 2567 1.54
2313 2.18 2827
0.86 2612 1.62
2376 2.28 2878
0.92 2658 1.71
2437 2.38 2929
0.99 2703 1.79
2498 2.49
1.06
Notes: 3800
3000
2200 14162387 1.01
1793
1975
2024
1038 1.80 2032
0.61 2436 1.10
2098 1.91 2089
0.67 2484 1.18
2169 2.01 2144
0.74 2531 1.27
2237 2.12 2199
0.80 2576 1.35
2302 2.23
0.87 2622 1.44
2252
2365 2.34 2305
0.94 2666 1.53
2426 2.44 2358
1.01 2710 1.62
2485 2.55 2410
1.08 2754 1.71
2544 2.66 2461
1.15 2797 1.80
2601 2.77
1.22
(1).52020
For data3200
specified
4000
2400 1888 in2065
1510
1133 BOLD,
2497 1.16
2159 0.73kindly
2.05 2543 consult
2120
2227 1.25
0.80 for1.34
2.16 2175
2589
2295 drive
2.27
0.87 set1.43
2633
2228
2359 selection.
2.39
0.95 2677 1.52
2280
2422 2.50
1.02 2720 1.61
2331
2482 2.61 2381
1.09 2762 1.71
2541 2.72 2431
1.16 2804 1.80
2597 2.84 2481
1.24 2846 1.90
2653 2.95 2530
1.31 2887 1.99
2707 3.07
1.39
(2). Internal 3400
static
4200 pressure
2600 1605
1227 2604is based
1982 2184
2290 1.38
0.88 on 1.47
2.32 2237
2357
2649 pressure
2.43 2289
0.95 2422 drops
2691 1.57
1.03 through
2.55 2340
2483
2733 1.66
1.10 the evaporator
2.67 2389
2542
2774 1.76
2.79 2439
1.18 2600 coil,
2815 1.86
1.26
2.90 fan1.96
2487
2657
2855 casing,
1.34
3.02 2896 droplet
2535
2712 2.06
3.14 2582
1.42 eliminator,
2765
2935 2.16
3.26 2629
1.50 - 1” 2.26
2817 flat- filter
1.58 G2 and F8
15” bag3600
filter. 1699
2800
4400 2077 2275
1321 2730 1.56
2420 2.49 2325
1.04 2771 1.66
2486 2.61 2376
1.12 2811 1.76
2546 2.73 2424
1.20 2850 1.86
2606 2.84 2473
1.28 2888 1.97
2663 2.96 2520
1.37 2927 2.07
2719 3.08 2567
1.45 2965 2.18
2773 3.20 2612
1.54 3002 2.28
2827 3.33 2658
1.62 - 2.38
2878 1.71
- 2703
2929
- 2.49
1.79
-
(3). USM option
3000 for
3800 region
1416
1793 2387III, please
1975 1.01 2436
1.80 consult
2032 1.91 SKM.
1.10 2484
2089 1.18 2531
2.01 2144 2.12
1.27 2576
2199 2.23
1.35 2622
2252 2.34
1.44 2666
2305 2.44
1.53 2710
2358 2.55
1.62 2754
2410 2.66
1.71 2797
2461 2.771.80
52020 3200
4000 1510
1888 2065
2497 2.051.16 2543
2120 2.16
1.25 2589
2175 2.27
1.34 2633
2228 2.39
1.43 2677
2280 2.50
1.52 2720
2331 2.61
1.61 2762
2381 2.72
1.71 2804
2431 2.84
1.80 2846
2481 2.95
1.90 2887
2530 3.071.99
3400
4200 1605
1982 2184 2.32
2604 1.38 2649
2237 2.43
1.47 2691
2289 2.55
1.57 2733
2340 2.67
1.66 2774
2389 2.79
1.76 2815
2439 2.90
1.86 2855
2487 3.02
1.96 2896
2535 3.14
2.06 2935
2582 3.26
2.16 2629
- 2.26
-
3600
4400 1699
2077 2275
2730 1.56
2.49 2325 2.61
2771 1.66 2811
2376 2.73
1.76 2850
2424 2.84
1.86 2888
2473 2.96
1.97 2927
2520 3.08
2.07 2965
2567 3.20
2.18 3002
2612 3.33
2.28 2658
- 2.38
- 2703
- 2.49
-
3800 1793 2387 1.80 2436 1.91 2484 2.01 2531 2.12 2576 2.23 2622 2.34 2666 2.44 2710 2.55 2754 2.66 2797 2.77
4000 1888 2497 2.05 2543 2.16 2589 2.27 2633 2.39 2677 2.50 2720 2.61 2762 2.72 2804 2.84 2846 2.95 2887 3.07
4200 1982 2604 2.32 2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02 2896 3.14 2935 3.26 - -
4400 2077 2730 2.49 2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20 3002 3.33 - - - -
12
2000 944 2664 0.83 2737 0.90 2808 0.97 2878 1.04 2946 1.11 3013 1.18 3078 1.25 3142 1.32 3205 1.39 3267 1.46
2200 1038 2891 1.05 2959 1.13 3025 1.20 3090 1.28 3153 1.36 3216 1.44 3277 1.51 3337 1.59 3396 1.66 3454 1.74
2400 1133 3114 1.32 3178 1.40 3240 1.48 3301 1.57 3360 1.65 3418 1.73 3476 1.81 3533 1.90 3589 1.92 3644 1.88
52018 2600
2800
1227
1321
2483
2663
1.10 2542 1.18 2600 1.26 2657 1.34 2712 1.42 2765 1.50 2817 1.58 2869 1.66 2920 1.74
1.37 2719 1.45 2773 1.54 2827 1.62 2878 1.71 2929 1.79 2979 1.88 3028 1.96 3076 2.05
2970 1.82
3123 2.13 R410-A
3000 1416 2812 1.62 REFRIGERANT
2865 1.71 2918 1.80 2968 1.89 3018 1.98 3065 2.07 3113 2.16 3159 2.24 3205 2.33 3249 2.42
3200 1510 2986 1.95 3036 2.04 3085 2.14 3132 2.23 3178 2.33 3223 2.42 3267 2.50 3311 2.59 3353 2.69 3396 2.79
3400 1605 3156 2.31 3203 2.41 3247 2.52 3291 2.62 3334 2.70 3376 2.78 3417 2.88 3458 2.99 3498 3.09 3538 3.20
3600 1699 3321 2.72 3363 2.83 3404 2.92 3444 2.99 3484 3.09 3523 3.20 3562 3.31 3600 3.42 3619 3.48 3619 3.48
FAN PERFORMANCE
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
2000 944 1891 0.49 1971 0.55 2043 0.61 2115 0.67 2182 0.74 2249 0.80 2313 0.86 2376 0.92 2437 0.99 2498 1.06
2200 1038 2024 0.61 2098 0.67 2169 0.74 2237 0.80 2302 0.87 2365 0.94 2426 1.01 2485 1.08 2544 1.15 2601 1.22
2400 1133 2159 0.73 2227 0.80 2295 0.87 2359 0.95 2422 1.02 2482 1.09 2541 1.16 2597 1.24 2653 1.31 2707 1.39
2600
2800
1227
1321
I 2290
2420
0.88
1.04
2357 0.95 2422 1.03 2483 1.10 2542 1.18 2600 1.26 2657
2486 1.12 2546 1.20 2606 1.28 2663 1.37 2719 1.45 2773 1.54 2827 1.62 2878 1.71
1.34 2712 1.42 2765 1.50 2817
2929
1.58
1.79
3000 1416 1975 1.01 2032 1.10 2089 1.18 2144 1.27 2199 1.35 2252 1.44 2305 1.53 2358 1.62 2410 1.71 2461 1.80
52020 3200 1510 2065 1.16 2120 1.25 2175 1.34 2228 1.43 2280 1.52 2331 1.61 2381 1.71 2431 1.80 2481 1.90 2530 1.99
3400 1605 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86 2487 1.96 2535 2.06 2582 2.16 2629 2.26
3600
3800
1699
1793
2275
2387Ii 1.56
1.80
2325 1.66 2376 1.76 2424 1.86 2473 1.97 2520 2.07 2567 2.18 2612 2.28 2658 2.38
2436 1.91 2484 2.01 2531 2.12 2576 2.23 2622 2.34 2666 2.44 2710 2.55 2754 2.66
2703
2797
2.49
2.77
4000 1888 2497 2.05 2543 2.16 2589 2.27 2633 2.39 2677 2.50 2720 2.61 2762 2.72 2804 2.84 2846 2.95 2887 3.07
4200
4400
1982
2077
2604
2730
2.32
2.49
2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02 2896 3.14 2935 3.26
2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20 3002 3.33 - -
Iii
-
- -
-
Region “I” shows standard motor size 2.2kw Table 15
Region “II” shows alternate motor size 3.0kw
Region “III” shows alternate motor size 4.0kw
52025
3800
3400
4000
3600
1793
1605
1888
1699
2260
2073
2376
2168
1.54 2130
1.19
1.77
1.36
2312 1.28
1.64 2184
2362 1.74
2425 1.46
2221
1.38 2412
1.88 2275
2473
2237 1.85
1.47 2460
1.99
1.56
2289 1.96
2520
1.57 2507
2325 2.11
2340 2.06
1.66 2566
2376
1.66 2554
2389 2.17
2.22
1.76
1.76 2611
2424 2.33
1.86 2655
2473 2.44
1.97
2599
2439 2.28
2698
1.86 2644
2520 2.56
2487 2.39
2.07 2741
1.96 2688
2567 2.67
2535
2.18 2783
2612
Ii 2.50
2.06
2.78
2.28
4200
3800 1982
1793 2466
2260 1.96
1.54 2513 1.64
2312 2.08 2362
2559 2.21
1.74 2604
2412 2.32
1.85 2649
2460 2.43
1.96 2691
2507 2.55
2.06 2733
2554 2.67
2.17 2774
2599 2.79
2.28 2815
2644 2.90
2.39 2855
2688 3.02
2.50
4400
4000 2077
1888 2578
2376 2.08
1.77 2623 1.88
2425 2.21 2473
2666 2.32
1.99 2710
2520 2.43
2.11 2750
2566 2.55
2.22 2791
2611 2.67
2.33 2830
2655 2.79
2.44 2869
2698 2.90
2.56 2908
2741 3.02
2.67 2947
2783 3.14
2.78
4600
4200 2171
1982 2600
2466 2.15
1.96 2645 2.08
2513 2.26 2559
2688 2.38
2.21 2730
2604 2.49
2.32 2771
2649 2.61
2.43 2811
2691 2.73
2.55 2850
2733 2.84
2.67 2888
2774 2.96
2.79 2927
2815 3.08
2.90 2965
2855 3.20
3.02
4400 2077 2578 2.08 2623 2.21 2666 2.32 2710 2.43 2750 2.55 2791 2.67 2830 2.79 2869 2.90 2908 3.02 2947 3.14
4600 2171 2600 2.15 2645 2.26 2688 2.38 2730 2.49 2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 Iii2965 3.20
Region “I” shows standard motor size 2.2kw EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Table 17
AIR FLOW
Model“II” shows
Region alternate motor size 3.0kw
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
Region “III” shows
CFM alternate
L/S motorBKW
RPM size 4.0kw
RPM BKW RPM BKW RPMEXTERNAL BKW RPM BKWPRESSURE-inch
STATIC RPM BKW RPM wg.(Pa)BKW RPM BKW RPM BKW RPM BKW
Model AIR FLOW
3000 1416 1753 0.71 1820 0.80 1884 0.88 1945 0.97 2004 1.05 2061 1.14 2117 1.22 2172 1.31 2226 1.40 22792 (500)
1.49
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450)
PAC4A
Notes: 3200
CFM
1510
L/S
1853 0.85 1918 0.93 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66
RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3400 1605 1954 1.00 2015 1.09 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86
(1). For data3000 1416 in1753
specified BOLD, 0.71kindly
1820 consult
0.80 1884
for 0.88
drive1945
set 0.97 2004 1.05 2061 1.14 2117 1.22 2172 1.31 2226 1.40 2279 1.49
selection.
3600 1699 2023 1.12 2082 1.21 2139 1.31 2195 1.41 2248 1.51 2300 1.61 2350 1.71 2400 1.81 2448 1.91 2496 2.02
3200
(2). Internal static 1510 1853
pressure 0.85 1918 0.93 1978 drops
1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254droplet
1.47 2305 1.57 2356 1.66
3800 1793 2121is based
1.28 2177on pressure
1.38 2234 1.49 2286 through the evaporator
1.59 2338 1.69 2387 1.80 coil,2436
fan 1.91
casing,
2484 2.01 2531 eliminator,
2.12 2576 2.23
3400 G21605
1” flat filter and 195415”1.00
F8 bag 2015
filter.1.09 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86
4000 1888 2217 1.45 2272 1.56 2325 1.66 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44
(3). USM option 3600 1699 2023 1.12 2082 1.21 2139 1.31 2195 1.41 2248 1.51 2300 1.61 2350 1.71 2400 1.81 2448 1.91 2496 2.02
4200 for1982
region III, please
2313 1.64 2366 consult SKM.1.85
1.75 2416 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 - -
3800 1793 2121 1.28 2177 1.38 2234 1.49 2286 1.59 2338 1.69 2387 1.80 2436 1.91 2484 2.01 2531 2.12 2576 2.23
4400
4000 2077
1888 1869
2217 1.55 1918 1.67 1966 1.79 2013 1.91 2058 2.04 2102 2.16 2145 2.29 2188
1.45 2272 1.56 2325 1.66 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44 2.41 2230 2.54 2272 2.67
52030
4600 2171 1940 1.641.73 1987 1.86 2034 1.98 2079 2.11 2123 2.24 2165 2.37 2207 2.50 2248 2.63 2289 2.76 2329 2.90
4200 1982 2313 2366 1.75 2416 1.85 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 - -
52030
4800
4400
5000
2265
2077
2360
2010 1.93 2056 2.06 2101 2.19 2145 2.33 2188 2.46 2229 2.60 2270 2.73 2310 2.87 2350 3.00 2389 3.14
1869 1.55 1918 1.67 1966 1.79 2013 1.91 2058 2.04 2102 2.16 2145 2.29 2188 2.41 2230 2.54 2272 2.67
2080 2.14 2125 2.27 2168 2.41 2211 2.55 2252 2.69 2293 2.83 2332 2.97 2371 3.11 2410 3.25 2448 3.30
S.K.M Air Conditioning LLC
4600 2171 1940 1.73 1987 1.86 2034 1.98 2079 2.11 2123 2.24 2165 2.37 2207 2.50 2248 2.63 2289 2.76 2329 2.90
5200 2454 2149 2.36 2193 2.50 2235 2.64 2277 2.79 2317 2.93 2357 3.08 2395 3.22 2433 3.37 2471 3.52 2508 3.67
4800
5400
2265
2549
2010 1.93 2056 2.06 2101 2.19 2145 2.33 2188 2.46 2229 2.60 2270 2.73 2310 2.87 2350 3.00 2389 3.14
2218 2.59 2260 2.74 2302 2.88 2342 3.03 2382 3.18 2420 3.33 2458 3.48 2495 3.64 2531 3.79 2567 3.95
13
5000 2360 2080 2.14 2125 2.27 2168 2.41 2211 2.55 2252 2.69 2293 2.83 2332 2.97 2371 3.11 2410 3.25 2448 3.30
Model AIR FLOW
0.2 (50)1.10 2521
0.4 (100) 0.6 (150) 0.8 (200)1.35 1 (250)1.44 1.2
2757(300)1.53 2812
1.4 (350) 1.6 (400)
PAC4A 3000 1416 2456 1.18 2585 1.27 2644 2702 1.62 2865 1.71 1.8
2918(450)
1.80 2 -(500) -
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3200 1510 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66 2406 1.76 2456 1.85
2400 1133 2083 0.66 2159 0.73 2227 0.80 2295 0.87 2359 0.95 2422 1.02 2482 1.09 2541 1.16 2597 1.24 2653 1.31
3400 1605 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86 2487 1.96 2535 2.06
52025 2600 1227 2219 0.80 2290 0.88 2357 0.95 2422 1.03 2483 1.10 2542 1.18 2600 1.26 2657 1.34 2712 1.42 2765 1.50
SKM 100% FA Package Air Conditioning Units
3600
2800
3800
3000
1699
1321
1793
1416
2168
2354
2260
2456
1.36 2221 1.46 2275 1.56
0.96 2420 1.04 2486 1.12
1.54 2312 1.64 2362 1.74
1.10 2521 1.18 2585 1.27
2325 1.66
2546 1.20
2412 1.85
2644 1.35
2376 1.76
2606 1.28
2460 1.96
2702 1.44
2424 1.86 2473 1.97 2520 2.07 2567 2.18
2663 1.37 2719 1.45 2773 1.54 2827 1.62
2507 2.06 2554 2.17 2599 2.28 2644 2.39
2757 1.53 2812 1.62 2865 1.71 2918 1.80
PAC4A Series
2612 2.28
2878
2688
-
1.71
-
2.50
4000 1888 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44 2698 2.56 2741 2.67 2783 2.78
3200 1510 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66 2406 1.76 2456 1.85
4200 1982 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02
3400 1605 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86 2487 1.96 2535 2.06
52025 4400 2077 2578 2.08 2623 2.21 2666 2.32 2710 2.43 2750 2.55 2791 2.67 2830 2.79 2869 2.90 2908 3.02 2947 3.14
3600 1699 2168 1.36 2221 1.46 2275 1.56 2325 1.66 2376 1.76 2424 1.86 2473 1.97 2520 2.07 2567 2.18 2612 2.28
4600 2171 2600 2.15 2645 2.26 2688 2.38 2730 2.49 2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20
3800 1793 2260 1.54 2312 1.64 2362 1.74 2412 1.85 2460 1.96 2507 2.06 2554 2.17 2599 2.28 2644 2.39 2688 2.50
FAN PERFORMANCE
4000 1888 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44 2698 2.56 2741 2.67 2783 2.78
4200 1982 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02
4400 2077 2578 2.08 2623 2.21 2666 2.32 27102.43 2750 2.55 2791 2.67 2830 2.79 2869 2.90 2908 3.02 2947 3.14
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model 4600 2171
AIR FLOW 2600 2.15 2645 2.26 2688 2.38 2730 2.49 2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3000 1416 1753 0.71 1820 0.80 1884 0.88 1945 0.97 2004 1.05 2061 1.14 2117 1.22 2172 1.31 2226 1.40 2279 1.49
3200 1510 1853 0.85 1918 0.93 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model 3400 1605
AIR FLOW 1954 1.00 2015 1.09 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A 3600 1699 2023 1.12 2082 1.21 2139 1.31 2195 1.41 2248 1.51 2300 1.61 2350 1.71 2400 1.81 2448 1.91 2496 2.02
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3800 1793 2121 1.28 2177 1.38 2234 1.49 2286 1.59 2338 1.69 2387 1.80 2436 1.91 2484 2.01 2531 2.12 2576 2.23
3000
4000
3200
1416
1888
1510
1753
2217
1853
I
0.71
1.45
0.85
1820 0.80 1884 0.88 1945 0.97 2004 1.05 2061 1.14 2117 1.22 2172 1.31 2226 1.40
2272 1.56 2325 1.66 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33
1918 0.93 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57
2279 1.49
2655 2.44
2356 1.66
4200 1982 2313 1.64 2366 1.75 2416 1.85 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 - -
3400 1605 1954 1.00 2015 1.09 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86
4400 2077 1869 1.55 1918 1.67 1966 1.79 2013 1.91 2058 2.04 2102 2.16 2145 2.29 2188 2.41 2230 2.54 2272 2.67
52030 3600 1699 2023 1.12 2082 1.21 2139 1.31 2195 1.41 2248 1.51 2300 1.61 2350 1.71 2400 1.81 2448 1.91 2496 2.02
4600 2171 1940 1.73 1987 1.86 2034 1.98 2079 2.11 2123 2.24 2165 2.37 2207 2.50 2248 2.63 2289 2.76 2329 2.90
3800 1793 2121 1.28 2177 1.38 2234 1.49 2286 1.59 2338 1.69 2387 1.80 2436 1.91 2484 2.01 2531 2.12 2576 2.23
4800 2265 2010 1.93 2056 2.06 2101 2.19 2145 2.33 2188 2.46 2229 2.60 2270 2.73 2310 2.87 2350 3.00 2389 3.14
4000 1888 2217 1.45 2272 1.56 2325 1.66 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44
5000 2360 2080 2.14 2125 2.27 2168 2.41 2211 2.55 2252 2.69 2293 2.83 2332 2.97 2371 3.11 2410 3.25 2448 3.30
4200 1982 2313 1.64 2366 1.75 2416 1.85 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 - -
52030
5200
4400
5400
4600
2454
2077
2549
2171
2149
2218 Ii
1869 1.55
2.36
2.59
1940 1.73
2193 2.50 2235 2.64 2277 2.79 2317 2.93 2357 3.08 2395 3.22 2433 3.37 2471 3.52
1918 1.67 1966 1.79 2013 1.91 2058 2.04 2102 2.16 2145 2.29 2188 2.41 2230 2.54
2260 2.74 2302 2.88 2342 3.03 2382 3.18 2420 3.33 2458 3.48 2495 3.64 2531 3.79
1987 1.86 2034 1.98 2079 2.11 2123 2.24 2165 2.37 2207 2.50 2248 2.63 2289 2.76
2508 3.67
2272 2.67
2567 3.95
2329 2.90
5600
4800 2643
2265 2286 2.83
2010 1.93 2328 2.06
2056 2.98 2101
2368 2.19
3.13 2145
2408 2.33
3.29 2188
2446 2.46
3.44 2229
2484 2.60
3.60 2270
2520 2.73
3.76 2310
2555 2.87
3.92 2350
2591 3.00
4.08 2626 3.14
2389 4.24
5800 2360
5000 2737 2355
2080 3.09
2.14 2396 2.27
2125 3.24 2168
2435 2.41
3.40 2211
2474 2.55
3.56 2252
2510 2.69
3.72 2293
2547 2.83
3.88 2332
2582 2.97
4.05 2371
2616 3.11
4.22 2410
2651 3.25
4.39 2686 3.30
2448 4.55
6000
5200 2832
2454 2444
2149 3.44
2.36 2193 2.50 2235 2.64 2277 2.79 2317 2.93 2357 3.08 2395 3.22 2433 3.37 2471 3.52-
2482 3.60 2521 3.77 2557 3.93 2593 4.10 2626 4.28 2660 4.46 2694 4.63 - Iii 2508 3.67-
-
Region “I” shows
5400 standard
2549 motor size
2218 2.59 3.0kw
2260 2.74 2302 2.88 2342 3.03 2382 3.18 2420 3.33 2458 3.48 2495 3.64 2531 3.79 2567 Table
3.95 18
Region “II” shows
5600 alternate
2643 motor2.83
2286 size 4.0kw
2328 2.98 2368 3.13 2408 3.29 2446 3.44 2484 3.60 2520 3.76 2555 3.92 2591 4.08 2626 4.24
5800 2737 2355 3.09 2396 3.24 2435 3.40 24743.56 2510 3.72 2547 3.88 2582 4.05 2616 4.22 2651 4.39 2686 4.55
Region “III” shows alternate motor size 5.5kw
Model 6000 2832
AIR FLOW 2444 3.44 2482 3.60 2521 3.77 2557 EXTERNAL
3.93 2593STATIC
4.10 PRESSURE-inch wg.(Pa)
2626 4.28 2660 4.46 2694 4.63 - - - -
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3000 1416 1753 0.71 1820 0.80 1884 0.88 1945 0.97 2004 1.05 2061 1.14 2117 1.22 2172 1.31 2226 1.40 2279 1.49
3200 1510 1853 0.85 1918 0.93 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
3400 1605 1954 1.00 2015 1.09 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A 3600 1699 2023 1.12 2082 1.21 2139 1.31 2195 1.41 2248 1.51 2300 1.61 2350 1.71 2400 1.81 2448 1.91 2496 2.02
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3800 1793 2121 1.28 2177 1.38 2234 1.49 2286 1.59 2338 1.69 2387 1.80 2436 1.91 2484 2.01 2531 2.12 2576 2.23
3000 1416 1753 0.71 1820 0.80 1884 0.88 1945 0.97 2004 1.05 2061 1.14 2117 1.22 2172 1.31 2226 1.40 2279 1.49
4000 1888 2217 1.45 2272 1.56 2325 1.66 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44
3200 1510 1853 0.85 1918 0.93 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66
4200 1982 2313 1.64 2366 1.75 2416 1.85 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 - -
3400 1605 1954 1.00 2015 1.09 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86
4400
3600 2077
1699 1869
2023 1.55
1.12 1918 1.21
2082 1.67 2139
1966 1.31
1.79 2195
2013 1.41
1.91 2248
2058 1.51
2.04 2300
2102 1.61
2.16 2350
2145 1.71
2.29 2400
2188 1.81
2.41 2448
2230 1.91
2.54 2272 2.02
2496 2.67
52035
4600
3800
4800
4000
2171
1793
2265
1888
1940
2121
2010
2217
I1.73
1.28
1.93
1.45
1987 1.38
2177 1.86 2234
2056 1.56
2272
2034 1.49
2.06 2325
1.98 2286
2101 1.66
2079 1.59
2.19 2376
2.11 2338
2145 1.77
2123 1.69
2.33 2425
2.24 2387
2188 1.88
2165 1.80
2.46 2473
2.37 2436
2229 1.99
2207 1.91
2.60 2520
2.50 2484
2270 2.11
2248 2.01
2.73 2566
2.63 2531
2310 2.22
2289 2.12
2.87 2611
2.76
2350 2.33
3.00
2329 2.23
2576
2389 2.44
2655
2.90
3.14
5000
4200 2360
1982 2080 1.64
2313 2.14 2125 2.27 2168 2.41 2211 2.55 2252 2.69 2293 2.83 2332 2.97
2366 1.75 2416 1.85 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 2371 3.11 2410 3.25 2448
- -3.30
5200
4400 2454
2077 2149 1.55
1869 2.36 1918
2193 1.67
2.50 1966
2235 1.79
2.64 2013
2277 2.79 2058
1.91 2317 2.04
2.93 2102
2357 2.16
3.08 2145
2395 2.29
3.22 2188
2433 2.41
3.37 2230
2471 2.54
3.52 2272
2508 2.67
3.67
52035 5400 2549
4600 2171 1940 1.73 1987 1.86 2034 1.98 2342
2218 2.59 2260 2.74 2302 2.88 2079 3.03 2123
2.11 2382 2.24
3.18 2165
2420 2.37
3.33 2207
2458 2.50
3.48 2248
2495 2.63
3.64 2289
2531 2.76
3.79 2329
2567 2.90
3.95
5600
4800 2643
2265 2286 1.93
2010 2.83 2056
2328 2.06
2.98 2101
2368 2.19
3.13 2145
2408 3.29 2188
2.33 2446 2.46
3.44 2229
2484 2.60
3.60 2270
2520 2.73
3.76 2310
2555 2.87
3.92 2350
2591 3.00
4.08 2389
2626 3.14
4.24
5800
5000 2737
2360 2355 2.14
2080 3.09 2125
2396 2.27
3.24 2168
2435 2.41
3.40 2211
2474 3.56 2252
2.55 2510 2.69
3.72 2293
2547 2.83
3.88 2332
2582 2.97
4.05 2371
2616 3.11
4.22 2410
2651 3.25
4.39 2448
2686 3.30
4.55
6000
5200 2832
2454 2444
2149 2.36 Ii
3.44 2193
2482 2.504 2521 2.64
2235 3.77 2277
2557 2.79
3.93 2317
2593 2.93
4.10 2357
2626 3.08
4.28 2395
2660 3.22
4.46 2433
2694 3.37
4.63 2471- 3.52- 2508- 3.67-
5400 2549 2218 2.59 2260 2.74 2302 2.88 2342 3.03 2382 3.18 2420 3.33 2458 3.48 2495 3.64 2531 3.79 2567 3.95
5600 2643 2286 2.83 2328 2.98 2368 3.13 2408 3.29 2446 3.44 2484 3.60 2520 3.76 2555 3.92 2591 4.08 2626 4.24
5800 2737 2355 3.09 2396 3.24 2435 3.40 2474 3.56 2510 3.72 2547 3.88 2582 4.05 2616 4.22 2651 4.39 2686 4.55
6000 2832 2444 3.44 2482 4 2521 3.77 2557 3.93 2593 4.10 2626 4.28 2660 4.46 2694 4.63 - - Iii - -
Region “I” shows standard motor size 3.0kw Table 19
Region “II” shows alternate motor size 4.0kw
Region “III” shows alternate motor size 5.5kw
Notes:
(1). For data specified in BOLD, kindly consult for drive set selection.
(2). Internal static pressure is based on pressure drops through the evaporator coil, fan casing, droplet eliminator, 1” flat filter G2 and F8
15” bag filter.
(3). USM option for region III, please consult SKM.
14
R410-A
REFRIGERANT
FAN PERFORMANCE
Notes:
(1). For data specified in BOLD, kindly consult for drive set selection.
(2). Internal static pressure is based on pressure drops through the evaporator coil, fan casing, droplet eliminator, 1” flat filter G2 and F8
15” bag filter.
(3). USM option for region III, please consult SKM.
FAN PERFORMANCE
60Hz
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKWRPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model 450
AIR FLOW212 2301 0.13 2451 0.14 2600 0.15 2734 0.17 2867 0.19 2988 0.21 3109 0.23 3221 0.26 3333 0.28 3439 0.30
PAC4A
61006
600
CFM
700
283
L/S
330
0.2 (50)
I 0.4 (100) 0.6 (150) 0.8 (200)
RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
1 (250)
2783 0.19 2909 0.21 3034 0.23 3151 0.26 3267 0.28 3376 0.31 3484 0.34
3154 0.28 3268 0.30 3381 0.325 3487 0.355 3593 0.385 3693 0.415 3793 0.445
1.2 (300) 1.4 (350) 1.6 (400)
3586 0.37
RPM BKW
3887 0.475
1.8 (450)
3688 0.39
RPM BKW
3982 0.505
2 (500)
3785 0.42
RPM BKW
4166 0.588
61006
450
800
600
212
378
283
2301 0.13 2451 0.14 2600 0.15 2734 0.17 2867 0.19 2988 0.21 3109 0.23
3526 0.36 3627 0.39 3727 0.42 3823 0.46 3918 0.49 4010 0.52 4101 0.55
2783 0.19 2909 0.21 3034 0.23 3151 0.26 3267 0.28 3376 0.31 3484 0.34
3221 0.26
4189 0.59
3586 0.37
3333 0.28
4276 0.62
3688 0.39
Ii
3439 0.30
-
3785 0.42
-
Model
700
1500
AIR FLOW
800
330
708
378
-
3459
- 0.2 (50)-
-
0.99 2075
3530 0.20
2239
1.05 2191
3600 0.22
0.26 2349
0.4 (100)
1.11 2303
0.29 2455
0.6 (150)
0.26
1.16 2411
3669EXTERNAL
0.8EXTERNAL
(200)
3737
STATIC
0.32 2558
1
0.29 2514
3803 0.33
0.36 2657
(250) 1.2
1.28 2613
1.22PRESSURE-inch
(300)
-
wg.(Pa)
0.40 2752
1.4
0.359
-
0.433
(350)
2710
-
2844
0.393
-
0.47
1.6 (400)
2805
-
2935
0.428
-
0.51
1.8 (450)
Ii --
3024
--
0.553
2 (500)
Region
PAC4A“I” shows
Model 1000 standard
AIR FLOW472 motorBKW
2493 size 1.1kw
0.36 2592 BKW0.40 2688 0.44 2781
STATIC PRESSURE-inch wg.(Pa)
0.48 2870 0.53 2957 0.57 3042 0.61 3126 0.66 3207 0.71 3286 Table
0.7522
62008 CFM L/S RPM 0.2 (50)size RPM
0.4 (100) RPM BKW
0.6 (150) RPM BKW
0.8 (200) RPM BKW
1 (250) RPM BKW
1.2 (300) RPM BKW
1.4 (350) RPM BKW
1.6 (400) RPM BKW
1.8 (450) RPM 2 (500)BKW
Region
PAC4A“II” shows
1200 alternate
566 motor
2844 0.55 1.5kw
2931 0.59 3015 0.64 3097 0.69 3178 0.74 3256 0.79 3331 0.84 3406 0.89 3480 0.94 3553 0.99
RPM BKW 2075 0.20 RPM
2191 BKW 0.22 RPM
2303 BKW 0.26 RPM
2411 BKW0.29 RPM
2514 BKW 0.33 RPM BKW
700 330 - - 2613 0.359 2710 0.393 2805 0.428 - -
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW
1400
800 661
378 3259
- 0.83
- 3335 0.26
2239 0.88 2349
3409 0.290.93 3481
2455 0.98
0.32
EXTERNAL 3553
2558
STATIC1.04
0.36 3624
2657 1.09
0.40
PRESSURE-inch 3693
2752
wg.(Pa) 1.15
0.433 3760
2844 1.20
0.47 3825
2935 1.26
0.51 3890
3024 1.32
0.553
Model 850
AIR FLOW401 - - 2184 0.24 2294 0.27 2404 0.30 2507 0.34 2609 0.38 2704 0.42 2799 0.45 2890 0.49 2980 0.53
1500
1000 708
472 3459
24930.2 0.99 2592
0.36
(50) 3530
0.4 1.05 3600
0.40
(100) 2688
0.6 1.11
0.44
(150) 3669
2781
0.8 1.16
0.48
(200) 3737
2870
1 1.22
0.53
(250) 3803
2957
1.2 1.28
0.57
(300) - (350)
3042
1.4 -
0.61 - (400)
3126
1.6 -
0.66 - (450)
3207
1.8 -
0.71 -2 (500)0.75
3286 -
PAC4A
62008 1000 472 2339 0.31 2442 0.35 2544 0.38 2640 0.42 2736 0.46 2825 0.51 2914 0.55 3000 0.59 3085 0.63 3166 0.68
1200
CFM
1200 566
L/S 2844 BKW
RPM
2662 0.55 RPM
0.46 2931 BKW
2755 0.59 RPM
0.50 3015 BKW
2844 0.64 2931
0.55 3097 BKW
RPM 0.69 3015
0.59 3178 BKW
RPM 0.74 3097
0.64 3256 BKW
RPM 0.79 3178
0.69 3331 BKW
RPM 0.84
0.74 3406 BKW
RPM
3256 0.89
0.79 3480 BKW
RPM
3331 0.94
0.84 3553 BKW
RPM
3406 0.99
0.89
62010 566
850
1400
1400
401
661 -
3259
2978
-
0.83
0.65
2184
3335 0.24
3061 0.88 2294
0.70 3409 0.27
3141 0.93 2404
0.75 3481 0.30
3221 0.98 2507
0.80 3553 0.34
3297
2609
1.04 3373
0.85 3624 0.900.38 2704
1.09 3445
3693 0.960.42
1.15 2799 0.45
3760 1.01
3517 1.20 2890 0.49
3825 1.07
3588 1.26 2980
3890 1.12
3659
0.53
1.32
661
1000
1500 472 2339
3459 0.31 0.99 2442
3530 0.35
1.05 2544
3600 0.381.11 2640
3669 0.42 2736
1.16 3649 0.46
3737 1.17 2825
1.22 3716
3803 1.230.51 2914
1.28 3782
- 0.55
- 3000 0.59 3085 0.63 3166 0.68
1600 708
755 3364 0.94 3437 1.00 3509 1.05 3580 1.11 1.29 -- -- -- -- -- --
62010 1200 566 2662 0.46 2755 0.50 2844 0.55 2931EXTERNAL STATIC
0.59 3015 0.64PRESSURE-inch
3097 0.69 wg.(Pa)
3178 0.74 3256 0.79 3331 0.84 3406 0.89
Model AIR FLOW
1400 661 29780.2 (50)
0.65 30610.4 (100) 0.6 (150)
0.70 3141 0.8 (200)
0.75 3221 1 (250)
0.80 3297 1.2 (300)
0.85 3373 1.4 (350)
0.90 3445 0.96 1.6 (400)
3517 1.01 1.8 (450)
3588 1.07 2 (500)1.12
3659
PAC4A
CFM
1600 L/S
755 RPM BKW
3364 RPM BKW
0.94 3437 RPM BKW
1.00 3509 RPM BKW
1.05 3580 RPM BKW
1.11 3649 RPM BKW
1.17 3716 RPM BKW
1.23 3782 1.29 RPM
- BKW
- RPM
- BKW
- RPM
- BKW-
Model
Model
850
AIR FLOW
1000
AIR FLOW
401
472
-
23390.2 (50)
I
- 2184 0.24 2294 0.27 2404EXTERNAL
0.31 2442 0.35 2544
0.4 (100) 0.38 2640
0.6 (150)
0.30 2507
EXTERNAL
STATIC
STATIC
0.42 2736
0.8 (200)
0.34PRESSURE-inch
2609 0.38 2704
PRESSURE-inch
0.46 2825
1 (250)
wg.(Pa)0.42
wg.(Pa)
0.51 2914
1.2 (300) 0.55
1.4 (350)
2799 0.45
3000 0.59
1.6 (400)
2890 0.49
3085 0.63
1.8 (450)
2980 0.53
3166 0.68
2 (500)
PAC4A 0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
62010 1200
CFM 566
L/S 2662
RPM BKW 0.46 2755
RPM BKW 0.50 2844
RPM BKW 0.55 2931
RPM BKW 0.59 3015
RPM BKW 0.64 3097
RPM BKW 0.69 3178
RPM BKW 0.74 3256
RPM BKW 0.79 3331
RPM BKW0.84 3406
RPM BKW 0.89
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
Model
PAC4A
1400
850
1000
AIR FLOW
1600
1000
1200
661
401
472
755
472
566
2978
-
2228
3364
23390.2
0.65
-
0.27
3061 0.24
2184
2339
0.94 2442
0.31
(50) 3437
0.4
0.70 2294
0.31
3141 0.27
2442
1.00 2544
0.35
(100) 3509
0.6
0.75 3221
0.35 2544
1.05 3580
0.38
(150) 2640
0.8
0.80
2404EXTERNAL
0.38
1.11
0.42
(200)
3297
0.30 2640
2507
STATIC
3649
2736
1
0.85
0.34
0.42
1.17
0.46
(250)
2519 0.39 2615 0.44 2710 0.48 2800 0.53 2889 0.57 2973 0.62 3057 0.66
3373
2609 0.90
PRESSURE-inch
2736
3716
2825
1.2
0.46
1.23
0.51
(300)
3445
2704 0.96
0.38 wg.(Pa)
2825
3782
2914
1.4
0.42
0.51
1.29
0.55
(350)
3517
2799 1.01
2914 0.55
- (400)
3000
1.6
3138 0.71
0.45
-
0.59
3588
2890 1.07
3000 0.59
- (450)
3085
1.8
3218 0.76
0.49
-
0.63 Ii 3659
2980 1.12
3085 0.63
0.53
-2 (500)0.68
3166
3294 0.81
-
62010 1200
CFM 566
L/S 2662 BKW
RPM 0.46 RPM
2755 BKW0.50 RPM
2844 BKW 0.55 3101
2931 BKW
RPM 0.59 3181
3015 BKW
RPM 0.64 3259
3097 BKW
RPM 0.69 3335
3178 BKW
RPM 0.74 3256 BKW
RPM 0.79 3331 BKW
RPM 0.84 3406Table
RPM 0.8923
BKW
Region
62011“I” shows
1400 standard
661 motor
2851 size
0.58 1.1kw
2937 0.63 3020 0.68 0.73 0.78 0.83 0.88 3409 0.93 3481 0.98 3553 1.04
1000
1400 472
661 2228
2978 0.27 0.65 2339
3061 0.31
0.70 2442
3141 0.350.75 2544
3221 0.38 2640
0.80 3473 0.42
3297 1.03 2736
0.85 3545
3373 1.080.46 2825
0.90 3614
3445 1.140.51
0.96 2914 0.55
3517 1.201.01 3000 0.59
3588 1.26
1.07 3085
3659 0.63
1.12
Region “II” shows alternate motor size 1.5kw
1600 755 3173 0.80 3252 0.85 3327 0.91 3401 0.97 3683 3749 3815 1.32
1200
1600
1800 566
755
850 2519
3364 0.39
3489 0.94 2615
1.06 3437 0.44
3559 1.00 2710
1.13 3509 0.48
3628 1.05 2800
1.19 3580 0.53
3697 1.26 2889
1.11 3763 0.57
3649 1.32 2973
1.17 3828
3716 1.380.62 3057
1.23 3892
3782 1.440.66
1.29 3138
-
3957 0.71
-
1.51 3218
-
4020 0.76
-
1.57 3294
-
4081 0.81
-
1.64
1400
2000 661
944
2851 0.58 2937 0.63 3020 0.68 3101EXTERNAL
3831 1.42 3896 1.49 3959 1.56 4021 1.63
STATIC
0.73 3181
4083
0.78PRESSURE-inch
1.70
3259 0.83 wg.(Pa)
4144 1.77
3335 0.88
4203 1.84
3409 0.93
- - 3481
- 0.98
- 3553
- 1.04
-
62011
Model AIR FLOW
1600 755 31730.2 (50)
0.80 32520.4 (100) 0.6 (150)
0.85 3327 0.8 (200)
0.91 3401 1 (250)
0.97 3473 1.2 (300)
1.03 3545 1.4 (350)
1.08 3614 1.14 1.6 (400)
3683 1.20 1.8 (450)
3749 1.26 38152 (500)1.32
PAC4A
CFM
1800 L/S
850 RPM BKW
3489 RPM BKW
1.06 3559 RPM BKW
1.13 3628 RPM BKW
1.19 3697 RPM BKW
1.26 3763 RPM BKW
1.32 3828 RPM BKW
1.38 3892 1.44 RPM BKW
3957 RPM BKW
1.51 4020 RPM BKW
1.57 4081 1.64
1000
2000 472
944 2228
3831 0.27 1.42 2339
3896 0.31
1.49 2442
3959 0.35
1.56 2544 0.38
4021EXTERNAL 2640
1.63 4083
STATIC0.42PRESSURE-inch
1.70 2736 1.77
4144 0.46 4203
2825 0.51
wg.(Pa)1.84 2914
- 0.55
- 3000
- 0.59
- 3085
- 0.63
-
Model AIR FLOW
1200 566 2519 0.39 2615 0.44 2710 0.48 2800 0.53 2889 0.57 2973 0.62 3057 0.66 3138 0.71 3218 0.76 3294 0.81
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A 1400 661 2851 0.58 2937 0.63 3020 0.68 3101 0.73 3181 0.78 3259 0.83 3335 0.88 3409 0.93 3481 0.98 3553 1.04
62011 CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
1600
1000 755
472 3173 0.27
2228 0.80 2339
3252 0.31
0.85 2442
3327 0.910.35 3401
2544 0.970.38 3473
2640 1.03
0.42 3545
2736 1.080.46 3614
2825 1.14 0.51 3683
2914 1.20
0.55 3749
3000 1.26
0.59 3815
3085 1.32 0.63
1800
1200 850
566 3489 0.39
2519 1.06 3559
2615 1.13
0.44 3628
2710 1.190.48 3697
2800 1.260.53 3763
2889 1.32
0.57 3828
2973 1.380.62 3892
3057 1.44 0.66 3957
3138 1.51
0.71 4020
3218 1.57
0.76 4081
3294 1.64 0.81
62011
2000
1400
1600
944
661
755
3831
2851 1.42
I
0.58 3896
2937 1.49
0.63 3959
3020 1.560.68 4021
3101 1.630.73 4083
3181 1.70
0.78 4144
3173 0.80 3252 0.85 3327 0.91 3401 0.97 3473 1.03 3545 1.08 3614 1.14
3259 1.770.83 4203
3335 1.84 0.88 -
3409 -
0.93 -
3481
3683 1.20 3749 1.26
-
0.98 -
3553
3815
-
1.04
1.32
1800 850 3489 1.06 3559 1.13 3628 1.19 3697 1.26 3763 1.32 3828 1.38 3892 1.44 3957 1.51 4020 1.57 4081 1.64
2000 944 3831 1.42 3896 1.49 3959 1.56 4021 1.63 4083 1.70 4144 1.77 4203 1.84 - - - - Ii - -
Notes:
(1). For data specified in BOLD, kindly consult for drive set selection.
(2). Internal static pressure is based on pressure drops through the evaporator coil, fan casing, droplet eliminator, 1” flat filter G2 and F8
15” bag filter.
(3). USM option for region III, please consult SKM.
16
R410-A
REFRIGERANT
FAN PERFORMANCE
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW
RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
1200 566 2417 0.35 2519 0.39 2615 0.44 2710EXTERNAL 0.48 2800 0.53PRESSURE-inch
STATIC 2889 0.57 wg.(Pa)
2973 0.62 3057 0.66 3138 0.71 3218 0.76
Model AIR FLOW
PAC4A
1400
1600
CFM
661
755
L/S
I
2718
3053
RPM BKW
0.50 2807
0.2 (50)
0.71 3134
RPM BKW
0.55 2895
0.4 (100)
0.77 3213
RPM BKW
0.60 2978
0.6 (150)
0.82 3289
RPM BKW
0.65 3061
0.8 (200)
0.88 3364
RPM BKW
0.70 3141
1 (250)
0.94 3437
RPM BKW
0.75 3221
1.2 (300)
1.00 3509
RPM BKW
0.80 3297
1.4 (350)
1.05 3580
RPM BKW
0.85 3373
1.6 (400)
1.11 3649
RPM BKW
0.90
1.8 (450)
1.17
3445
2 (500)0.96
3716
RPM BKW 1.23
62013 1800
1200 850
566 2665 0.35
2417 0.81 2519
2739 0.39
0.88 2615
2811 0.44
0.94 2710
2881 0.48
1.01 2800
2950 0.53
1.07 2889
3017 0.57
1.14 3083
2973 1.20
0.62 3148
3057 1.270.66 3211
3138 1.340.71 3272
3218 1.41
0.76
2978EXTERNAL STATIC0.70PRESSURE-inch wg.(Pa)1.49
Model
PAC4A
2000
1400
AIR FLOW
2200
1600
944
661
1038
755
2913 0.50
2718
3185
3053 Ii
1.07 2807
0.2 (50)
1.40
2980 0.55
0.71 3247
3134
1.14 2895
0.4 (100)
1.48
3046 0.60
0.77 3308
3213
1.21 3110
0.6 (150)
1.55
0.82 3367
3289
1.28
0.65 3174
0.8 (200)
1.63
3061
0.88 3425
3364
1.35
1 (250)
1.70
3236
3141 1.42
0.94 3483
3437
0.75 3298
1.2 (300)
1.78
3221
1.00 3541
3509
0.80 3358
1.4 (350)
1.86
3297 1.57
1.05 3597
3580
0.85 3417
1.6 (400)
1.94
3373 1.64
1.11 3652
0.90
1.8 (450)
3649 2.02
1.17
3476
3445 1.72
0.96
2 (500)
3706
3716 2.10
1.23
62013 CFM
2400
1800
1200
2000
L/S
1133
850
566
RPM BKW
3447
2665 1.77 RPM BKW
0.81 3505
2739 1.86 RPM BKW
0.88 3562
2811 1.94 RPM BKW
0.94 3617
2881 1.90 RPM BKW
1.01 3671
2950 1.86 RPM 1.99
1.07 3662
3017 BKW RPM 2.11
1.14 3652
3083
2417 0.35 2519 0.39 2615 0.44 2710 0.48 2800 0.53 2889 0.57 2973 0.62 3057 0.66 3138 0.71
2913 1.07
BKW RPM 2.10
1.20 3768
2980 1.14 3046 1.21 3110 1.28 3174 1.35 3236 1.42 3298 1.49 3358 1.57 3417 1.64
3148 BKW 3883
1.27 RPM 2.45
3211 BKW
1.34 Iii3934
RPM
3272
3218
3476
BKW
2.27
1.41
0.76
1.72
Region “I” shows 944
1400 standard
661 motor 0.50
2718 size 1.5kw
2807 0.55 2895 0.60 2978 0.65 3061 0.70 3141 0.75 3221 0.80 3297 0.85 3373 0.90 Table
3445 25
0.96
2200 1038 3185 1.40 3247 1.48 3308 1.55 3367 1.63 3425 1.70 3483 1.78 3541 1.86 3597 1.94 3652 2.02 3706 2.10
Region “II” shows
1600 alternate
755 3053 0.71 2.2kw
motor size 3134 0.77 3213 0.82 3289 0.88 3364 0.94 3437 1.00 3509 1.05 3580 1.11 3649 1.17 3716 1.23
2400 1133 3447 1.77 3505 1.86 3562 1.94 3617 1.90 3671 1.86 3662 1.99 3652 2.11 3768 2.10 3883 2.45 3934 2.27
Region
62013“III” shows
1800 alternate
850 motor0.81
2665 size2739
3.0kw0.88 2811 0.94 2881EXTERNAL 1.01 2950
STATIC1.07 3017 1.14 wg.(Pa)
PRESSURE-inch 3083 1.20 3148 1.27 3211 1.34 3272 1.41
Model AIR FLOW
2000 2913 1.07 2980 1.14 3046 1.21 3110 1.28 3174 1.35 3236 1.42 3298 1.49 3358 1.57 3417 1.64 3476
944 0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)1.72
PAC4A
2200
CFM 1038
L/S 3185 BKW
RPM 1.40 RPM
3247 BKW1.48 RPM
3308 BKW1.55 RPM
3367 BKW1.63 RPM
3425 BKW1.70 RPM
3483 BKW1.78 RPM
3541 BKW 1.86 RPM
3597 BKW 1.94 RPM
3652 BKW 2.02 3706 BKW
RPM 2.10
2400
1500 1133
708 3447 0.52
2732 1.77 2825
3505 0.57
1.86 2910
3562 0.62
1.94 2995
3617EXTERNAL
1.90 3076
0.67 3671 1.86
0.72 3662
3157 1.99
0.78 3652
3234
STATIC PRESSURE-inch wg.(Pa) 2.11
0.83 3768
3311 2.10
0.89 3883
3385 2.45
0.94 3934 0.99
3459 2.27
Model AIR FLOW 2841 0.58 2931 0.63 3013 0.69 3094 0.74 3173 0.80 3252 0.85 3327 0.91 3401 0.97 3473 1.03 3545
1600 755 0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)1.08
PAC4A
1800
CFM 850
L/S 3150
RPM BKW 0.79 3229
RPM BKW 0.85 3308
RPM BKW 0.91 3381
RPM BKW 0.97 3454
RPM BKW 1.03 3524
RPM BKW 1.10 3594
RPM BKW 1.16 3663
RPM BKW 1.23 3731
RPM BKW 1.29 -
RPM -
BKW
2000
1500 944
708 2664 0.52
2732 0.83 2825
2737 0.57
0.90 2910
2808 0.62
0.97 2995
2878 0.67
1.04 2946
3076 1.11
0.72 3013
3157 1.18
0.78 3078
3234 1.25
0.83 3142
3311 1.320.89 3205
3385 1.390.94 3267
3459 1.460.99
62015
Model
PAC4A
2200
1600
2400
1800
1038
AIR FLOW755
1133
850
2891 0.58
2841
0.2 (50)
3114
3150
I
1.05 2931
1.32
2959 0.63
0.79 3178
3229
1.13 3025
0.4 (100)
1.40
3013 1.20
0.6 (150)
0.85 3240
3308 1.48
3094EXTERNAL
0.69 3090
0.91 3301
3381
1.28
0.8 (200)
1.57
STATIC
0.74 3153
3173
0.97 3360
3454
0.80PRESSURE-inch
1.36
1 (250)
1.65
3216
3252 1.44
1.2 (300)
1.03 3418
3524 1.73
wg.(Pa)1.51
0.85 3277
3327 0.91 3337
1.4 (350)
1.10 3476
3594 1.81
3401 1.59
1.16 3533
0.97 3396
1.6 (400)
3663 1.90
3473 1.66
1.23 3589
1.03
1.8 (450)
3731 1.92
1.29
3454
3545 1.741.08
- 2 (500)
3644 1.88
-
CFM
2600
2000 L/S
1227
944 RPM BKW
3336
2664 1.63 RPM BKW
0.83 3396
2737 1.72 RPM BKW
0.90 3455
2808 1.81 RPM BKW
0.97 3513
2878 1.90 RPM BKW
1.04 3569
2946 1.99 RPM 2.08
1.11 3624
3013 BKW RPM 2.17
1.18 3678
3078 BKW RPM 2.23
1.25 3732
3142 BKW 3785
1.32 RPM 2.26
3205 BKW
1.39 RPM
-
3267 BKW
-
1.46
62015 2732 0.52 2825 2.10
0.57 3693
2910 2.20
0.62 3747
2995 2.30
0.67 3798
1500
2800
2200
1600
2400
708
1321
1038
755
1133
3581
2891 2.01
Ii
1.05 3638
2959 1.13 3025 1.20 3090 1.28 3076 2.40
3153 0.72 3849
1.36 3157 2.49
3216 0.78 3901
1.44 3234 2.59
3277
2841 0.58 2931 0.63 3013 0.69 3094 0.74 3173 0.80 3252 0.85 3327 0.91 3401 0.97 3473 1.03
3114 1.32 3178 1.40 3240 1.48 3301 1.57 3360 1.65 3418 1.73 3476 1.81 3533 1.90 3589 1.92
0.83 3952
1.51 3311 2.68
3337 0.89 3396
1.59 3385
- 0.94
-
1.66 3459
-
3454
3545
3644
0.99
-
1.74
1.08
1.88
1800 850 3150 0.79 3229 0.85 3308 0.91 3381 0.97 3454 1.03 3524 1.10 3594 1.16 3663 1.23 3731 1.29 - -
62015
2600
2000
2800
2200
1227
944
1321
3336 1.63 3396 1.72 3455 1.81 3513 1.90 3569 1.99 3624 2.08 3678 2.17 3732 2.23 3785 2.26
2664 0.83 2737 0.90 2808 0.97 2878 1.04 2946 1.11 3013 1.18 3078 1.25 3142 1.32 3205 1.39
3581 2.01 3638 2.10 3693 2.20 3747 2.30 3798 2.40 3849 2.49 3901 2.59 3952 2.68
2891 1.05 2959 1.13 3025 1.20 3090EXTERNAL 1.28 3153 1.36 3216 1.44 wg.(Pa)
3277 1.51 3337 1.59 3396 1.66
- - Iii
-
3267
-
3454
-
1.46
-
1.74
1038 STATIC PRESSURE-inch
Region
Model“I” shows
2400 standard
AIR FLOW
1133 motor
3114 size 1.5kw
1.32
0.2 (50) 3178 1.40 3240
0.4 (100) 1.48 3301
0.6 (150) 1.57 3360
0.8 (200) 1.65 3418
1 (250) 1.73 3476
1.2 (300) 1.81 3533
1.4 (350) 1.90 3589
1.6 (400) 1.92
1.8 (450) 3644
Table 26
2 (500)1.88
PAC4A
Region “II” shows
2600 alternate
CFM 1227
L/S motorBKW
3336
RPM size RPM
1.63 2.2kw
3396 BKW1.72 RPM
3455 BKW1.81 RPM
3513 BKW1.90 RPM
3569 BKW1.99 RPM
3624 BKW2.08 RPM
3678 BKW 2.17 RPM
3732 BKW 2.23 RPM
3785 BKW 2.26 RPM- BKW -
Region “III” shows
2800 alternate
1600 755
1321 motor0.49
2239
3581 size2327
2.01 3.0kw0.54
3638 2.10 2410
3693 0.60
2.20 2492 0.66
2.30 2570
3747EXTERNAL 3798 0.72
2.40
STATIC 2647
3849 0.77 2722
3901 0.83
2.49 wg.(Pa)
PRESSURE-inch 2.59 2796
3952 0.89
2.68 2866
- 0.95
- 2935
- 1.01-
Model AIR FLOW
1800 2473 0.66 2551 0.72 2628 0.78 2702 0.85 2776 0.91 2846 0.98 2916 1.04 2983 1.11 3050 1.17 3115
850 0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)1.24
PAC4A 2000 944 2664 0.83 2737 0.90 2808 0.97 2878 1.04 2946 1.11 3013 1.18 3078 1.25 3142 1.32 3205 1.39 3267 1.46
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
2200
1600 1038
755
2891 1.05 2959 1.13 3025 1.20
2239 0.49 2327 0.54 2410 0.60 3090 1.28 3153 1.36 3216 1.44 3277
2492 0.66 2570 0.72 2647 0.77 2722 1.51 0.83 3337
2796 1.59
0.89 3396 0.95 3454
2866 1.66 2935 1.741.01
2400
1800 1133
850 3114 0.66
2473 1.32 2551
3178 0.72
1.40 2628
3240 0.78
1.48 3301EXTERNAL
2702 1.57 3360
0.85 2776 1.65
STATIC 3418
2846 1.73
0.98 3476
0.91PRESSURE-inch wg.(Pa)1.81
2916 1.04 3533
2983 1.90
1.11 3589
3050 1.92
1.17 3644
3115 1.881.24
Model AIR FLOW
62018 2600
2000 1227
944 2483
2664 1.10
0.83 2542
0.2 (50) 2737 1.18
0.90 2600
0.4 (100) 1.26
0.6 (150)
2808 0.97 2657 1.34
0.8 (200)
2878 1.04 2712 1.42
1 (250)
2946 1.11 2765 1.50
1.18 2817
1.2 (300)
3013 1.58
1.4 (350)
3078 1.25 2869 1.66
1.32 2920
1.6 (400)
3142 1.74
1.39 2970
1.8 (450)
3205 3267 1.82
2 (500)
1.46
PAC4A
2800
CFM
2200 1321
L/S
1038 2663
RPM
2891 1.37
1.05 2719
BKW 2959 1.45
RPM BKW
1.13 2773
3025 1.54
1.20 2827
RPM BKW RPM BKW
3090 1.62
1.28 2878
RPM BKW
3153 1.71
1.36 2929
RPM 1.79
3216 1.44 2979
BKW RPM 1.88
3277 BKW
1.51 3028
RPM 1.96
3337 BKW 3076
1.59 RPM 2.05
3396 3123
BKW 3454
1.66 RPM 1.742.13
BKW
3000
1600
2400 1416
755
1133 2239
2812
3114 0.49
1.62 2327 1.71
1.32 2865
3178 0.54
1.40 2410 1.80
2918
3240 0.60 2968
1.48 2492 1.89
3301 0.66
1.57 2570 1.98
3018
3360 0.72
1.65 2647 1.73
3065
3418 0.77 3476
2.07 3113 2.16
2722 1.81
0.83 3159 2.24
2796 1.90
3533 3205
0.89 3589 2.33
2866 1.92 3249
0.95 3644 2.42
2935 1.88 1.01
62018 1800
3200
2600 850
1510
1227 2473
2986
2483 0.66 2542
1.95
1.10 2551 1.18
3036 0.72
2.04 2628 1.26
3085
2600 0.78 3132
2.14 2702 2.23
2657 0.85
1.34 2776 2.33
3178
2712 0.91
1.42 2846 2.42
3223
2765 0.98 3267
1.50 2916 2.50
2817 1.04
1.58 2983 2.59
3311
2869 1.11 3353
1.66 3050 2.69
2920 1.17 3396
1.74 3115 2.79
2970 1.24
1.82
2000
3400
2800 944
1605
1321 2664
3156
2663 0.83
2.31 2737 2.41
1.37 3203
2719 0.90
1.45 2808 2.52
3247
2773 0.97 3291
1.54 2878 2.62
2827 1.04
1.62 2946 2.70
3334
2878 1.11
1.71 3013 2.78
3376
2929 1.18 3417
1.79 3078 2.88
2979 1.25
1.88 3142 2.99
3458
3028 1.32 3498
1.96 3205 3.09
3076 1.39 3538
2.05 3267 3.20
3123 1.46
2.13
2200
3600
3000
2400
3200
1038
1699
1416
1133
1510
2891
3321
2812
3114
2986
I 1.05 3363
2.72
1.62 2959 2.83
2865
1.32 3036
1.95
1.13
1.71
3178 2.04
1.40 3085
3025 2.92
3404
2918
3240 2.14
1.20 3444
1.80
1.48 3132
3090 2.99
2968
3301 2.23
1.28
1.89
1.57 3178
3360 2.33
3153 3.09
3484
3018
3418 2.42
1.65 3223 1.73
1.36
1.98 3216 3.20
3523
3065 1.44 3562
2.07 3277 3.31
3113
3476
3267
1.51
2.16
1.81
2.50
3337 3.42
3600
3159
3533
3311
1.59 3619
2.24
1.90
2.59
3396 3.48
3205
3589
3353
2.33
1.92
2.69
3454 3.48
1.66 3619
3249
3644
3396
1.74
2.42
1.88
2.79
62018 2600
3400 1227
1605 2483
3156 1.10 2542 2.41
2.31 3203 1.18 3247
2600 2.52
1.26 3291
2657 2.62
1.34 3334
2712 2.70
1.42 3376
2765 2.78
1.50 2817
3417 1.58
2.88 2869
3458 1.66
2.99 2920
3498 1.74
3.09 2970
3538 1.82
3.20
2800 1321 2663 1.37 2719 1.45 2773 1.54 2827 1.62 2878 1.71 2929 1.79 2979 1.88 3028 1.96 3076 2.05 3123 2.13
3600 1699 3321 2.72 3363 2.83 3404 2.92 3444 2.99 3484 3.09 3523 3.20 3562 3.31 3600 3.42 3619 3.48 3619 3.48
Model
3000 1416
AIR FLOW
3200 1510
2812
2986
Ii
0.2 (50)
1.62
1.95
2865 1.71 2918 1.80 2968EXTERNAL
3036 2.04 3085
0.4 (100) 2.14 3132
0.6 (150)
1.89 3018
STATIC
2.23 3178
0.8 (200)
1.98 3065 2.07 wg.(Pa)
PRESSURE-inch
2.33 3223
1 (250)
3113 2.16
2.42 3267
1.2 (300) 2.50
1.4 (350)
3159 2.24 3205 2.33
3311 2.59 3353
1.6 (400) 2.69
1.8 (450)
3249
3396
2.42
2 (500)2.79
PAC4A
CFM
3400 L/S
1605 RPM
3156 BKWRPM
2.313203 BKW2.41 RPM
3247 BKW2.52 RPM
3291 BKW2.62 RPM
3334 BKW2.70 RPM
3376 BKW2.78 RPM
3417 BKW2.88 RPM
3458 BKW2.99 RPM
3498 BKW3.09 RPM
3538 BKW 3.20
2000
3600 944
1699 1891
3321 0.492.72 1971
3363 0.55
2.83 2043
3404 0.61
2.92 2115 0.67
2.99 2182
3444EXTERNAL 3484 0.74
STATIC3.09 2249
3523 0.80 2313
3562 0.86
3.20 wg.(Pa)
PRESSURE-inch 3.31 2376
3600 0.92
3.42 2437
3619 0.99 Iii
3.48 2498
3619 1.063.48
Model AIR FLOW
2200 1038 2024 0.61 2098 0.67 2169 0.74 2237 0.80 2302 0.87 2365 0.94 2426 1.01 2485 1.08 2544 1.15 2601 1.22
Region
PAC4A
“I” shows standard motor size
0.2 (50) 2.2kw
0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) Table
2 (500) 27
2400
CFM
1133
L/S
2159 0.73 2227 0.80 2295 0.87 2359 0.95 2422 1.02 2482 1.09 2541 1.16 2597 1.24 2653 1.31 2707 1.39
RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
Region “II” shows
2600 alternate
1227 motor size 3.0kw
2290 0.88 2357 0.95 2422 1.03 2483 1.10 2542 1.18 2600 1.26 2657 1.34 2712 1.42 2765 1.50 2817 1.58
2000 944 1891 0.49 1971 0.55 2043 0.61 2115 0.67 2182 0.74 2249 0.80 2313 0.86 2376 0.92 2437 0.99 2498 1.06
Region “III” shows
2200 alternate
2800 1321
1038 motor0.61
2420
2024 size2098
1.04 4.0kw0.67
2486 1.12 2169
2546 0.74
1.20 2606 1.28
0.80 2663
2237EXTERNAL STATIC
2302 1.37 2719 0.94 2773
2365 1.45
0.87PRESSURE-inch wg.(Pa)1.54
2426 1.01 2827
2485 1.62
1.08 2878
2544 1.71
1.15 2929
2601 1.791.22
Model AIR FLOW
3000 1975 1.01 2032 1.10
2400 1416
1133 0.2 (50)
2159 0.73 2227 0.80 2089
0.4 (100) 2295 1.18
0.87 2144
0.6 (150) 1.27
0.95 2199
0.8 (200)
2359 1.35
1.02 2252
1 (250)
2422 1.44
1.09 2305
1.2 (300)
2482 1.53
1.16 2358
1.4 (350)
2541 1.62
1.24 2410
1.6 (400)
2597 1.71
1.31 2461
1.8 (450)
2653 1.80
2 (500)
2707 1.39
PAC4A
62020 3200
2600
CFM 1510
L/S
1227 2065
RPM BKW
2290 1.16
0.88 2120
RPM BKW
2357 1.25
0.95 2175
RPM BKW
2422 1.34
1.03 2228
RPM BKW
2483 1.43
1.10 2280
RPM BKW
2542 1.52
1.18 2331
RPM 1.61
2600 1.26 2381
BKW RPM 1.71
2657 1.34 2431
BKW RPM 1.80
2712 1.42 2481
BKW 2765 1.90
RPM 1.50 2530
BKW 2817
RPM 1.581.99
BKW
3400
2000 1605
944 2184
1891 1.38
0.49 2237
1971 1.47
0.55 2289
2043 1.57
0.61 2340
2115 1.66
0.67 2389
2182 1.76
0.74 2439
2249 1.86 2487
0.80 2773 1.96
2313 1.54 2535
0.86 2827 2.06
2376 1.62 2582
0.92 2878 2.16
2437 1.71 2629
0.99 2929 2.26
2498 1.791.06
Notes: 2800 1321 2420 1.04 2486 1.12 2546 1.20 2606 1.28 2663 1.37 2719 1.45
3600
2200
3000 1699
1038
1416 2275
2024 1.01
1975 1.56 2325
0.61 2032
2098 1.101.66
0.67 2376
2169 1.76
2089 0.74 2424
1.18 2237 1.86
2144 0.80 2473
1.27 2302 1.97
2199 0.87 2520
1.35 2365 2.07
2252 0.94 2567
1.44 2426 2.18
2305 1.01 2612
1.53 2485 2.28
2358 1.08 2658
1.62 2544 2.38
2410 1.15 2703
1.71 2601 2.49
2461 1.22
1.80
(1). For data3800specified
2400
3200 1133 in2065
1793
1510
BOLD,
2159
2387 0.73kindly
1.80
1.16 2227 consult
2436
2120 1.91
1.25 2295for2.01
0.80 2484
2175
drive
0.87
1.34
set2.12
2359
2531
2228
selection.
0.95
1.43 2422 2.23
2576
2280 1.02 2622
1.52 2482 2.34
2331 1.09 2666
1.61 2541 2.44
2381 1.16 2710
1.71 2597 2.55
2431 1.24 2754
1.80 2653 2.66
2481 1.31 2797
1.90 2707 2.77
2530 1.39
1.99
62020
(2). Internal static
2600 pressure
4000
3400 1227
1888
1605 2290is based
2497
2184 0.88 2543
2.05
1.38
on pressure
2357
2237 0.95 2589
2.16
1.47 2289
drops
2422 2.27
1.03 2633
1.57
through
2483
2340 2.39
1.66
the evaporator
1.10 2677
2542
2389 1.18 2720
2.50
1.76 2600 2.61
2439 1.26
1.86
coil,
2762
2487
fan2.72
2657 casing,
1.34
1.96 2712 droplet
2804
2535 2.84
2.06 2765
1.42 2846
2582
eliminator,
2.95
2.16 28171”3.07
1.50 2887
2629
flat filter
1.58
2.26
G2 and F8
15” bag4200
filter. 1982
2800
3600 1321
1699 2420 2.32
2604
2275 1.04 2649
1.56 2486 2.43
2325 1.12 2691
1.66 2546 2.55
2376 1.20
1.76 2606 2.67
2733
2424 1.28 2774
1.86 2663 2.79
2473 1.37
1.97 2719 2.90
2815
2520 2.07 2773 3.02
1.45 2855
2567 1.54
2.18 2827 3.14
2896
2612 1.62 2935
2.28 2878 3.26
2658 1.71
2.38 2929
-
2703 1.79
-
2.49
(3). USM option
3000 for2077
4400
3800
region
1416
1793
III, please
1975
2730 1.01
2387 2.49
consult
2032
1.80 2771
2436 2.61
1.91
SKM.
1.10 2811
2089
2484 1.18
2.73
2.01 2144 2.84
2850
2531 1.27 2888
2.12 2199 2.96
2576 1.35
2.23 2252 3.08
2927
2622 1.44 2965
2.34 2305 3.20
2666 1.53
2.44 2358 3.33
3002
2710 1.62
2.55 2410
-
2754 1.71
-
2.66 2461
-
2797 1.80
-
2.77
62020 3200
4000 1510
1888 2065
2497 1.16 2120
2.05 2543 1.25 2589
2.16 2175 2.27
1.34 2633
2228 2.39
1.43 2677
2280 2.50
1.52 2331 2.61
2720 1.61 2762
2381 2.72
1.71 2431 2.84
2804 1.80 2481 2.95
2846 1.90 2530
2887 1.99
3.07
3400
4200 1605
1982 2184
2604 1.38
2.32 2237
2649 1.47 2691
2.43 2289 2.55
1.57 2733
2340 2.67
1.66 2774
2389 2.79
1.76 2439
2815 1.86
2.90 2487
2855 1.96 2896
3.02 2535 3.14
2.06 2582 3.26
2935 2.16 2629
- 2.26
-
3600
4400 1699
2077 2275
2730 1.56
2.49 2325
2771 1.66 2811
2.61 2376 2.73
1.76 2850
2424 2.84
1.86 2888
2473 2.96
1.97 2520
2927 2.07
3.08 2567
2965 2.18 3002
3.20 2612 3.33
2.28 2658
- 2.38
- 2703
- 2.49
-
3800 1793 2387 1.80 2436 1.91 2484 2.01 2531 2.12 2576 2.23 2622 2.34 2666 2.44 2710 2.55 2754 2.66 2797 2.77
4000 1888 2497 2.05 2543 2.16 2589 2.27 2633 2.39 2677 2.50 2720 2.61 2762 2.72 2804 2.84 2846 2.95 2887 3.07
4200 1982 2604 2.32 2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02 2896 3.14 2935 3.26 - -
4400 2077 2730 2.49 2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20 3002 3.33 - - - -
FAN PERFORMANCE
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
2000 944 1891 0.49 1971 0.55 2043 0.61 2115 0.67 2182 0.74 2249 0.80 2313 0.86 2376 0.92 2437 0.99 2498 1.06
2200 1038 2024 0.61 2098 0.67 2169 0.74 2237 0.80 2302 0.87 2365 0.94 2426 1.01 2485 1.08 2544 1.15 2601 1.22
2400 1133 2159 0.73 2227 0.80 2295 0.87 2359 0.95 2422 1.02 2482 1.09 2541 1.16 2597 1.24 2653 1.31 2707 1.39
2600
2800
1227
1321
2290
2420
I 0.88
1.04
2357 0.95 2422 1.03 2483 1.10 2542 1.18 2600 1.26 2657 1.34
2486 1.12 2546 1.20 2606 1.28 2663 1.37 2719 1.45 2773 1.54 2827 1.62 2878 1.71
2712 1.42 2765 1.50 2817
2929
1.58
1.79
3000 1416 1975 1.01 2032 1.10 2089 1.18 2144 1.27 2199 1.35 2252 1.44 2305 1.53 2358 1.62 2410 1.71 2461 1.80
62020 3200 1510 2065 1.16 2120 1.25 2175 1.34 2228 1.43 2280 1.52 2331 1.61 2381 1.71 2431 1.80 2481 1.90 2530 1.99
3400 1605 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86 2487 1.96 2535 2.06 2582 2.16 2629 2.26
3600
3800
1699
1793
2275
2387
Ii 1.56
1.80
2325 1.66 2376 1.76 2424 1.86 2473 1.97 2520 2.07 2567 2.18 2612 2.28 2658 2.38
2436 1.91 2484 2.01 2531 2.12 2576 2.23 2622 2.34 2666 2.44 2710 2.55 2754 2.66
2703
2797
2.49
2.77
4000 1888 2497 2.05 2543 2.16 2589 2.27 2633 2.39 2677 2.50 2720 2.61 2762 2.72 2804 2.84 2846 2.95 2887 3.07
4200
4400
1982
2077
2604
2730
2.32
2.49
2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02 2896 3.14 2935 3.26
2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20 3002 3.33 - - Iii -
-
-
-
Region “I” shows standard motor size 2.2kw Table 28
Region “II” shows alternate motor size 3.0kw
Region “III” shows alternate motor size 4.0kw
Region “III” shows alternate motor size 4.0kw EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model 2400
AIR FLOW
1133 2083 0.66 2159 0.73 2227 0.80 2295 0.87 2359 0.95 2422 1.02 2482 1.09 2541 1.16 2597 1.24 2653 1.31
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A 2600 1227 2219 0.80 2290 0.88 2357 0.95 2422 1.03 2483 1.10 2542 1.18 2600 1.26 2657 1.34 2712 1.42 2765 1.50
CFM L/S RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
2800 1321 2354 0.96 2420 1.04 2486 1.12 2546 1.20 2606 1.28 2663 1.37 2719 1.45 2773 1.54 2827 1.62 2878 1.71
2400 1133 2083 0.66 2159 0.73 2227 0.80 2295 0.87 2359 0.95 2422 1.02 2482 1.09 2541 1.16 2597 1.24 2653 1.31
3000 1416 2456 1.10 2521 1.18 2585 1.27 2644 1.35 2702 1.44 2757 1.53 2812 1.62 2865 1.71 2918 1.80 - -
2600 1227 2219 0.80 2290 0.88 2357 0.95 2422 1.03 2483 1.10 2542 1.18 2600 1.26 2657 1.34 2712 1.42 2765 1.50
3200 1510 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66 2406 1.76 2456 1.85
62025
2800
3400
3000
3600
1321
1605
1416
1699
2354
2073
2456
2168
I 0.96
1.19
1.10
1.36
2420 1.04 2486 1.12 2546 1.20 2606 1.28 2663 1.37 2719 1.45
2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76
2521 1.18 2585 1.27 2644 1.35 2702 1.44 2757 1.53 2812 1.62
2221 1.46 2275 1.56 2325 1.66 2376 1.76 2424 1.86 2473 1.97
2773 1.54
2439 1.86
2865 1.71
2520 2.07
2827 1.62 2878 1.71
2487 1.96 2535 2.06
2918 1.80 -
2567 2.18 2612 2.28
-
3200 1510 1978 1.02 2037 1.11 2093 1.20 2148 1.29 2201 1.38 2254 1.47 2305 1.57 2356 1.66 2406 1.76 2456 1.85
3800 1793 2260 1.54 2312 1.64 2362 1.74 2412 1.85 2460 1.96 2507 2.06 2554 2.17 2599 2.28 2644 2.39 2688 2.50
3400 1605 2073 1.19 2130 1.28 2184 1.38 2237 1.47 2289 1.57 2340 1.66 2389 1.76 2439 1.86 2487 1.96 2535 2.06
62025 4000 1888 2376 1.77 2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44 2698 2.56 2741 2.67 2783 2.78
3600 1699 2168 1.36 2221 1.46 2275 1.56 2325 1.66 2376 1.76 2424 1.86 2473 1.97 2520 2.07 2567 2.18 2612 2.28
4200 1982 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02
3800
4400
4000
1793
2077
1888
Ii
2260
2578
2376
1.54
2.08
1.77
2312 1.64 2362 1.74 2412 1.85 2460 1.96 2507 2.06 2554 2.17
2623 2.21 2666 2.32 2710 2.43 2750 2.55 2791 2.67 2830 2.79
2425 1.88 2473 1.99 2520 2.11 2566 2.22 2611 2.33 2655 2.44
2599 2.28
2869 2.90
2698 2.56
2644 2.39 2688 2.50
2908 3.02 2947 3.14
2741 2.67 2783 2.78
4600 2171 2600 2.15 2645 2.26 2688 2.38 2730 2.49 2771 2.61 2811 2.73 2850 2.84 2888 2.96 2927 3.08 2965 3.20
4200 1982 2466 1.96 2513 2.08 2559 2.21 2604 2.32 2649 2.43 2691 2.55 2733 2.67 2774 2.79 2815 2.90 2855 3.02
4400
4600
2077
2171
2578
2600
2.08
2.15
2623
2645
2.21
2.26
2666
2688
2.32
2.38
2710
2730
2.43
2.49
2750
2771
2.55
2.61
2791
2811
2.67
2.73
2830
2850
2.79
2.84
2869
2888
2.90
2.96
2908
2927
3.02
3.08
Iii2947
2965
3.14
3.20
Notes:
(1). For data specified in BOLD, kindly consult for drive set selection.
(2). Internal static pressure is based on pressure drops through the evaporator coil, fan casing, droplet eliminator, 1” flat filter G2 and F8
15” bag filter.
(3). USM option for region III, please consult SKM.
FAN PERFORMANCE
EXTERNAL STATIC PRESSURE-inch wg.(Pa)
Model AIR FLOW
0.2 (50) 0.4 (100) 0.6 (150) 0.8 (200) 1 (250) 1.2 (300) 1.4 (350) 1.6 (400) 1.8 (450) 2 (500)
PAC4A
CFM RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW RPM BKW
3800 1793 1593 0.96 1652 1.06 1706 1.17 1760 1.28 1811 1.39 1862 1.49 1911 1.60 1959 1.71 2006 1.83 2053 1.94
4000 1888 1669 1.11 1725 1.22 1778 1.33 1829 1.44 1879 1.55 1928 1.66 1975 1.78 2021 1.89 2067 2.01 2112 2.13
4200 1982 1716 1.20 1770 1.32 1823 1.43 1873 1.55 1922 1.66 1969 1.78 2015 1.90 2060 2.02 2105 2.14 2149 2.26
4400 2077 1792 1.37 1843 1.49 1895 1.61 1942 1.73 1990 1.85 2035 1.98 2081 2.10 2124 2.23 2167 2.35 2209 2.48
4600 2171 1864 1.54 1915 1.67 1964 1.79 2011 1.92 2056 2.05 2101 2.18 2144 2.31 2186 2.44 2228 2.57 2269 2.70
4800 2265 1912 1.67 1962 1.80 2010 1.93 2056 2.06 2101 2.19 2145 2.33 2188 2.46 2229 2.60 2270 2.73 2310 2.87
62040
5000
5200
2360
2454 I
1985
2058
1.87
2.08
2034 2.00 2080 2.14 2125 2.27 2168 2.41 2211 2.55 2252
2104 2.22 2149 2.36 2193 2.50 2235 2.64 2277 2.79 2317 2.93 2357 3.08 2395 3.22
2.69 2293 2.83 2332 2.97 2371
2433
3.11
3.37
5400 2549 1606 1.81 1651 1.95 1695 2.10 1738 2.25 1779 2.40 1819 2.56 1858 2.71 1897 2.87 1935 3.03 1973 3.19
5600 2643 1660 1.99 1703 2.14 1746 2.29 1787 2.45 1827 2.61 1866 2.77 1904 2.92 1942 3.09 1979 3.25 2016 3.42
5800 2737 1712 2.19 1755 2.35 1796 2.51 1836 2.67 1875 2.83 1913 2.99 1951 3.15 1988 3.32 2024 3.49 2060 3.66
6000 2832 1764 2.40 1806 2.56 1846 2.72 1885 2.88 1923 3.05 1961 3.22 1997 3.39 2033 3.56 2068 3.73 2103 3.90
6200 2926 1815 2.62 1856 2.78 1895 2.95 1934 3.12 1971 3.29 2007 3.47 2043 3.64 2078 3.81 2113 3.99 2147 4.17
6400 3020 1867 2.84 1906 3.02 1945 3.19 1982 3.37 2018 3.54 2054 3.72 2089 3.89 2123 4.07 2157 4.25 2190 4.44
6600 3115 1917 3.09 1956 3.26 1993 3.44 2030 3.62 2066 3.80 2101 3.98 2135 4.16 2168 4.35 2201 4.54 - -
6800 3209 1967 3.34 2005 3.51 2042 3.70 2078 3.88 2113 4.07 2147 4.25 2180 4.44 2213 4.63 - - II
- -
Notes:
(1). For data specified in BOLD, kindly consult for drive set selection.
(2). Internal static pressure is based on pressure drops through the evaporator coil, fan casing, droplet eliminator, 1” flat filter G2 and F8 15”
bag filter.
(3). USM option for region III, please consult SKM.
0.3
Pressure Drop [in.wg]
0.2
0.1
0
150 200 250 300 350 400
**Note that the face velocity to be calculated based on the face area of sand trap louver shown in drawings, page 29-32.
20
R410-A
REFRIGERANT
ELECTRICAL DATA
Model Unit Characteristic Compressor Condenser Fan Motor Evaporator Fan Motor
PAC4A
MFA MCA ICF QTY RLA LRA QTY FLA LRA FLA LRA
51006 32 18 79 1 11.8 74 2 0.9 2.6 1.8 9.0
52008 40 26 88 2 9.6 72 2 0.9 2.6 2.7 13.0
52010 63 31 92 2 11.8 74 2 0.9 2.6 2.7 13.0
52011 63 34 96 2 12.5 75 2 1.2 3.6 3.3 24.0
52013 63 36 123 2 13.6 101 2 1.2 3.6 3.3 24.0
52015 80 50 144 2 18.6 111 2 2.2 9.0 3.3 24.0
52018 80 54 154 2 20 118 2 2.2 9.0 4.6 40.0
52020 80 55 154 1+1 21 + 20 118 + 118 2 2.2 9.0 4.6 40.0
52023 100 65 181 2 25 140 2 2.2 9.0 4.6 40.0
52025 125 74 224 1+1 29 + 25 174 + 140 2 4.0 16.5 4.6 40.0
52030 125 87 280 1+1 34 + 29 229 + 174 4 2.2 9.0 6.0 48.0
52035 160 92 285 2 34.3 229 4 2.2 9.0 6.0 48.0
52040 160 111 391 1+1 42 + 34 320 + 229 4 4.0 16.5 7.9 49.0
Table 34
Model Unit Characteristic Compressor Condenser Fan Motor Evaporator Fan Motor
PAC4A
MFA MCA ICF QTY RLA LRA QTY FLA LRA FLA LRA
61006 32 16 83 1 10.4 78 2 0.9 2.6 1.7 13.0
62008 40 25 93 2 9.4 78 2 0.9 2.6 2.3 16.0
62010 40 27 94 2 10.4 78 2 0.9 2.6 2.3 16.0
62011 63 32 98 2 11.9 78 2 1.2 3.6 3.2 24.0
62013 63 36 108 2 12.2 88 2 1.2 3.6 3.2 24.0
62015 63 42 124 2 15.5 94 2 2.2 9.0 3.2 33.0
62018 80 57 177 2 21.4 140 2 2.2 9.0 4.5 33.0
62020 100 63 182 1+1 26 + 21 145 + 140 2 2.2 9.0 4.5 33.0
62023 100 68 187 2 26.4 145 2 2.2 9.0 4.5 33.0
62025 100 71 191 2 26.4 145 2 3.4 10.0 6.0 50.0
62030 160 91 247 1+1 38 + 29 196 + 138 4 2.2 9.0 6.0 50.0
62035 160 102 350 1+1 39 + 38 290 + 196 4 2.2 9.0 6.0 50.0
62040 160 110 358 2 39.3 290 4 3.4 10.0 8.1 57.0
Table 35
Legend
MFA Maximum Fuse Amps (for fuse/circuit breaker sizing), RLA Rated Load Amps. (at worst operating condition)
complies with NEC Article 440-22 & 430-52. LRA Locked Rotor Amps
MCA Minimum Circuit Amps.(for wire sizing), complies with NEC FLA Full Load Amps
article 440-33.
Note :
Typical
TypicalWiring
WiringDiagram
Diagram
Typical
PAC4A
For Model:
Units Wiring
51006
With &Diagram
61006
One Compressor:
For Units
PAC4A Models:With
51006One Compressor:
PAC4A Models: 51006
XM
*POWER SUPPLY (V/Ph/Hz)
**L1
L2 XM
*POWER SUPPLY (V/Ph/Hz)
**
L3 L1
N L2
L3
E N K1 K2
OLR1 OLR1
DUCT
K1 K2
HPS
E
LPS
TEMP.
DUCT
SENSOR
S1
HPS
OLR1
LPS
TEMP.
SENSOR
L1
L3
L2 OLR1 S1
THERMOSTAT
L3 ( LOOSE SUPPLY )
L1 L2
THERMOSTAT
CM CFM1 CFM2 EFM R SUPPLY
( LOOSE C G) Y
CM CFM1 CFM2 EFM R C G Y
(HP 1)
(HP 2)
ON / OFF
LP 1
LP 2
OFF)/ OFF)
HP 1
HP 2
(LP 1)
(LP 2)
(HP 1)
(HP 2)
ON / OFF
LP 1
LP 2
HP 1
HP 2
(LP 1)
(LP 2)
(ON /(ON
F1
RLY11 RLY10 RLY9 RLY8 RLY7 RLY6 RLY5 RLY4 RLY3 RLY2 RLY1
F1
R
RLY11 RLY10 RLY9 RLY8 RLY7 RLY6 RLY5 RLY4 RLY3 RLY2 RLY1
C
R
K1 K1
FAN1FAN2FAN2
HTR2 X1 X1 X2 X2 OUTOUTOUTOUT
C
G
K1 K1
W2 W1 Y2 Y1
G
W2 W1 Y2 Y1
ECB
FAN1
ECB X2
X2
P-COM1
HTR1HTR2
P-COM1
INFAN HTR1
P2P2 INFAN
OD
OD
LEGEND
LEGEND
1234
S11 2 3 4
ID
P1
HBPV S1 CONTROL
S1 CONTROL SWITCHSWITCH
HBPV
CCH
CCH
CCH CCH
CRANKCRANK CASE HEATER
CASE HEATER
CM1
CM1
F1 MINIATURE
F1 MINIATURE CIRCUITCIRCUIT
BREAKERBREAKER
CM+CFM1+CFM2
CM+CFM1+CFM2
T5A L250V
OVERLOAD
CFM CFM CONDENSER
CONDENSER FAN MOTOR
FAN MOTOR
F1
F1
SEC1
SEC1
N1
N1
PRI1
PRI1
CM COMPRESSOR
CM MOTOR MOTOR
COMPRESSOR
EFM
EFM
K CONTACTOR
K CONTACTOR
K2
K2 K1
K1 FCS FAN CYCLING
FCS SWITCHSWITCH
FAN CYCLING
HBPV HOT GAS
HBPV BYPASS
HOT VALVE VALVE
GAS BYPASS
CONTROL CIRCUIT
CONTROL CIRCUIT TFR TRANSFORMER
TFR TRANSFORMER
BLACK
BLACK XM POWER TERMINAL BLOCK BLOCK
10V
XM POWER TERMINAL
10V
220~240V
RED
24V
XM
*POWER SUPPLY (V/Ph/Hz)
** XM
*POWER SUPPLY (V/Ph/Hz)
**L1 L1
L2
L2 L3
L3 N
N
OLR1
E DUCT
HPS1
HPS2
LPS1
LPS2
OLR1
E TEMP. DUCT
K5
HPS1
HPS2
LPS1
LPS2
K1 K2 SENSOR TEMP.
K5 S1
K1 K2 SENSOR
K3 K4 S1
K3 K4 OLR1 THERMOSTAT
L1
L3
L2 L1
L3
L2 OLR1 ( LOOSE SUPPLY )
THERMOSTAT
L1
L3
L2 L1
L3
L2
R C (GLOOSE
Y1 SUPPLY
Y2 )
CM1 CM2 CFM1 CFM2 R C G Y1 Y2
EFM
CM1 CM2 CFM1 CFM2
(ON / OFF)
HP 1
HP 2
(HP 1)
(HP 2)
ON / OFF
(LP 1) LP 1
(LP 2) LP 2
HP 2(LP 1)
LP 1(LP 2)
EFM
(ON / OFF)
HP 1
(HP 1)
(HP 2)
ON / OFF
LP 2
RLY1
F1
R
C
RLY1
OUT FAN2
F1
OUT
R
RLY2
K1 K2 K1
G
C
FAN1 FAN2
W2 W1 Y2 Y1
OUT FAN1
OUT
RLY2
K1 K2 K1
G
RLY3
ECB
W2 W1 Y2 Y1
FCS1 FCS1
FCS2 FCS2
X2
RLY3
ECB X2
RLY4
X2
X1
X2
RLY4
RLY5
P2 INFAN HTR1 HTR2
X1
P-COM1
RLY5
RLY6
INFAN HTR1 HTR2
P-COM1
RLY6
RLY7
OD
RLY7
RLY8
1234
OD
RLY11 RLY10 RLY9
RLY11 RLY10 RLY9 RLY8
P1
ID
P2
S1
1234
CM2
P1
HBPV
ID
S1
CCH1
CCH2
CM1
CM2
HBPV
L1
CCH1
CCH2
T5A L250V
CM1
CFM1
CFM2
F1
CM2
CM1
EFM
SEC1
N1
PRI1
L1
K4 K3 K5 K2 K1
T5A L250V
CFM1
CFM2
F1
CM2
CM1
EFM
SEC1
N1
PRI1
CONTROL CIRCUIT
K4 K3 K5 K2 K1 BLACK
10V
220~240V
RED BLACK
BLACK
TFR WHITE
10V
220~240V
RED BLACK
WHITE
RED
24V
TFR WHITE
22
R410-A
REFRIGERANT
OLR1
E DUCT
HPS1
HPS2
LPS1
LPS2
XM K1 K2 *POWER SUPPLY (V/Ph/Hz) K5 TEMP.
**L1 S1
SENSOR
L2 K3 K4
L3 OLR1
N L3 L3
THERMOSTAT
L1 L2 L1 L2
( LOOSE SUPPLY )
OLR1
E DUCT
HPS1
HPS2
LPS1
LPS2
K5 R G Y1 Y2
CTEMP.
CM1
K1 K2
CM2 CFM1 CFM2
EFM S1
SENSOR
K3 K4
ON / OFF
(HP 1)
(HP 2)
(LP 1)
(LP 2)
(ON / OFF)
HP 1
HP 2
LP 1
LP 2
OLR1
TK-2
TK-1
L3 L3
THERMOSTAT
L1 L2 L1 L2
( LOOSE SUPPLY )
R C G Y1 Y2
CM1 CM2 CFM1 CFM2
RLY1
F1 EFM
R
C
FAN1 FAN2
ON / OFF
(HP 1)
(HP 2)
(LP 1)
(LP 2)
OFF)
OUT(ON / OUT
HP 1
HP 2
LP 1
LP 2
TK-2
TK-1
RLY2
K1 K2 K1
G
W2 W1 Y2 Y1
RLY3
ECB
RLY1
F1
R
FCS1
FCS2
X2
C
FAN2
OUT
X2
RLY4
RLY2
K1 K2 K1
G
W2 W1 Y2 Y1
X1
FAN1
OUT
RLY3
RLY5
ECB
FCS1
FCS2
HTR2
P-COM1
X2
X2
RLY4
RLY6
INFAN HTR1
X1
RLY5
RLY7
HTR2
P-COM1
RLY6
OD
INFAN HTR1
RLY8
P2
RLY7
TK-2
TK-1
LEGEND
1234
RLY9
FIELD WIRING & FIELD SUPPLIED DEVICES
OD
P1
ID
RLY8
LPS LOW PRESSURE SWITCH
S1
P2
RLY11 RLY10
TK-2
TK-1
HPS
LEGENDHIGH PRESSURE SWITCH
CM2
1234
HBPV RLY9 FIELD WIRING & S1 CONTROLDEVICES
FIELD SUPPLIED SWITCH
P1
ID
LPS LOW PRESSURE SWITCH
S1
CCH CRANK CASE HEATER
CCH1
CCH2
CM1
RLY11 RLY10
CCH2
CM1
T5A L250V
OLR OVERLOAD RELAY
F1 MINIATURE CIRCUIT BREAKER
CFM1
CFM2 CFM2
F1
CM2
CM1
SEC1
EFM FAN MOTOR
N1
PRI1
L1
CM COMPRESSOR MOTOR
T5A L250V
F1
CM1
CFM
EFM
SEC1
N1
PRI1
CM COMPRESSOR FCS
MOTOR FAN CYCLING SWITCH
K4 K3 K5 K2 K1 CONTROL CIRCUIT K CONTACTOR HBPV
BLACK HOT GAS BYPASS VALVE
FCS FAN CYCLING SWITCH
10V
CONTROL CIRCUIT TFR TRANSFORMER
220~240V
RED
XM POWER TERMINAL BLOCK
RED
TFR WHITE WHITE
ECB BLOCK
ELECTRONIC CONTROL BOARD
24V
X2 CONTROL TERMINAL
TFR WHITE
ECB TK
ELECTRONIC CONTROLTHERMAL
BOARD OVERLOAD RELAY
TK DTS RELAY
THERMAL OVERLOAD DUCT TEMPERATURE SENSOR
**L1
XM
**L1
XM
*POWER
*POWER SUPPLY (V/Ph/Hz)
SUPPLY (V/Ph/Hz)
L2 L2
L3
L3
N
N K7
E
E K7
K1 K2 K3 K4 K5 K6
K1 K2 K3 K4 K5 K6
OLR1
L1 L1 OLR1
N L1 L2 L3
L3 L2
L1 L1
N L1 L2 L3
MPM L3 L2 CFM1 CFM2 CFM3 CFM4
T2 T1 L1 L2 L3
M2 M1
CM1 CM2 EFM
F1 MPM CFM1 CFM2 CFM3 CFM4
M2 M1
CM1 CM2
TK-1
TK-2
TK-3
TK-4
T2 T1 L1 L2 L3 EFM
F1
TK-1
TK-2
TK-3
TK-4
HPS1
HPS2
S1
LPS1
LPS2
HPS1
HPS2
TEMP.
M2 SENSOR
S1
MPM1
LPS1
LPS2
M1
TEMP.
THERMOSTAT SENSOR
M2
MPM1
( LOOSE SUPPLY )
M1 R C G Y1 Y2
THERMOSTAT
( LOOSE SUPPLY )
ON / OFF
ON / OFF
HP 1
HP 1
HP 2
HP 2
LP 1
LP 1
LP 2
LP 2
R C G Y1 Y2
RLY1
LP 1R
ON / OFF
ON / OFF
HP 1
HP 1
HP 2
HP 2
LP 1
LP 2
LP 2
C
FAN2
OUT
RLY2
G
W2 W1 Y2 Y1
FAN1
OUT
K1 K2 K1
RLY1
RLY3
ECB
R
FCS1
FCS4
FCS2
FCS5
FCS3
FCS6
C
X2
FAN2
OUT
X2
RLY4
RLY2
G
X1
W2 W1 Y2 Y1
FAN1
OUT
K1 K2 K1
RLY5
RLY3
ECB
HTR2
P-COM1
FCS1
FCS4
FCS2
FCS5
FCS3
FCS6
RLY6
X2
X2
INFAN HTR1
RLY4
RLY7
X1
RLY5
OD
HTR2
RLY8
P-COM1
P2
RLY6
1234
INFAN HTR1
RLY9
TK-1
TK-2
TK-3
TK-4
P1
ID
S1
RLY7
RLY11 RLY10
CM2
OD
HBPV
RLY8
CCH1
CCH2
CM1
P2
1234
RLY9
L1
T5A L250V
TK-1
TK-2
TK-3
CFM4TK-4
P1
ID
COMP-2
COMP-1
S1
F1
SEC1
CFM1
CFM2
CFM3
N1
PRI1
EFM
RLY11 RLY10
CM2
K3 K4 K5 K6 K7 K2 K1
HBPV
CCH1
CCH2
CM1
CONTROL CIRCUIT
TFR
L1
BLACK
T5A L250V
10V
COMP-2
COMP-1
220~240V
RED BLACK
F1
SEC1
CFM1
CFM2
CFM3
CFM4
N1
PRI1
WHITE
EFM
RED
24V
WHITE
K3 K4 K5 K6 K7 K2 K1
CONTROL CIRCUIT
TFR
BLACK
10V
220~240V
RED BLACK
WHITE
RED
24V
WHITE
OLR1
L1 L1
N L1 L2 L2
L3 L3
TK-1
TK-2
TK-3
TK-4
HPS1
HPS2
S1
LPS1
LPS2
TO CONTROL CIRCUIT TO CONTROL CIRCUIT DUCT
OLR1
TEMP.
M2 M2 SENSOR
MPM1
MPM2
M1 M1
THERMOSTAT
( LOOSE SUPPLY )
R C G Y1 Y2
ON / OFF
ON / OFF
HP 1
HP 1
HP 2
HP 2
LP 1
LP 1
LP 2
LP 2
RLY1
R
C
FAN2
OUT
RLY2
G
W2 W1 Y2 Y1
FAN1
K1 K2 K1
OUT
RLY3
ECB
FCS1
FCS4
FCS2
FCS5
FCS3
FCS6
X2 X2
RLY4
X1
RLY5
HTR2
P-COM1
RLY6
INFAN HTR1
RLY7
OD
RLY8
P2
1234
RLY9
TK-1
TK-2
TK-3
TK-4
P1
ID
S1
RLY11 RLY10
CM2
LEGEND
CCH2
CM1
T5A L250V
COMP-1
F1
CFM1
CFM2
CFM3
CFM4
SEC1
F1 MINIATURE CIRCUIT BREAKER
N1
PRI1
EFM
24
R410-A
REFRIGERANT
Dimensional Data
PAC4A Model - 51006 & 61006 STANDARD DRG.
10 10
01
[254] A1 A3 [254]
DIMENSIONS [mm]
MODEL ALT A
DRAIN Ø3/4[19] (FPT)
FAN ALT 1 256
04 LEGEND 51006/61006
ACCESS
FAN ALT 2 -
1- CONTROL PANEL
2- COMPRESSOR
3- CONDENSER FAN
03
4- CONDENSER COIL
5- EVAP. COIL + ELIMINATOR SECTION
6- EVAP. FAN & MOTOR SECTION
7- 15"BAG FLAT FILTER
8- 1'' FLAT FILTER
A2 A4 9- PLENUM SECTION
34
[864]
72
[1829] 64
34 [1626]
[864]
A 06 09
[532]
21
A
[990]
39
[992]
39
[457]
[354]
13.9
18
F/A
2
02 RIGGING HOLES [51] 08 07 05 09
[100]
ACCESS PANEL Ø2[51] 4 Nos.
4
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
ALL DIMENSIONS ARE IN INCHES[mm]
2- COMPRESSOR
MODEL ALT A
3- CONDENSER FAN
4- CONDENSER COIL FAN ALT 1 288
5- EVAP. COIL + ELIMINATOR SECTION 52008/62008
03 FAN ALT 2 -
6- EVAP. FAN & MOTOR SECTION
7- 15"BAG FLAT FILTER FAN ALT 1 288
8- 1'' FLAT FILTER 52010/62010
9- PLENUM SECTION FAN ALT 2 -
A2 A4
34
[864]
72 64
34 [1829] [1626]
[864] A
1
06 09
[25]
[634]
A
25
[1320]
52
[1420]
55.9
[686]
[583]
23
27
F/A
2
[51] 09
02 RIGGING HOLES 08 07 05
[100]
10 10
01
[254] A1 A3 [254]
LEGEND
DIMENSIONS [mm]
1- CONTROL PANEL
MODEL ALT A
DRAIN Ø1[25] (FPT) 2- COMPRESSOR
04 3- CONDENSER FAN FAN ALT 1 288
ACCESS
52011/62011
4- CONDENSER COIL FAN ALT 2 -
5- EVAP. COIL + ELIMINATOR SECTION
6- EVAPORATOR FAN & MOTOR SECTION FAN ALT 1 288
52013/62013
03
7- 15"BAG FLAT FILTER FAN ALT 2 322
8- 1'' FLAT FILTER
9- PLENUM SECTION
A2 A4
42
[1067] 74
82
[2083] [1880]
36
[914] A 1 06 09
[25]
A
[685]
27
[1370]
[1471]
54
57.9
[583]
[686]
23
27
F/A
2
02 RIGGING HOLES [51] 08 07 05 09
[100]
ACCESS PANEL
4
FOR COMPRESSOR CONTROL CIRCUIT Ø2[51] 4 Nos.
BOTH SIDES POWER SOURCE
ALL DIMENSIONS ARE IN INCHES[mm]
9- PLENUM SECTION
STANDARD
SKM Airconditioning LLCDRG.
PAC4A Model - 52015/52018 & 62015/62018
8- 1'' FLAT FILTER
TITLE EQUIPMENT LAYOUT
7- 15"BAG FLAT FILTER POST BOX No: 6004, SHARJAH, U.A.E.
6- EVAP. FAN & MOTOR TEL : +971 6 514 3333 , FAX : +971 6 514 3300
MODEL PAC-4A-52013 AIR CONDITIONING EQUIPMENT
LEGEND
DIMENSIONS [mm]
1- CONTROL PANEL
2- COMPRESSOR MODEL ALT A
DRAIN Ø1[25] (FPT)
04
3- CONDENSER FAN FAN ALT 1 288
ACCESS
45.9
[1165]
G
90 82
[2286] [2083]
40
[1016]
A
06 09
[813]
A
32
[1600]
[1700]
63
66.9
[687]
[787]
27
31
F/A
2
02 [51] 08 07 09
RIGGING HOLES 05
[100]
ACCESS PANEL
3.9
Ø2[51] 4 Nos.
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
Note :
8- 1'' FLAT FILTER
TITLE EQUIPMENT LAYOUT SKM Airconditioning LLC
7- 15"BAG FLAT FILTER POST BOX No: 6004, SHARJAH, U.A.E.
6- EVAP. FAN & MOTOR TEL : +971 6 514 3333 , FAX : +971 6 514 3300
1.Drawings are not contractually binding. MODEL PAC4A-52018 AIR CONDITIONING EQUIPMENT
26
R410-A
REFRIGERANT
STANDARD DRG.
ACCESS
2- COMPRESSOR MODEL ALT A
3- CONDENSER FAN
04 4- CONDENSER COIL FAN ALT 1 361
52020/62020
5- EVAP. COIL + ELIMINATOR SECTION FAN ALT 2 404
6- EVAPORATOR FAN & MOTOR SECTION
A2 A4
46
[1165]
90 88
[2286] [2235]
40
[1016]
A
1
CONDENSER 06 09
COIL GUARD [25]
[864]
34
[1905]
[2005]
75
78.9
[1041]
[941]
41
37
F/A
2
RIGGING HOLES [51] 08 07 05 09
02
100
ACCESS PANEL Ø2[51] 4 Nos.
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
STANDARD
ALL DIMENSIONS ARE INDRG.
INCHES[mm]
A2 A4
49.9
[1267]
99 88
[2514] [2235]
45
[1143]
A
1 06 10
[25]
A
[864]
34
[1905]
[2005]
75
78.9
[1041]
[941]
41
37
F/A
2 09 08 05 10
02 RIGGING HOLES
100
STANDARD DRG.
PAC4A Model - 52030/52035 & 62030/62035
04
A1 A3
LEGEND
03
1- CONTROL PANEL DIMENSIONS [mm]
2- COMPRESSOR
MODEL ALT A
3- CONDENSER FAN
4- CONDENSER COIL
FAN ALT 1 404
DRAIN Ø1 1/4[32] (FPT)
52030/62030
5- EVAP. COIL + ELIMINATOR SECTION FAN ALT 2 453
ACCESS
6- EVAPORATOR FAN & MOTOR SECTION
FAN ALT 1 404
7- 15"BAG FLAT FILTER 52035/62035
FAN ALT 2 453
8- 1'' FLAT FILTER
9- PLENUM SECTION
01
A4
A2
49.9
[1266]
88
134 [2235]
[3404]
80
[2032] A
1 06 09
[25]
[941]
37
[2361]
92.9
[1600]
63
[1195]
[1295]
47
51
F/A
2
[51]
RIGGING HOLES 08 07 05 09
POWER SOURCE
[125]
Ø2[51] 4 Nos.
4.9
CONTROL CIRCUIT
A4
A2
49.9
[1266]
88
138
[2235]
[3505]
84
[2134]
A
1 06 09
[25]
[1015]
A
40
[2613]
102.9
[1702]
67
[1498]
[1398]
[1498]
59
55
59
F/A
2
RIGGING HOLES 08 07 05 09
POWER SOURCE [51]
[125]
4.9
Ø2[51] 4 Nos.
CONTROL CIRCUIT
28
R410-A
REFRIGERANT
Dimensional Data
Sand Trap Louver Option
PAC4A Model - 51006 & 61006
10 10
01
[254] A1 A3 [254]
DIMENSIONS [mm]
DRAIN Ø3/4[19] (FPT)
MODEL ALT A
04
ACCESS
LEGEND FAN ALT 1 256
51006/61006
1- CONTROL PANEL -
FAN ALT 2
2- COMPRESSOR
3- CONDENSER FAN
03 4- CONDENSER COIL
5- EVAPORATOR COIL + ELIMINATOR SECTION
6- EVAPORATOR FAN & MOTOR SECTION
7- 15"BAG FLAT FILTER
A4 8- 1'' FLAT FILTER
A2 9- PLENUM SECTION
10- F/AIR BOX WITH SAND TRAP LOUVER
34
[864]
72
[1829]
34 64
[864] [1626]
25
A
06 09
[534]
21
A
[1091]
42.9
[990]
39
[457]
[354]
13.9
[418]
16.5
18
F/A
02 RIGGING HOLES 10 08 07 05 09
[100]
ACCESS PANEL Ø2[51] 4 Nos.
4
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
ALL DIMENSIONS ARE IN INCHES[mm]
10 5- EVAP. 10
01 COIL + ELIMINATOR JOB No. - QTY. - SCALE 1:30
[254] A1 A3 [254] NAME SIGN DATE
4- CONDENSER COIL
3- CONDENSER FAN DESIGNED MN 15.03-2021 CLIENT -/-
DRAWN SH 15.03-2021 DIMENSIONS [mm]
2- COMPRESSOR PROJECT -/-
- - - - 1- CONTROL PANEL CHECKED MN 15.03-2021 MODEL ALT A
REV. DATE NAME REMARKS LEGEND APPROVED MNL E G E N D15.03-2021 DRG. No. -/- REV. - SHEET 1 / 1
FAN ALT 1 288
DRAIN Ø3/4[19] (FPT) 52008/62008
1- CONTROL PANEL
04 FAN ALT 2 -
ACCESS
2- COMPRESSOR
3- CONDENSER FAN 288
FAN ALT 1
4- CONDENSER COIL 52010/62010
5- EVAPORATOR COIL + ELIMINATOR SECTION FAN ALT 2 -
03 6- EVAPORATOR FAN & MOTOR SECTION
7- 15"BAG FLAT FILTER
8- 1'' FLAT FILTER
9- PLENUM SECTION
A4 10- F/AIR BOX WITH SAND TRAP LOUVER
A2
34
[864]
72 64
34 [1829] [1626]
25
[864] A
CONDENSER
COIL GUARD 10
[634]
A
25
[1320]
52
[1420]
55.9
[686]
[583]
[686]
23
27
27
F/A
02 RIGGING HOLES 10 09 08 05 10
[100]
10 10
01
[254] A1 A3 [254]
LEGEND
DIMENSIONS [mm]
DRAIN Ø1[25] (FPT) 1- CONTROL PANEL
2- COMPRESSOR MODEL ALT A
04
ACCESS
3- CONDENSER FAN
4- CONDENSER COIL FAN ALT 1 288
52011/62011
5- EVAPORATOR COIL + ELIMINATOR SECTION -
FAN ALT 2
6- EVAPORATOR FAN & MOTOR SECTION
03 7- 15"BAG FLAT FILTER FAN ALT 1 288
8- 1'' FLAT FILTER 52013/62013
FAN ALT 2 322
9- PLENUM SECTION
10- F/AIR BOX WITH SAND TRAP LOUVER
A4
A2
42
82 [1067] 74
[2083] 25 [1880]
36
A
[914]
06 09
[685]
27
[1370]
54
[1471]
57.9
[685]
[686]
[583]
F/A
27
27
23
05
02 RIGGING HOLES 10 08 07 09
[100]
ACCESS PANEL 10 Ø2[51] 4 Nos.
4
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
ALL DIMENSIONS ARE IN INCHES[mm]
8- 1'' FLAT FILTER 9- PLENUM SECTION
TITLE EQUIPMENT LAYOUT SKM Airconditioning LLC
7- 15"BAG FLAT FILTER 10- F/AIR BOX WITH SAND POST BOX No: 6004, SHARJAH, U.A.E.
6- EVAP. FAN & MOTOR TRAP LOUVER TEL : +971 6 514 3333 , FAX : +971 6 514 3300
MODEL PAC-4A-52013
PAC4A Model - 52015 & 62015
AIR CONDITIONING EQUIPMENT
LEGEND
DIMENSIONS [mm]
DRAIN Ø1[25] (FPT) 1- CONTROL PANEL
2- COMPRESSOR MODEL ALT A
ACCESS
3- CONDENSER FAN
4- CONDENSER COIL
FAN ALT 1 288
04 52015/62015
5- EVAPORATOR COIL + ELIMINATOR SECTION
FAN ALT 2 322
6- EVAPORATOR FAN & MOTOR SECTION
A2
46
[1168]
90 82
[2286] [2083]
40
25
[1016]
A
06 09
[813]
A
32
[1600]
[1700]
63
66.9
[802]
[687]
[787]
31.6
F/A
27
31
02 RIGGING HOLES 10 08 07 05 09
[100]
ACCESS PANEL 10
3.9
30
R410-A
REFRIGERANT
LEGEND
1- CONTROL PANEL
DRAIN Ø1[25] (FPT) 2- COMPRESSOR DIMENSIONS [mm]
ACCESS
3- CONDENSER FAN
MODEL ALT A
4- CONDENSER COIL
[305]
12
A4
A2
46
[1168]
90 82
[2286] [2083]
40
25
[1016]
A
06 09
[813]
A
32
[1600]
[1700]
63
66.9
[802]
[687]
[787]
31.6
27
31
F/A
02 RIGGING HOLES 10 08 07 05 09
[100]
ACCESS PANEL
3.9
Ø2[51] 4 Nos.
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
A4
A2
46
[1168]
90 88
[2286] [2235]
40
[1016] A
1
[25] 6 09
A
[864]
34
[1905]
[2005]
75
78.9
[1041]
[1041]
[941]
41
41
37
F/A
RIGGING HOLES 10 08 07 05 09
02
100
LEGEND
1- CONTROL PANEL DIMENSIONS [mm]
2- COMPRESSOR
MODEL ALT A
3- CONDENSER FAN
4- CONDENSER COIL FAN ALT 1 361
52025/62025
DRAIN Ø1[25] (FPT) 5- EVAPORATOR COIL + ELIMINATOR SECTION
FAN ALT 2 404
04
ACCESS
6- EVAPORATOR FAN & MOTOR SECTION
[305]
12
A4
A2
50
[1270]
99 88
[2514] [2235]
45
[1143]
A 1
CONDENSER [25] 06 09
COIL GUARD
[864]
34
[1905]
[2005]
75
78.9
[1041]
[1041]
[941]
41
37
41
F/A
RIGGING HOLES 10 08 07 05 09
02
100
ACCESS PANEL Ø2[51] 4 Nos.
FOR COMPRESSOR CONTROL CIRCUIT
BOTH SIDES POWER SOURCE
FAN ALT 1
4- CONDENSER COIL 52030/62030
FAN ALT 2 453
5- EVAPORATOR COIL + ELIMINATOR SECTION
6- EVAPORATOR FAN & MOTOR SECTION FAN ALT 1 404
03 52035/62035
7- 15"BAG FLAT FILTER FAN ALT 2 453
8- 1'' FLAT FILTER
9- PLENUM SECTION
A4
A2
50
[1270]
134 88
[3404] [2235]
1
80
[25]
[2032] A
06 10
A
[941]
37
[2361]
92.9
[1600]
63
[1295]
[1295]
[1195]
51
51
47
F/A
10 08 07 05 09
POWER SOURCE
[125]
4.9
CONTROL CIRCUIT
1.Drawings are not contractually binding. 5- EVAP. COIL + ELIMINATOR JOB No. - QTY. - SCALE 1:30
NAME SIGN DATE
2.Before designing an installation, consult the certified drawings, available on request.
4- CONDENSER COIL
DESIGNED MN 15.03-2021 CLIENT -/-
3- CONDENSER FAN 10- F/AIR BOX WITH SAND -
3.For single unit and multiple unit installation or unit is installing near to the wall, please
2- COMPRESSOR DRAWN refer
SH to the15.03-2021
TRAP LOUVERrecommended clearance drawings (refer page no:34).
PROJECT -/-
- - - 1- CONTROL PANEL CHECKED MN 15.03-2021
9- PLENUM SECTION
4.Dimensions
REV. DATE NAME
-
shown in standard drawing are suitable only for open trailers. In APPROVED
REMARKS
case of closed
LEGEND MN container please
15.03-2021 DRG. consult SKM as theREV.
No. -/- unit- dimension
SHEET 1 / 1will
change.
32
R410-A
REFRIGERANT
03
LEGEND
DRAIN Ø1 1/4[32] (FPT) 1- CONTROL PANEL DIMENSIONS [mm]
2- COMPRESSOR
ACCESS
MODEL ALT A
3- CONDENSER FAN
4- CONDENSER COIL FAN ALT 1 453
5- EVAPORATOR COIL + ELIMINATOR SECTION 52040/62040
FAN ALT 2 507
6- EVAP. FAN & MOTOR SECTION
7- 15"BAG FLAT FILTER
8- 1'' FLAT FILTER
01
9- PLENUM SECTION
10- F/AIR BOX WITH SAND
[305]
12
A4
A2
50
[1270]
138 88
[3505] [2235]
84
[2134] A
06 09
[1015]
40
[2638]
103.9
[1702]
67
[1501]
[1396]
[1498]
59.1
55
59
F/A
RIGGING HOLES 10 08 07 05 09
POWER SOURCE
[125]
Ø2[51] 4 Nos.
4.9
CONTROL CIRCUIT
Note :
8- 1'' FLAT FILTER
TITLE EQUIPMENT LAYOUT SKM Airconditioning LLC
7- 15"BAG FLAT FILTER POST BOX No: 6004, SHARJAH, U.A.E.
6- EVAP. FAN & MOTOR TEL : +971 6 514 3333 , FAX : +971 6 514 3300
1.Drawings are not contractually binding. MODEL PAC4A-52040 AIR CONDITIONING EQUIPMENT
Recommended Clearances
UNIT INSTALLATION
UNIT INSTALLATION
UNIT INSTALLATION
SPACING FOR SERVICE SPACING FOR AIR FLOW
SPACING FOR SERVICE SPACING FOR AIR FLOW
A
D C
SINGLE UNIT A MULTIPLE UNIT B MODEL
A
30 30
C C DUCT
B
[762] [762]
APMR-51005V
A A
A B MODEL
[
DUCT
30 APMR-51006V
[762] DUCT
APMR-51005V
A A ALL DIMENSIONS ARE IN
DUCT
DUCT
A
C APMR-51006V
DUCT 30 DUCT
B
B C 30
B
B
[762] [762]
UNIT INSTALLATION ALL DIMENSIONS ARE
A
MODELS: APMR- 51005V, 51006V & MODELS: APMR- 51005V, 51006V & A
61005V, 61006V 61005V, 61006V
B
DUCT 30 30
DUCT
SPACING FOR SERVICE B SPACING FOR AIR FLOW
[762] MODELS: PAC4A 51006-52025 & 61006-62025
[762]
MODELS:
SINGLEAPMR-
UNIT 51005V, 51006V & MODELS:UNIT
MULTIPLE APMR- 51005V, 51006V &
61005V, 61006V 61005V, 61006V
A
A A
D
C
B
C
DUCT
DUCT
DUCT
C
B
36
R410-A
REFRIGERANT
GUIDE SPECIFICATIONS
GENERAL lubricated bearings and belt driven by V belt with an adjustable
Packaged Air Conditioners shall be composed of compressor(s), variable pitch motor pulley.
condenser & evaporator coils with fans, refrigerant piping,
electrical components & enclosing cabinet in one piece. These Motor shall be Totally Enclosed Fan Cooled (TEFC), 2 poles or
units shall be factory assembled, internally wired, fully refrigerant 4 poles, class-F insulated, minimum IP55 protection & wired to
charged with R410A, tested under strict quality standards & are unit control panel.
suitable for outdoor installation on rooftop or ground level with
ducted system. REFRIGERANT PIPING
The refrigerant circuit piping shall be fabricated from ACR grade
COMPRESSOR(S) copper piping, with 1 & 2 refrigeration circuits, each liquid line
Compressor shall be hermetic scroll, refrigerant gas cooled shall include, filter drier and expansion valve.
furnished with crankcase heater, and shall be mounted on
rubber isolators. Suction line shall be insulated with ½” (12mm) wall thickness
enclosed cell pipe insulation with maximum K factor 0.28 Btu.in
CONDENSER COIL(S) /ft2.h.°F. (0.040 W/mK).
Coil shall be air cooled with integral sub-cooling circuit, constructed
of seamless copper tubes 3/8” OD mechanically bonded to Piping shall have hot gas bypass system as standard for PAC4A
aluminium or copper with corrugated cross-wave fins with series on the lead compressor.
maximum 14 FPI (1.8mm) or 16FPI (1.6MM) spacing. Coil shall be
tested against leakage by pressurizing air at 715psig (4930kPa) CASING AND STRUCTURE
in coil,, under water, cleaned and dehydrated at the factory. Unit casing shall be made of zinc coated galvanized steel
sheets conforming to JIS-G3302 and ASTMA653 which shall
CONDENSER FAN(S) be phosphatized and then electrostatically dry powder coated
The machine shall be furnished with direct driven propeller type of approx.60 microns to provide an extremely tough, scratch
discharging air upward condenser fans. Fans shall be constructed resistance, excellent anticorrosive protection that can pass 1000
of corrosion resistant blades such as heavy gauge aluminum. hrs in 5% salt spray testing at 95°F (35°C) and 95% relative
The fan and drive shall be held in proper alignment. humidity as per ASTM B117.
Fan assemblies shall be provided with heavy gauge, rust resistant Evaporator section shall be sealed with vinyl gaskets and
steel wire fan guard. All condenser fans shall be individually, completely insulated faced with black glass tissue (BGT) heavy
statically, and dynamically balanced for vibration free Operation. density, fire retardant, 32 Kg/m3
density having Max. K factor 0.23 Btu.in /ft2.h.°F (0.033 W/mK)
Motors shall be Totally Enclosed Air Over, Class-F insulation, and permanent odorless fibre glass insulation. Evaporator section
IP-54 or IP-55 Protected depending on models and factory wired shall be double skin.
to unit control panel.
FILTER SECTION
EVAPORATOR COIL Two stages of filteration shall be provided:
Evaporator coil shall be constructed of seamless copper tubes
3/8” OD mechanically bonded to aluminium or copper corrugated 1- Flat Filter Section incorporating 1” (25mm) thick is provided as
crosswave fins with maximum 14 FPI (1.8mm) spacing. standard and 2” (50mm) thick filter having an average arrestance
efficiency of 54% as per ASHRAE Standard 52.1 or equivalent
Coil consists of headers of seamless copper tubing, expansion can be provided as an option.
valve(s) & multi-circuited distributor(s).
2- Bag filter section incorporating 15” deep bag filter F8.
These coils shall be tested against leakage by air pressure of
450psig (3103kPa) under water. cleaned & dehydrated at the CONTROL PANEL
factory. Coil shall conform to AHRI-410. The panel shall be factory wired and confirm to IP-54 requirements.
Control panel shall contain compressor and motor starting
Evaporator coil section shall be provided with moisture eliminators contactors, electronic control board for unit operation, compressor
to avoid water droplet carryover. anti-recycle time delay, control on/off switch, control circuit breaker
and power, 24V digital thermostat, duct temperature sensor &
EVAPORATOR FAN & DRIVE control terminal blocks. High and Low pressure switches should
Fans of evaporators shall be backward curved, double inlet be provided for protection.
double width (DIDW), centrifugal type, statically & dynamically
balanced, mounted on a single heavy duty shaft with lifetime
NOTES
38
R410-A
REFRIGERANT
NOTES
Contact us
SKM Offices
Kuwait
231/2021A
visit: www.skmaircon.com Supercedes Bulletin # 231/2021
40