Professional Documents
Culture Documents
Poppy Pin
Poppy Pin
Poppy Brooch
Pattern and instructions
Materials:
5321 5310
2
Poppy Brooch
Abbreviations
This Pattern uses US Terminology
rnd/rnds – round/rounds
mr - magic ring
ch - chain
sc - single crochet
sc inc - single crochet increase
sc dec - single crochet decrease
hdc - half double crochet
hdc inc - half double crochet increase
hdc dec - half double crochet decrease
dc - double crochet
dc inc - double crochet increase
dc dec - double crochet dec
tc - triple crochet
tc inc - triple crochet increase
tc dec - triple crochet decrease
quad - quadruple crochet
tog - together
slst - slip stitch
st - stitch
f/o - fasten off
Fa cebook - Etsy - Ra velry Leopard Lily - Ori ginal design by Pi ppa Pa tterns 2017 3
Poppy Brooch
Pattern Instructions
Notes: When you see stitches in brackets, it means that all the
ones in the bracket are worked in to one stitch.
Example: (sc inc) means 2sc worked in to one stitch.
(3sc) means 3sc in the same stitch.
(3sc) x 2 means 3sc in each of the next 2 stitches.
Petal
Make 3
Rnd.1:
Ch5,
Skip1,
2sc,
(3sc) in the last chain, going down the other side,
2sc,
(3sc) in the skipped chain from the beginning.
Rnd.2:
1sc,
(1hdc, 1dc, 1tc),
(1tc, 1dc, 1hdc),
Petal - Wire
Cut a piece of approximately 8”(20cm) of florist wire and thread it
through the stitch on your hook (p1 & 2).
Crochet this whole next round over the wire (p3).
1 3
Rnd.3:
(ch1, 1sc),
1sc,
1hdc,
(1dc, 1tc),
(2tc, 1quad),
(1quad, 2tc),
1tc,
(tc inc),
2tc,
2
1dc in to the centre stitch,
2tc,
(tc inc),
1tc,
(2tc, 1quad),
(1quad, 2tc),
(1tc, 1dc),
1hdc,
2sc,
Slst in the 1st chain on the opposite side.
Sew in the tail
Corolla
Corolla: Crochet Button
Assembly
Place the first 2 petals together as shown in (p1).
Twist the wires tight together at the base (p2).
Place the last petal on top with the good side touching and
again twist the wire at the base (p3).
Pull the corners of each petal over the one before (like fan)
as shown in (p4).
Push all the petals up a bit (p5).
Thread the tails of the corolla through the darning needle
(p6) and stitch through the middle of the flower (p7).
Pull the tails out underneath (p8).
1 2 3 4
5 6 7 8
Assembly
Wind the tails around the stem and trap the end in between the wires.
Spray generously with hairspray to glue the yarn together at the end (p1)
or use glue if you prefer. Once dry, cut the end off (p2). You can leave the
petals as they are or bend the edges out a bit (p3).
Use a pin or safety pin to attach the poppy to your collar.
1 2 3
4 5
The End
Congratulations on creating your very own
Poppy Pin
We would love for you to share your
finished product…