This document contains a quiz on ASME and NBIC code knowledge related to ASME Section VIII Division 1 from 2023. The quiz question asks where a circular nozzle with an internal diameter greater than 30% of the shell or channel diameter cannot be located for a non-simply supported heat exchanger according to the code. The correct answer is that no part of the nozzle can be located within 1.8 times the diameter from the adjacent tubesheet face, referencing a specific code paragraph for more details.
Original Description:
2023
Original Title
ISSUE 477 QUIZ-Nozzles Adjacent to Tubesheets-VIII.1
This document contains a quiz on ASME and NBIC code knowledge related to ASME Section VIII Division 1 from 2023. The quiz question asks where a circular nozzle with an internal diameter greater than 30% of the shell or channel diameter cannot be located for a non-simply supported heat exchanger according to the code. The correct answer is that no part of the nozzle can be located within 1.8 times the diameter from the adjacent tubesheet face, referencing a specific code paragraph for more details.
This document contains a quiz on ASME and NBIC code knowledge related to ASME Section VIII Division 1 from 2023. The quiz question asks where a circular nozzle with an internal diameter greater than 30% of the shell or channel diameter cannot be located for a non-simply supported heat exchanger according to the code. The correct answer is that no part of the nozzle can be located within 1.8 times the diameter from the adjacent tubesheet face, referencing a specific code paragraph for more details.
Chutchai Phromngam, Authorized Inspector & Supervisor RELATED CODE : ASME SECTION VIII.1, E2023 Line ID: cphromngam, Chutchai.phromngam@apave.com Cont’d FIG-1
Nozzle adjacent to Tubesheet
2/3
QUIZ: ASME AND NBIC CODE KNOWLEDGE ISSUE 477
By using information provided on page no. 2 to answer the following question, For a non-simply supported heat exchanger, a circular nozzle with internal diameter (d) greater than 30% of the shell or channel diameter(D), shall be located to where no part of dmay be located within 1.8(Dt) of the______________.