Professional Documents
Culture Documents
1- Wound Rotor
2- Squirrel Cage
Faculty of Engineering
Objective
Equipment
1- Induction Motor
2- Power Pack
3- Power meter
4- Voltmeter
5- Ammeter
Where:
R1 : stator resistance
X1 : stator leakage reactance
Xm: magnetizing reactance
Rc : machine core loss resistor
X2 : rotor leakage reactance
R2 : rotor resistance
Faculty of Engineering
Slip:
Faculty of Engineering
The no-load test, like the open circuit test on a transformer, gives information
about the excitation current and the rotational losses. The testis performed by
applying balanced rated voltage on the stator windings at the rated frequency. The
small power provided to the machine is due to core losses, friction and windage
losses. The machine will rotate at almost the synchronous speed, which makes slip
nearly zero. The stator windings are star connected
Connect the circuit shown in figure, run the motor at rated voltage ,and frequency.
Read from the power meter, the phase voltage (Vo), the current (Io), and the total
power (Po ).
Connect the circuit shown in figure and hold the shaft at stand still.
Read from the power meter , the phase voltage (Vs), the phase current (Is),
and the total power Ws.
Faculty of Engineering
Calculate
Connect the circuit show in figure to calculate the stator resistance per
phase. Vary the dc input voltage(Vdc) and read for each step the current (Idc)
this current should not exceed (2A)
Plot the curve between (Vdc) as Y axis and (Idc) as X axis then, calculate
the slope (Rdc )
AC Machines
Connection steps:
• Final Circuit:
Faculty of Engineering