Has the operation of the following equipment has been studied and fully understood? Alarms Bridge lighting, including controls for decks and over side illumination Direction finder Anchoring and mooring equipment Electronic navigational position fixing aids Emergency arrangements in the event of main engine failure Hazard monitoring equipment Gyro compass / repeaters Magnetic compass Navigation lights, including emergency navigation, not under command and other signal lights Radar and associated plotting aids Course recorder Steering gear, including manual, auto-pilot and emergency Telegraph including control of main engines and Water tight doors a. Is he aware of the location and operation of the auxiliary bridge equipment (e.g. binoculars, signalling flags, meteorological equipment)? b. Is he familiar with the stowage of chart and hydro graphic publications? c. Is he familiar with radio room equipments (main transmitters, receiver, and communication’s systems)? LIFE SAVING EQUIPMENT / FIRE FIGHTING EQUIPMENT (for all) Are you familiar with the use of the following? Lowering of life boats Use of life jackets Use of life boat’s equipment Use of life rafts First Aids Position and equipment of hoses storeroom Use of life rafts with launching device Emergency Steering Use of thermal/fire suit Use of portable extinguishers Use of the equipment of fire hoses storeroom Position and use of pollution prevention equipment Intercommunication system Duties during emergency situations Knowledge of the safety and environmental protection policy of the Company FAMILIARIZATION WITH ISM RISK Management Is crew member assessing with risk(s) on their place of work, is he assured that all such risks are kept under control and specific procedures are available to maintain such risks continuously