Professional Documents
Culture Documents
18. After a tire has been changed, the driver should stop after a short distance to:
21. When asked to complete an offset back/right parking maneuver, you should:
a) When the air compressor pumps air into the air storage tanks.
b) How fast air is pumped into the air storage tanks.
c) The temperature of air pumped into the air storage tanks.
d) The speed of the vehicle.
d) You should only worry about the track closest to your vehicle.
33. When inspecting your brakes, a slack adjuster should move ____ from where it
isattached to the push rod.
34. An item that is 40 feet long placed on a flatbed trailer should be secured by at
least____ tie-down(s).
a) One
b) Two
c) Three
d) Four
38. If an Anti-Lock Braking System (ABS) is equipped on a trailer but not on a tractor:
a) The truck should not be driven because ABS needs to be on both the tractor and
trailer.
b) The truck should be driven more slowly than usual.
c) The tractor should not be used and a new tractor with ABS should be located.
d) The tractor and trailer can still be used together.
39. What happens if the air pressure in a system's air tanks falls below 60 psi?
40. On a truck with air brakes, the braking system’s air compressor:
42. During the straight line backing exercise, how many times are you permitted
to exitthe vehicle to check its position?
a) One time
b) Two times
c) Three times
d) Four times
a) Maintain full-capacity air pressure in the braking systems even when the
vehicle is notrunning.
b) Maintain some air pressure in the braking systems when the vehicle is
not running.
c) Must be run to build enough air pressure to brakes to operate properly.
d) Do not need time to build air pressure before a trip.
44. Be sure you are always driving so your vehicle can stop:
a) Within 10 feet of your current position.
b) Within 1,000 feet of your current position.
c) Within your view of the road ahead.
d) Immediately.
TEXT-2
a) 100 feet
b) 250 feet
c) 300 feet
d) 450 feet
21. If braking at a speed of 55 mph while driving on dry pavement, the brake
lag can add____ to your vehicle's total stopping distance.
a) 32 feet
b) 15 feet
c) 50 feet
d) 10 feet
a) Applies and releases the brakes when you press the brake pedal while driving
normally.
b) Applies and releases the parking brakes.
c) Applies and releases the emergency brake.
d) Applies and releases the axle brake.
32. During a basic vehicle control skills test, what is considered a look?
a) Drains the water and compressor oil from the air tanks.
b) Prevents air from escaping if the air compressor has a leak.
c) Activates the emergency brakes when there is a leak.
d) Holds the spring brakes in position until they are used.