Professional Documents
Culture Documents
PP3 B481eu
PP3 B481eu
Print out
lamp begins blinking.
lamp begins
blinking. DataBusy DataReady
SelfCheck DataReady PROCESS
PROCESS
DATA
after at least 5 seconds. computer and also cleared by message indication section,
* Notify your dealer of the error code pressing the [ON LINE] key. indicating the location of the paper
number when the error code is See page 106 in the Instruction jam.
displayed again. Manual about the details. Open the front door, confirm the
jammed paper and remove it. Each
number, letters [D] and [R] show
the location in the diagram.
Magazine
The Magazine D is not set Replace the Magazine D when the
D Magazine correctly. Set it correctly. [DONOR EMPTY] lamp lights up.
R *After replacing the donor, perform a calibration
Toggles between (Standard color condition setup).
ON LINE and
OFF LINE.
ON LINE The Magazine R is not set Replace the Magazine R when the
correctly. Set it correctly. [PAPER EMPTY] lamp lights up.
Service HXX DataBusy CXX JXX:123456789DR CheckMagazine(D) CheckMagazine(R) Warning Front door
OFF LINE
Magazine R
DATA
During receiving
the image data
from the host
Check the water in the water bottle. Change water when the
computer, this Change water when the water level [WATER CHANGE] lamp
lamp blinks. CheckFilter ChangeFilter CheckWaterTank drops due to evaporation. lights up.
PROCESS
Water
Displays the amount of the water that can coat the donor until
water replacement.
MEC V er.X.XX
ColorControl Brigtness 0
Adjusts the brightness of the print.
Contrast 0
Adjusts the contrast of the print.
R.Balance 0
Adjusts the balance of the red color of the print.
G.Balance 0
Adjusts the balance of the green color of the print.
B.Balance 0
Adjusts the balance of the blue color of the print.
Matching ON1
Selects ON or OFF of the function which controls the colors
on the print image to match with the color on the monitor screen.
Buzzer ON
Sets up the function On and OFF of the buzzer sound.
MarginControl X 0 mm
Sets up the X margin of the print.
Dev Printer Y 0 mm
Sets up the device type Sets up the Y margin of the print.
(printer, processor).
Calibration 1)PrintRef.
Makes the calibration pattern.
2)MeasureDens.
Measures the calibration pattern.