Professional Documents
Culture Documents
The amount of blended materials added depends on the quality of the clinker and
the characteristics of the blended materials. If the clinker quality is good, a larger
amount of blended materials can be added. However, exceeding the maximum
limit of blended materials will significantly decrease the strength of the cement. The
amount of blended materials added depends on the type of cement, clinker quality,
and properties of the blended materials.
5. Control of Setting Time
The setting time of cement is a reflection of its hydration rate and is related to the
amount of gypsum added and the quality of the clinker. The setting process can be
divided into initial setting and final setting. According to national standards, the
initial setting time of “Grade V” cement should not be earlier than 45 minutes, and
the final setting time should not be later than 12 hours. Generally, the actual setting
time is controlled within 1 to 3 hours for initial setting and 3 to 5 hours for final
setting.
6. Control of Cement Stability
Cement stability refers to the physical property that reflects the volume changes of
cement after hardening.