Professional Documents
Culture Documents
.Q1
صف طريقة عملها.) في معالجة المخلفات الصناعية السائلةAir Floation ( (أ) أذكر فائدة التعويم الهوائي
و ما هو العيب الوحيد في هذه األجهزة؟
ناعية,,ائلة ص,ات س,ة مخلف,(ب) المطلوب تصميم أحواض الترسيب االبتدائية من النوع المستطيل الالزمة لمعالج
ول,بة الط,أن نس,ع العلم ب, م،وم,ي/م48 =واض,طحي لألح,ل الس,دل التحمي, إذا علمت أن مع،وم,ي/3 م66000قدرها
. متر3 مع افتراض عمق الحوض4:1 إلى العرض تساوي
(c) The following test results were obtained for a WW sample. All of the tests were
performed using a sample size of 50 mL. Determine the concentration of total
solids(TS), total suspended solids (TSS), volatile suspended solids (VSS), and total
dissolved solids (TDS). The samples used in the solid analysis were all either
evaporated, dried or ignited to constant weight.
Tare mass of evaporating dish = 53.5433 g
Mass of evaporating dish + residue after evaporation at 105oC = 53.5794 g
Mass of evaporating dish + residue after ignition at 550oC = 53.5625 g
Tare mass of Whatman GF/C filter after drying at 105oC = 1.5433 g
Mass of Whatman GF/C filter + residue after drying at 105oC = 1.5554 g
Mass of Whatman GF/C filter + residue after ignition at 550oC = 1.5476 g
Hint: TDS=TS-TSS
.Q2
Dilution is a prominent method of natural disposal, consists of discharging the )a(
wastewater into receiving water body (Such as river, sea, lake etc.).What is the
?important precation must be considered before implementing this option
(أذكر باختصار العوامل التي تعتمد عليها عملية الترسيب في المعالجة الكيميائية للمخلفات السائلة )ب
الصناعية.
3
(c) An Industrial wastewater having a BOD of 450 g/m is to be treated by a two-
stage trickling filter. The desired effluent quality is 56 g/m 3 of BOD. If both of the
1
filter depths are to be 1.83 m and the recirculation ratio is 2:1, find the required filters
diameter using NRC equation. Assume the following design assumptions apply.
(Note: g/m3=mg/L):
Flow rate = 7550 m3/d.
Filter depth, h = 1.80 m.
Wastewater temperature = 20°C
E 1 = E2
Hint: E1 = 100/ [1+ 0.448(W1 /V1.F1) 0.5] F1 = (1+r1)/(1+0.1r1) 2
100
1+ R 2 −b ± √ b2−4 ac
E2 = 1+
√
0.448 W 2
1−E 1 V 2 F2
F2 = ( 1+0.1 R ) 2
ET = E1 + E2 ( 1- E1)
2
x=
2a
Q3.
(a) Completely mixed activated sludge plant is to treat 10,000 m 3/d of industrial
wastewater .The wastewater has a BOD5 of 1200 mg/L that must be reduced to 200
mg/L prior to discharge to a municipal sewer. Pilot plant analysis indicates that a
mean cell resident time of 5 day maintaining MLSS concentrationof 5000 mg/L and
underflow concentration of 15000 mg/L. The value for Y is determine to be 0.70
kg/kg and value of kd is found to be 0.03 d-1. Determine:
i. The volume of the reactor.
ii. The mass and volume of solids waasted each day.
iii. The sludge recirculation ratio.
متر3 = Qw (ج) محطة معالجة مياه صرف صناعي يصدر منها سائل نهائي بمعدل دفق يساوي
فإذا كانت قيمة األكسجين الحيوي المستهلك في المورد. لتجد طريقها في مورد مائي مجاور،ثانية/مكعب
كما تم قياس.دقيقة/3 م1620 بمعدل دفق يبلغQr وينساب الماء خالل المورد،لتر/ ملجم8 تبلغPr المائي
أوجد قيمة األكسجين الحيوي.لتر/ ملجم14.7 تركيز األكسجين الحيوي المستهلك أدنى المصب فوجد
. وكذلك نسبة التخفيف التي تحققت بفعل المورد المائي. الخارج من محطة المعالجةPw المستهلك
Qr Qr
) Qw ( Pm [ 1 + ( Qw )] = Pw + Pr
2
Q4.
لتحويل الملوثات السامةOxidation/Reduction (أ) " تستعمل المعالجة الكيميائية باألكسدة و االختزال
إلى مواد غير ضارة بالبيئة أو إلى مواد أقل ُس مية" تكلم عن مكونات هذه المعالجة و طريقة عملها؟
(b) The industrial zone of Ras Lanuf has been directed to upgrade its WWTP to a
secondary plant that can meet an effluent standard of 30 mg/L BOD5 and 30 mg/L of
suspended solids (SS). They have selected a completely mixed activated sludge
system with MLSS = 2000 mg/L. The effluent BOD5 was measured as 11.1 mg/L.
Determine the aeration tank volum. The following data are available for the
existing primary plant.
Existing plant effluent characteristics:
Flow = 0.150 m3/s , BOD5 = 84 mg/L
Assume the following values for growth constants:
Ks = 100 mg/L , μm = 2.5d-1 , Kd = 0.05 d-1, Y = 0.50 , θc = 10 d
Hint: S = Ks (1+ Kd θc ) / θc ( μm – Kd ) –1
X = θc Y (So - S) / θ (1+ Kd θc )
Where; θ = V/Q and X = MLSS and S =effluet BOD
عامل مهم وفعال في أي أسلوب من أساليبSolubility ولماذا تعتبر الذائبية.(ج) عرف المعالجة الكيميائية
المعالجة الكيميائية؟
Q5.
(a) Wastewater from a poultry- processing plant average 1000 m3/d with BOD5 of
10,000 mg/L. The waste is to be treated in a three-cell facultative pomd system in
which the 20 ̊C reaction rateconstant k has been found to be 0.5 d-1. The coldest
monthly average temperature is expected to be 10 ̊C . For despersion coefficient of
0.25 . Determine the surface area required to meet an effluent standard of 50 mg/L.
3
(b) A high rate aeration system produces 1140 m3/d. of waste sludge. The sludge is
wasted directly from the aerator has solids content of 3300 mg/L.This sludge is
thickened by dissolved air flotation unit to 3% solids. Determine the volume of
thickened sludge produced each day.
ما هي أهم المعلومات التي تستعين بها.)ج) تم اختيارك للمشاركة في تصميم محطة معالجة مياه صرف صناعي
في التصميم؟ وما هي التجارب التي ستجريها لمعرفة خواص مياه الصرف الصناعي؟
4
GOOD LUCK