METROLOGY 1. Linear measurements with inside, outside and depth micrometers, Vernier calipers and Height gauges. METROLOGY: 2. Measurement of roundness 1. Linear measurements with inside, Any FIVE experiments from the following errors with Bench Centre outside and depth micrometers, Vernier 1. Measurement of lengths, heights, diameters method and V-block method. calipers and Height by vernier calipers micrometers etc. 3. Measurement of thread gauges. 2. Measurement of bores by internal elements with Tool Maker‟s 2. Measurement of roundness errors 1. Internal and external taper micrometers and dial bore indicators. Microscope 4. Measurement of angles with with Bench Centre method and V-block measurement. 3. Use of gear teeth, Vernier calipers and Sinebar, Bevel protractor and method. 2. Thread measurement using checking the chordal addendum and Precision level. 3. Measurement of thread elements with floating carriage diameter chordal height of spur gear. 5. Tolerance measurement Tool Maker‟s Microscope measuring machine. 4. Use of spirit level in finding the flatness of with Comparator and GO -No 4. Measurement of angles with Sinebar, 3. Straightness measurement surface plate. GO Bevel protractor and Precision level. using auto-collimator. 5. Thread measurement by two wire/ three wire Gauge. 5. Tolerance measurement with 4. Measurement of Thread and method or tool makers’ microscope. 6. Calibration of Outside Electrical Comparator, Mechanical Gear profiles for their form and 6. Tool makers microscope and its application micrometer and Dial gauge. Comparator and GO -No GO geometrical accuracies. 7. Angle and taper measurements by bevel INSTRUMENTATION Gauge. 5. Demonstration Coordinate protractor, sine bars, etc. 1. Calibration of transducer for 6. Calibration of Outside micrometer Measuring Machine for the 8. Surface roughness measurement temperature measurement. 2. Study and calibration of and Dial gauge. evaluation of form errors. 9. Machine tool alignment test on a lathe. LVDT transducer for 7. Profile measurement with profile 10. Machine tool alignment test on a milling displacement measurement. projector machine. 3. Calibration of strain gauge 8. Surface roughness measurement 11. Surface wear resistances test using electro for temperature measurement. using surface roughness tester spark coating device. 4. Calibration of thermocouple for temperature measurement. 5. Calibration of capacitive transducer for angular displacement.