Professional Documents
Culture Documents
Minimum Maximum
Parameter Value Units
Measured Measured
HHHHHH: 001856:00: 001856:00:
ECM Time (Key On Time) 001856:02:59
MM:SS 56 56
Engine Distance 12515.2 mi 12515.2 12515.2
Engine Brake Output Circuit 1 Inactive
Engine Brake Output Circuit 2 Inactive
Engine Brake Output Circuit 3 Inactive
Engine Brake Output Circuit 4 Inactive
Engine Brake Selector Switch 1 On
Engine Brake Selector Switch 2 Off
Engine Brake Switch Level 33 percent 33 33
Engine Coolant Level Normal
Engine Coolant Temperature 140.6 °F 131.2 140.6
Engine Coolant Temperature Sensor Signal Voltage 1.50 V 1.50 1.69
HHHHHH: 001810:24: 001810:24:
Engine Hours 001810:26:54
MM:SS 50 50
Engine Oil Pressure 43.9 psi 34.8 45.7
Engine Oil Pressure Sensor Signal Voltage 2.63 V 2.19 2.69
Engine Oil Pressure Sensor Type Analog
Engine Oil Temperature 141.8 °F 130.6 141.8
Engine Oil Temperature Sensor Signal Voltage 1.44 V 1.44 1.75
Engine Operating State All Speed Accelerator
Engine Protection Derate Suppress Disable
Engine Protection Shutdown Override Switch Off
Engine Speed 1634 RPM 786 1763
Engine Speed Backup Sensor State Valid Signal
Engine Speed Backup Synchronization State Have Synchronization
Engine Speed Main Sensor Signal State In Range
Engine Speed Main Sensor State Valid Signal
Engine Speed Main Synchronization State Have Synchronization
Engine Speed Sensor Active Main
Engine Speed Status Good
Accelerator Pedal
Engine Torque Mode
Operator Selection
Engine Warmup Protection Status Inactive
Exhaust Gas Pressure 75.38 InHg 43.86 77.80
Exhaust Gas Pressure Sensor Signal Voltage 1.94 V 1.19 2.00
Exhaust Gas Temperature (Calculated) 426 °F 310 426
Exhaust Mass Flowrate 40.2 lb/min 14.9 42.7
Fan Control 2 Multiplexed Request Level 0.0 percent 0.0 0.0
Fan Control Command 0 percent 0 0
Fan Control Multiplexed Request Level 0 percent 0 0
Fan Control Switch On
Fan Drive State Manual Switch or Datalink
Fuel Flow Rate Commanded 12.03 gph 0.00 22.06
Fuel Pump Actuator Commanded Current 1.44 mA 1.25 2.19
Minimum Maximum
Parameter Value Units
Measured Measured
Fuel Pump Actuator Duty Cycle 36 percent 31 48
Fuel Pump Actuator Measured Current 1.56 mA 1.44 2.19
Fuel Pump Actuator Position Close
Fuel Rail Pressure Commanded 19404 psi 6732 21852
Fuel Rail Pressure Measured 19274 psi 6226 22126
Fuel Rail Pressure Sensor Signal Voltage 2.37 V 1.11 2.63
Idle Validation Switch Off Idle
Instantaneous Fuel Economy 0.0 mpg 0.0 0.0
Intake Manifold Air Temperature 97.3 °F 95.4 97.4
Intake Manifold Air Temperature Sensor Signal Voltage 0.94 V 0.94 0.94
Intake Manifold Pressure 22.5 InHg 5.5 23.1
Intake Manifold Pressure Sensor Signal Voltage 1.56 V 1.13 1.63
J1939 Engine Source Address 0 0 0
J1939 Stop Broadcast Source Address One 0 0 0
J1939 Stop Broadcast Source Address Three 0 0 0
J1939 Stop Broadcast Source Address Two 0 0 0
Keyswitch On
Keyswitch Off Counts 370 370 370
Keyswitch On Counts 371 371 371
Load Based Speed Control Status Not Limiting
Low Idle Adjustment Switch Neutral
OEM Ambient Air Temperature 86 °F 86 86
OEM Ambient Air Temperature Sensor Signal Voltage 2.94 V 2.94 2.94
Percent Accelerator Pedal or Lever 62 percent 0 72
Percent Load 8 percent 0 22
Percent Remote Accelerator Pedal or Lever 0 percent 0 0
Red Stop Lamp Status Off
Remote Accelerator Pedal or Lever Switch Off
Remote Accelerator Position Sensor Voltage 0.8 V 0.8 0.8
Sensor Supply 1 5.00 V 5.00 5.00
Sensor Supply 2 5.00 V 5.00 5.00
Sensor Supply 3 5.00 V 5.00 5.00
Sensor Supply 4 5.00 V 5.00 5.00
Sensor Supply 5 5.00 V 5.00 5.00
Sensor Supply 6 5.00 V 5.00 5.00
Starter Lockout Relay Command Open
Transmission Gear Ratio 16.00 16.00 16.00
Turbocharger Actuator Position Commanded (Percent 53 percent 50 71
Turbocharger Actuator Position Measured (Percent Closed) 53 percent 49 72
Turbocharger Actuator Position Sensor Signal Voltage 0.00 V 0.00 0.00
Turbocharger Actuator Type Electric
Turbocharger Compressor Intake Air Temperature 88.2 °F 87.9 99.7
Turbocharger Compressor Intake Air Temperature Sensor
2.69 V 2.63 2.69
Signal Voltage
Minimum Maximum
Parameter Value Units
Measured Measured
Turbocharger Speed 75062 RPM 38641 76867
Turbocharger Speed Derate Active Inactive
Vehicle Speed 0 mph 0 0
HHHHHH: 000000:00: 000000:00:
Water In Fuel Detected Total Accumulated Time 000000:00:00
MM:SS 00 00
Water in Fuel Sensor Signal Voltage 4.1 V 4.0 4.1
Water In Fuel State No Water Detected