of action of the load does not pass through the center of gravity of group of bolts.
Determine the stress in bolt 1 if 20 mm
diameter bolts are used. The load applied is 160 kN.
From the figure shown, bolt diameter = 22
mm, Determine the following:
1. Shear stress due to load alone
2. Shear stress due to torque
3. Most critical rivet
4. Maximum shear stress
Principles of Steel Design Module 7 Eccentrically loaded connection
The bolts to be used in the connection
shown are 22-mm-diameter A325N bolts. 1. Determine the polar moment of inertia per mm². 2. Determine the load in the critical bolt if P acts on the centroid of the bolt group. 3. Determine the load in the critical bolt due to torsion. 4. Calculate the shear stress on the critical bolt.