Professional Documents
Culture Documents
SDS Armor All Snow Foam Car Wash Bottle US en 2023 09 11
SDS Armor All Snow Foam Car Wash Bottle US en 2023 09 11
SECTION 1: Identification
- Pictograms
GHS07
- Hazard statements
H315 Causes skin irritation.
H317 May cause an allergic skin reaction.
H319 Causes serious eye irritation.
- Precautionary statements
P101 If medical advice is needed, have product container or label at hand.
P102 Keep out of reach of children.
P103 Read label before use.
P261 Avoid breathing mist/vapors.
P272 Contaminated work clothing must not be allowed out of the workplace.
P280 Wear protective gloves.
P302+P352 If on skin: Wash with plenty of water.
P305+P351+P338 If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P321 Specific treatment (see on this label).
P333+P313 If skin irritation or rash occurs: Get medical advice/attention.
P337+P313 If eye irritation persists: Get medical advice/attention.
P362 Take off contaminated clothing and wash before reuse.
P363 Wash contaminated clothing before reuse.
P501 Dispose of contents/container in accordance with local/regional/national/international regula-
tions.
3.1 Substances
Not relevant (mixture)
3.2 Mixtures
Description of the mixture
Following inhalation
If breathing is irregular or stopped, immediately seek medical assistance and start first aid actions. In case of respiratory
tract irritation, consult a physician. Provide fresh air.
Following ingestion
Rinse mouth with water (only if the person is conscious). Do NOT induce vomiting.
4.2 Most important symptoms and effects, both acute and delayed
Symptoms and effects are not known to date.
4.3 Indication of any immediate medical attention and special treatment needed
none
Coun Name of agent CAS No Iden- TWA TWA STEL STEL Ceil- Ceil- Nota Sourc
try tifier [ppm] [mg/ [ppm] [mg/ ing-C ing-C tion e
m³] m³] [ppm] [mg/
m³]
Notation
appx-D see Appendix D - Substances with No Established RELs
Ceiling-C ceiling value is a limit value above which exposure should not occur
i inhalable fraction
mist as mists
r respirable fraction
STEL short-term exposure limit: a limit value above which exposure should not occur and which is related to a 15-minute period
(unless otherwise specified)
TWA time-weighted average (long-term exposure limit): measured or calculated in relation to a reference period of 8 hours time-
weighted average (unless otherwise specified
Name of sub- CAS No End- Threshold Protection goal, Used in Exposure time
stance point level route of expos-
ure
Sulfonic acids, C14- 68439-57-6 DNEL 152.2 mg/ human, inhalatory worker (industry) chronic - systemic
16-alkane hydroxy m³ effects
and C14-16-alkene,
sodium salts
Sulfonic acids, C14- 68439-57-6 DNEL 2,158 mg/ human, dermal worker (industry) chronic - systemic
16-alkane hydroxy kg bw/day effects
and C14-16-alkene,
sodium salts
Sodium sulfate 7757-82-6 DNEL 20 mg/m³ human, inhalatory worker (industry) chronic - systemic
effects
Sodium sulfate 7757-82-6 DNEL 20 mg/m³ human, inhalatory worker (industry) chronic - local ef-
fects
Cocamidopropyl be- 61789-40-0 DNEL 8.22 mg/m³ human, inhalatory worker (industry) chronic - systemic
taine effects
Cocamidopropyl be- 61789-40-0 DNEL 2.33 mg/kg human, dermal worker (industry) chronic - systemic
taine bw/day effects
Name of sub- CAS No End- Threshold Protection goal, Used in Exposure time
stance point level route of expos-
ure
Methylchloroiso- 55965-84-9 DNEL 0.02 mg/m³ human, inhalatory worker (industry) chronic - local ef-
thiazolinone fects
Methylchloroiso- 55965-84-9 DNEL 0.04 mg/m³ human, inhalatory worker (industry) acute - local effects
thiazolinone
Sulfonic acids, C14- 68439-57-6 PNEC 0.024 mg/l aquatic organ- freshwater short-term (single
16-alkane hydroxy isms instance)
and C14-16-alkene,
sodium salts
Sulfonic acids, C14- 68439-57-6 PNEC 0.002 mg/l aquatic organ- marine water short-term (single
16-alkane hydroxy isms instance)
and C14-16-alkene,
sodium salts
Sulfonic acids, C14- 68439-57-6 PNEC 4 mg/l aquatic organ- sewage treatment short-term (single
16-alkane hydroxy isms plant (STP) instance)
and C14-16-alkene,
sodium salts
Sulfonic acids, C14- 68439-57-6 PNEC 0.767 mg/kg aquatic organ- freshwater sedi- short-term (single
16-alkane hydroxy isms ment instance)
and C14-16-alkene,
sodium salts
Sulfonic acids, C14- 68439-57-6 PNEC 0.077 mg/kg aquatic organ- marine sediment short-term (single
16-alkane hydroxy isms instance)
and C14-16-alkene,
sodium salts
Sulfonic acids, C14- 68439-57-6 PNEC 1.21 mg/kg terrestrial organ- soil short-term (single
16-alkane hydroxy isms instance)
and C14-16-alkene,
sodium salts
Sodium sulfate 7757-82-6 PNEC 11.09 mg/l aquatic organ- freshwater short-term (single
isms instance)
Sodium sulfate 7757-82-6 PNEC 1.109 mg/l aquatic organ- marine water short-term (single
isms instance)
Sodium sulfate 7757-82-6 PNEC 800 mg/l aquatic organ- sewage treatment short-term (single
isms plant (STP) instance)
Sodium sulfate 7757-82-6 PNEC 40.2 mg/kg aquatic organ- freshwater sedi- short-term (single
isms ment instance)
Sodium sulfate 7757-82-6 PNEC 4.02 mg/kg aquatic organ- marine sediment short-term (single
isms instance)
Sodium sulfate 7757-82-6 PNEC 1.54 mg/kg terrestrial organ- soil short-term (single
isms instance)
Cocamidopropyl be- 61789-40-0 PNEC 3.2 µg/l aquatic organ- freshwater short-term (single
taine isms instance)
Cocamidopropyl be- 61789-40-0 PNEC 0.32 µg/l aquatic organ- marine water short-term (single
taine isms instance)
Cocamidopropyl be- 61789-40-0 PNEC 300 mg/l aquatic organ- sewage treatment short-term (single
taine isms plant (STP) instance)
Cocamidopropyl be- 61789-40-0 PNEC 0.219 mg/kg aquatic organ- freshwater sedi- short-term (single
taine isms ment instance)
Cocamidopropyl be- 61789-40-0 PNEC 21.9 µg/kg aquatic organ- marine sediment short-term (single
taine isms instance)
Cocamidopropyl be- 61789-40-0 PNEC 41.9 µg/kg terrestrial organ- soil short-term (single
taine isms instance)
Methylchloroiso- 55965-84-9 PNEC 3.39 µg/l aquatic organ- freshwater short-term (single
thiazolinone isms instance)
Methylchloroiso- 55965-84-9 PNEC 3.39 µg/l aquatic organ- marine water short-term (single
thiazolinone isms instance)
Methylchloroiso- 55965-84-9 PNEC 0.23 mg/l aquatic organ- sewage treatment short-term (single
thiazolinone isms plant (STP) instance)
Methylchloroiso- 55965-84-9 PNEC 0.027 mg/kg aquatic organ- freshwater sedi- short-term (single
thiazolinone isms ment instance)
Methylchloroiso- 55965-84-9 PNEC 0.027 mg/kg aquatic organ- marine sediment short-term (single
thiazolinone isms instance)
Methylchloroiso- 55965-84-9 PNEC 0.01 mg/kg terrestrial organ- soil short-term (single
thiazolinone isms instance)
Skin protection
- Hand protection
Wear suitable gloves. Chemical protection gloves are suitable, which are tested according to EN 374. Check leak-tight-
ness/impermeability prior to use. In the case of wanting to use the gloves again, clean them before taking off and air
them well. For special purposes, it is recommended to check the resistance to chemicals of the protective gloves men-
tioned above together with the supplier of these gloves.
Respiratory protection
In case of inadequate ventilation wear respiratory protection.
Odor characteristic
Explosive limits
Partition coefficient
Auto-ignition temperature
10.1 Reactivity
Concerning incompatibility: see below "Conditions to avoid" and "Incompatible materials".
Classification procedure
The method for classification of the mixture is based on ingredients of the mixture (additivity formula).
Skin corrosion/irritation
Causes skin irritation.
Carcinogenicity
Shall not be classified as carcinogenic.
Reproductive toxicity
Shall not be classified as a reproductive toxicant.
Aspiration hazard
Shall not be classified as presenting an aspiration hazard.
12.1 Toxicity
Harmful to aquatic life with long lasting effects.
Remarks
Please consider the relevant national or regional provisions. Waste shall be separated into the categories that can be
handled separately by the local or national waste management facilities.
Transport of dangerous goods by road or rail (49 CFR US DOT) - Additional information
Not subject to transport regulations.
15.1 Safety, health and environmental regulations specific for the product in question
National regulations (United States)
Toxic Substance Control Act (TSCA) not all ingredients are listed (ACTIVE)
Right to Know Hazardous Substance List
- Cleaning Product Right to Know Act Substance List (CA-RTK)
Legend
E Environmental hazard
California Environmental Protection Agency (Cal/EPA): Proposition 65 - Safe Drinking Water and
Toxic Enforcement Act of 1987
Chronic * chronic (long-term) health effects may result from repeated overexposure
Physical hazard 0 material that is normally stable, even under fire conditions, and will not react with wa-
ter, polymerize, decompose, condense, or self-react. Non-explosive
Personal protection -
NFPA® 704
National Fire Protection Association: Standard System for the Identification of the Hazards of Materials for Emergency Re-
sponse (United States).
Health 2 material that, under emergency conditions, can cause temporary incapacitation or re-
sidual injury
Special hazard
National inventories
Legend
AIIC Australian Inventory of Industrial Chemicals
CICR Chemical Inventory and Control Regulation
CSCL-ENCS List of Existing and New Chemical Substances (CSCL-ENCS)
DSL Domestic Substances List (DSL)
ECSI EC Substance Inventory (EINECS, ELINCS, NLP)
Legend
IECSC Inventory of Existing Chemical Substances Produced or Imported in China
INSQ National Inventory of Chemical Substances
ISHA-ENCS Inventory of Existing and New Chemical Substances (ISHA-ENCS)
KECI Korea Existing Chemicals Inventory
NCI National Chemical Inventory
NDSL Non-domestic Substances List (NDSL)
NZIoC New Zealand Inventory of Chemicals
PICCS Philippine Inventory of Chemicals and Chemical Substances (PICCS)
REACH Reg. REACH registered substances
TCSI Taiwan Chemical Substance Inventory
TSCA Toxic Substance Control Act
2.2 - Hazardous ingredients for labelling: - Hazardous ingredients for labelling: yes
Sulfonic acids, C14-16-alkane hydroxy and C14-16- Cocamidopropyl betaine, Methylchloroiso-
alkene, sodium salts, Methylchloroiso- thiazolinone
thiazolinone, Glycerol
11.1 Serious eye damage/eye irritation: Serious eye damage/eye irritation: yes
Causes serious eye damage. Causes serious eye irritation.
12.5 Results of PBT and vPvB assessment: Results of PBT and vPvB assessment: yes
Data are not available. According to the results of its assessment, this
substance is not a PBT or a vPvB. Does not con-
tain a PBT-/vPvB-substance in a concentration of
≥ 0.1%.
29 CFR 29 CFR 1910.1000, Tables Z-1, Z-2, Z-3 - Occupational Safety and Health Standards: Toxic and Hazardous Sub-
1910.1000 stances (permissible exposure limits)
CAS Chemical Abstracts Service (service that maintains the most comprehensive list of chemical substances)
EC50 Effective Concentration 50 %. The EC50 corresponds to the concentration of a tested substance causing 50 %
changes in response (e.g. on growth) during a specified time interval
ErC50 ≡ EC50: in this method, that concentration of test substance which results in a 50 % reduction in either
growth (EbC50) or growth rate (ErC50) relative to the control
GHS "Globally Harmonized System of Classification and Labelling of Chemicals" developed by the United Nations
IATA/DGR Dangerous Goods Regulations (DGR) for the air transport (IATA)
LC50 Lethal Concentration 50%: the LC50 corresponds to the concentration of a tested substance causing 50 %
lethality during a specified time interval
NIOSH REL National Institute for Occupational Safety and Health (NIOSH): Recommended Exposure Limits (RELs)
NPCA-HMIS® III National Paint and Coatings Association: Hazardous Materials Identification System - HMIS® III, Third Edition
RTECS Registry of Toxic Effects of Chemical Substances (database of NIOSH with toxicological information)
Classification procedure
Physical and chemical properties: The classification is based on tested mixture.
Health hazards, Environmental hazards: The method for classification of the mixture is based on ingredients of the mix-
ture (additivity formula).
List of relevant phrases (code and full text as stated in section 2 and 3)
Code Text
Disclaimer
This information is based upon the present state of our knowledge. This SDS has been compiled and is solely intended for
this product.