Professional Documents
Culture Documents
Impol Katalog Rolled-Products
Impol Katalog Rolled-Products
Rolled products with their wide range of use represent the largest segment of aluminium
products. We can find their presence in automotive, transport, building and construction, con-
sumer and many other sectors.
Modern technology, appropriate technical equipment together with the knowledge of our
employees ensure results that can satisfy the most demanding customer requirements.
The basic manufacturing procedures are hot and cold rolling of aluminium and its alloys,
where hot rolled or cast strips serve as input material for cold rolling. In addition to standard
tempers and mechanical properties, entirely specific tempers, properties and quality of rolled
products can be achieved through controlled cold working and heat-treatments. The finally
rolled coils are slit into various widths with modern rotating shears. Sheet is obtained by cut-
ting strips to lengths on cutting lines with built-in roller straightener.
2 3
PRO D U C T I O N P R O C E S S 1 Alu m iniu m plates IMPOL SEVAL
Available dimensions:
intermediate
annealing
sawing
4 5
3 A lu mi n i um c o l d r o l l e d c oils I M P OL SE VA L
6 7
3 A lu mi n i um c o l d r o l l e d c oils I M P OL F T 4 Alu m iniu m tr ead sheets
Coil sizes:
8 9
5 A lu mi n i um c i r c l e s I M P OL F T STAND ARD S AND CHEMICAL COMPOSITION
Alloys, temper and surface: Our aluminium products are produced in different alloys according to international standards.
The chemical composition, mechanical properties and tolerances are in compliance to EN
Alloy (EN AW-xxxx) 1050, 1200, 5454, 5754, 6082, 4006, 8006 standards for various products:
O– soft, H18 – hard
Temper
DDQ is available on request
• EN 573–3, chemical composition, all aluminium products
Surface finish Mill finish • EN 602 chemical composition, aluminium for food contact,
• EN 485–2, mechanical properties, sheets, strips and plates
• EN 683–2, mechanical properties, finstock
Available dimensions:
• EN 485–4, tolerances, sheets, strips and plates
Thickness (mm) 1,00 – 4,00 • EN 683–3, tolerances, finstock
• EN 851, circles and circle stock, specifications
See table
Diameter (mm) • EN 1386, tread plate specifications
Shapes are available on request
Available diameters:
10 11
PA C K ING ORD ERING
Our products are packed according to the customer’s wishes and our capabilities. Impol’s For a quicker response to your inquiry we kindly ask you to provide us the following data:
standard packing methods include packing onto pallets, both axis horizontal or vertical for
strips. Special packing is also available on agreement. All packing is returnable. • Product type
Each shipment is accompanied with a certificate of quality, which also proves suitability of • Alloy and temper
materials. • Dimensions and desired tolerances
• For coils, coil size (desired weight) and/or inside and outside diameter
• Purpose of use or desired mechanical properties
Main packing types used for rolled products:
• Quantity
12 13
Edition September 2010