You are on page 1of 13

GORESH SAINI-

1999005 CLAY
PREPRATION
WORSHOP-
BACH[208]
CLAY FROM SOAP

 To create this kind of clay we need


foam based soap.
 Grate the soap on a fine grater.
 Now in pan take one cup of grated soap
 Mix half cup of water to it.
 And let it stoke for 5mins.
 Now keep it on low flame and let it
melt.
 Now add 1/3 cup of fevicol to it and
mix it .
 And let it reach the boiling point.
 Now turn off the heat and add half cup
of corn starch to it
 Mix it with hot mix of fevicol and soap.
 Now take the mixture in bowl
 Now apply some oil in your hands and
start needing
 Add corn starch in accordance to get
dough like constituency
 It becomes harder as it colds
 Add more glue or corn starch if need.
 Add it air back container and store it at
room temperature it is ready now.
CLAY FROM DRIED
CLAY RESIDUES

Allow the clay to dry out completely, then


break it down into small pieces and place
it in a plastic container – washing up
bowls are a good choice because they
contain a manageable amount. Cover the
clay with warm water and allow it to
break down overnight – this process is
called slaking down. The water should
completely cover the clay.
Siphon off the excess water covering the
clay. The easiest way to do this is to use a
slip trailer, but any soft squeezy bottle
would work if you don’t have a trailer.
Empty the excess water into a separate
container close to the clay, to minimize
spillage.
Give the slurry a little mix then transfer to
an absorbent surface, such as a plaster
batt, to form a layer about 5cm thick. Use
your hand or a wooden spoon for this –
either way it can be a little messy.
The clay will dry out quite quickly so check
it from time to time. When it has dried to a
stage where it can be lifted easily from the
batt, turn the clay over so that the wetter
surface comes into contact with the plaster,
to even up the firming process.
When the clay has firmed up to a workable
consistency roll it up as shown, so that any
remaining excess moisture is contained –
this will be distributed when the clay is
wedged.
Still working on the plaster batt – work
the clay into a large brick shape – this is
by far the easiest shape to manage when
wedging.
SOAP CLAY

Soap clay is an air dry clay, used to make beautiful handcrafted


flowers and dolls. We have white and green color pigment clay. It
is completely non-toxic, and thus it is appropriate for all age
groups.

USES
CLAY FORMED FROM RESDUES

This clay is used for making pottery, both utilitarian and


decorative, and construction products, such as bricks, wall and
floor tiles.

You might also like