Professional Documents
Culture Documents
Frame Introduction
Bottom board
Left lengthening beam
Guard-engine
Outer longitudinal pull rod
Left front support Cab lower guard board
1.2 Base Frame
Seven components.
Important parts.
Steel castings (red color) used in high stress areas.
Torque tubes
Rear longitudinal beam
Hoist seat
Closed-loop
crossmember
Part2 Frame Features
Longitudinal pull rod increases the stiffness of Body limit on the front of the frame, improves
front part of the frame, enhances vehicle the vehicle harshness and the frame stress.
stability.
Tie rod units installation Longitudinal pull rod installation Lengthening beam installation
Driveline guard
installation
Washer Washer
Animation
Part4 Cautions
1 、 Inspection
Inspect the frame and attached parts at intervals not exceeding 250
hours for cracked or broken welds and bending/twisting of the frame. Any defects found
should be repaired before they progress into major failures.
2 、 Painting
A check of the condition of the paint should be made approximately twice a year and
chassis repainted if necessary.
3 、 Welding
In principle, it is not allowed to weld anything to frame casually. Particularly, it is
prohibited to weld anything on the upper and lower flanges of the front and rear
longitudinal beams and it is strictly forbidden to splash any weld slag on them.
Back