Professional Documents
Culture Documents
GCV526
Presented by :
Houssein Swaydan
Rana Sayed Ahmad
Georges Nassar
Ilia Kozah
P r e s e n t e d to : D r. A n t o n i o R i z k a l l a h
Introduction
Preliminary design
Project Architecture
overview Materials
Loads
Design of structural elements
MEP
BOQ
My Chart Title
Ajaloun 681 is a residential building of a
property number 681, located in Ajaltoun,
Lebanon.
Architecture
Materials
Concrete: Steel:
In order to calculate the loads, we had to obtain the slab thickness.
We have one-way ribbed slab, According to ACI table 9.3.1.1, we had for the longest one-end continuous slab span
For our design we took and we will check it later.
Dead load:
Slab:
Beam:
Live load:
Loads Residential:
Balcony:
Stairs:
Ribs design:
Section 1-1.
Beams design:
Beam B1:
columns :
We divide the area of the entire floor into tributary areas for each
column , we add each column’s load downwards from the roof to
the basement.
Stifness of columns.
Columns design:
Footing design::
An isolated footing is one of
the most regularly used forms
of foundation when single-
columns are located at a
considerable distance. We
developed an isolated footing
in our project to avoid
exceeding its bearing capacity,
ensure safety from overturn or
sliding, and prevent the earth
from settling. For a chosen
footing of L=140 cm and B=125
cm. after calculations a
thickness of 50 cm will be
provided.
Footing design.
Stairs design:
The type of stairs that we will
design is a double flight stair with
a landing 62 cm wide.
Rise =15 cm, run=30 cm ℎ =
25𝑐𝑚.
Stais design.
Tie beams:
Water supply:
Cuisine.
toilet,.
Bathroom.
Mechanical::
drainage:
Bathroom. Cuisine.
Electrical and power supply:
Concrete volume:
Steel weight :
Steel percentage.
BOQ SUMMARY:
Conclusion:
To summarize, civil engineering is a smart and serious field that is continually evolving, mistakes can be fatal.
As a result, every engineer must be competent and cautious in order to strike a balance between the economic and
safety aspects in order to get the greatest possible design.
We finished this course carrying big amount of information.
• The size of lines is important.
• Cold water to the right, hot water to the left.
• The size of each cartouche must be as a printing paper.
• Edge beams carry less loads than internal beams.
• Make a block foe axis is very helpful.
And more and more is learnt from Dr. Antonio. Dearest Dr. you treated us as engineers and supplied us with what
takes to be in the business domain. We promise your efforts will never be vanished
Thank you!