Professional Documents
Culture Documents
Then Click OK
4./ Start Cutting
Click “OK”
Congratulation !!
Import Note:
1./ You must check and adjust the wire vertical when you
a.) You just change the Z axis ( raised or lower the Up frame)
b.) You put a new metal block for cutting
c.) Wire Broken during Taper Cutting
d.) It’s first time taper cutting after you install the machine
2./ You must cut a cone for test and use Taper Calc to correct H1 & H2 when you:
a.) It’s first time taper cutting after you install the machine
b.) You just change the Z axis ( raised or lower the Up frame)
c.) You fix the work piece in a different height
3./ When the Taper <= +/-3 degree , the precision is <=0.04mm
When the Taper <= +/- 30 degree, the precision is <=0.1mm
Tip2,
Abnormal Stop during Taper
Cutting, Click “Go to Origin”
can make wire back to
Vertical status.
Thank you take time reading!!