Professional Documents
Culture Documents
BTS Configuration Modules Nokia
BTS Configuration Modules Nokia
NOKIA
NOKIA
1940 (76.4)
770 (30.3)
750 (29.5)
600 (23.6)
620 (24.4)
600 (23.6)
620 (24.4)
Outdoor
Indoor
Midi
No heat exchanger or air-conditioner required Heater unit For cold start (< -10C) Optional for UltraSite GSM Outdoor BTS
4 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
1 1
6 6 6
1 1
11 7
11
1
1 1
9 1 1 1 1 1 2 2
10
2 1 1 1 1 1 1 7 7
7
99440361
1 2 1 1 2 1 1 2 1 8 8 8 8 8 10 11 9 9 KEY: 1 2 3 4 5 6 7 8 9 10 11 Transceiver RF Unit 2-way Receiver Multicoupler Unit Transceiver Baseband Unit Base Operation and Interface Unit Transmission Unit Dual Duplex Unit DC/DC Power Supply Unit Rectifier Battery Unit for IBBU Distribution Unit for IBBU Cabinet Control Unit 6 6 6
brief power shortages reduced site space fast roll-out up to 18 TRXs in 2 BTS cabinets
IBBU parts
Rectifiers (1-5) Battery string (0-1) Control Unit (1) AC/DC unit (1)
NOKIA
GSM/EDGE/WCDMA CABINET
Power Supply Unit Transmission Units WCDMA Transceivers System Clock Unit Application Manager Unit Signal Processor Units Summing and MUX Unit Fan
9 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
POSSIBLE COMBINATION
6 GSM/EDGE TRXs Up to 6 GSM/EDGE TRXs
3 WCDMA Carriers
IBBU
11
NOKIA
SECTORS
Configuration Combiner By-pass WBC 2:1 WBC 4:1 RTC Max # of sectors / cabinet 6 3 1 2 BTS with WCDMA or IBBU 3 1 1 1
dBm
Combiner by-pass WBC 2:1 WBC 4:1 RTC 44.5 41.0 37.5 42.0
W
28.2 12.6 5.6 15.8
13
NOKIA
Support 2-way diversity 4-way diversity (available later) Above parameters are with sub-band receiver filters NOTE! Full-band and sub-band filters are available in GSM 1800
14 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
CONFIGURATIONS
By-pass Combining 2-way
15
NOKIA
COMBINING BY-PASS
TRX RF Units Receive Multicoupler Dual Duplex Unit Antennas
Duplexer
TX RX
main div
LNA
Duplexer
TX RX
main div
Splitter Splitter
LNA
Example: 2 TRX/Cell
16 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
17
NOKIA
TX RX
TX RX TX RX
LNA
Duplexer
WBC
main div LNA Splitter
main div
Splitter
Example: 4 TRX/Cell
18
NOKIA
19
NOKIA
TRX RF Units
TX RX TX RX TX RX TX RX TX RX TX RX TX RX TX RX
20 NOKIA
main div main div main div main div main div main div main div main div
CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
WBC
Splitter Splitter Splitter Splitter Splitter Splitter LNA LNA
Antennas
DuplexerDuplexer
Example: 8 TRX/Cell
21
NOKIA
6
Duplexer
Cavities
main TX RX
main div
LNA's
div
Splitter Splitter
Example: 6 TRX/Cell
22 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
23
NOKIA
TSxx
Uplink/downlink bus
12C_A
DVxx
24
NOKIA
M O N ITO R IN TERFAC E RE SE T
LMP
13 MHz
00129021
25
NOKIA
26
NOKIA
99584316
27
NOKIA
D-bus signals Uplink and Downlink signals Section B D-bus Interface Section B Control Block Section B DSP Block
99627445
28
NOKIA
99614746
29
NOKIA
Interface Board
TX Filter ANT 2
TX Input 2
30
NOKIA
MULTICOUPLER
M2xA
M6xA
99586474
31
NOKIA
RX 1 RX IN RX 2
RX IN RX 4 RX 5
RX 6
99586486
99591881
32
NOKIA
R (FLT) Y (S TA ND B Y ) G (OP R)
99584258
33
NOKIA
R (FLT) Y (S TA ND B Y ) G (OP R)
99584285
34
NOKIA
00217117
35 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
Main LNA
PWR IN
Controller module
Filter module
Selector module
Combiner module
Duplexer
Ant
00120512
36 NOKIA CTXX 5563/2.0en.PPT/ 28.5.2001/ Remo Grosso
37
NOKIA
TX2 IN
fo 6 M
Output
TX6 IN
fo 6 M
38
NOKIA
TX
RX RXExt
Operating voltages from controller module Gain controlling from controller module LNA Minor and Major Alarms to controller module Diversity RX Filter
RX Filter High/Low Logic
Internal AlarmLogic
Diversity LNA
DAnt Operating voltages from controller module Gain controlling from controller module LNA Minor and Major Alarms to controller module
High/Low Logic
DRX
Internal AlarmLogic
00120548
39
NOKIA
RIFP
Data
Address
MUCA
2MHz 6.5MHz +26V +9V -9V +5V +3.3V AGND DGND Power control Motor driver block
to Combiner Module
00120551
40
NOKIA
TRANSCEIVER RF UNIT
41
NOKIA
WIDEBAND COMBINER
99614773
42
NOKIA
Wideband Combiner
Air flow
Duplexer unit
99625895
75
120/100
99591936
44
NOKIA
99591909
45
NOKIA
RX/TX line 1
RX/TX line 2
RX/TX line 3
RX/TX line 4
99591924
46
NOKIA
99591912
47
NOKIA
99614797
48
NOKIA
49
NOKIA
DTRU
BB2
Red
Yellow
Blnking Green
TSx
Red
Yellow
50
NOKIA
Red
Blinking Green
Blinking Yellow
DVx
PWS
BATA
CCUA
51
NOKIA