OPERATORS NAME: OVERALL REMARKS: 1. Satisfact!". #. F$!t%&! t!ai'i'( !&)$i!&* '+". ,. F$!t%&! t!ai'i'(- !&-&.a/i'ati' 0 R&c&!tificati' 1. R&23& c&!tificat&. ID: Dat& f Ass&ss/&'t: Lcati': FIELD ASSESSMENT POINTS 4&s 5'. R&/a!3s 1. Whether the technician is having the proper procedure with him for performing the job? 2. Does he have understanding of the applicability of the procedure & acceptance standards? 3. Does he carry a copy of valid evel !! certificate with him? ". #re all the steps ade$uately followed during the e%amination as instructed in the procedure? &. Does he carry the e$uipment calibration certificate copy' batch certificates with him? (. Does he chec) the surface preparation prior to start of the test? *. Does he have ade$uate )nowledge about the test variables? +. Does he receive the actual weld' job configuration prior to start of job from client? ,. -as he chec)ed the instrument for linearity prior to start of test? -ow often he chec)s the instrument linearity during the e%amination period? 1.. -as he chec)ed the probes' cables for any damage or variation in probe angle' inde% point'internal reflections'noise etc.? 11. -as he prepared proper scan plan or carry instruction sheet how to do the scanning to ensure complete coverage? 12. /an he be able to discriminate between relevant and non0 relevant indications? 13. /an he answer all relevant $uestions as)ed by #!'12#? 1". 3ood house)eeping is maintained? 1&. !s he aware of the ethics' 4uality policy of !5627/? 1(. Does he follow all the safety rules e%isting at the wor) site? 1*. #re the individual8s interpretation'evaluation s)ills ade$uate? 1+. !s he preparing reports in compliance with the approved procedures? G&'&!a+ C//&'ts 6if a'"7: Ass&ss/&'t 8": Na/&: L&2&+: D&si('ati':