The document provides technical delivery conditions for carbon steel forged flanges to be used for HIC (Hydrogen-Induced Cracking). It specifies that the material must be SA105 carbon steel with a maximum carbon content of 0.23% and meet chemical, tensile test, heat treatment, dimensional, and visual requirements. HIC testing is not required for the carbon steel forged flanges. Original inspection reports and material test certificates reviewed by the specified inspection agency are required documentation.
The document provides technical delivery conditions for carbon steel forged flanges to be used for HIC (Hydrogen-Induced Cracking). It specifies that the material must be SA105 carbon steel with a maximum carbon content of 0.23% and meet chemical, tensile test, heat treatment, dimensional, and visual requirements. HIC testing is not required for the carbon steel forged flanges. Original inspection reports and material test certificates reviewed by the specified inspection agency are required documentation.
The document provides technical delivery conditions for carbon steel forged flanges to be used for HIC (Hydrogen-Induced Cracking). It specifies that the material must be SA105 carbon steel with a maximum carbon content of 0.23% and meet chemical, tensile test, heat treatment, dimensional, and visual requirements. HIC testing is not required for the carbon steel forged flanges. Original inspection reports and material test certificates reviewed by the specified inspection agency are required documentation.
TECHNICAL DELIVERY CONDITION FOR CARBON STEEL FORGED
FLANGES FOR HIC
1) Material Specification: SA105 (Latest Edition )/API 650 11th edition
Add.3Aug,2011. 2) Size: As per MTO. 3) Product Requirement: a)
a) Chemical Analysis: i.Chemical Analysis: C=0.23%Max.
CE<0.43, Max. S content0.01%&Max P content0.01%. ii.Total unspecified element shall be less than 0.5%. iii.The micro alloying element B,Ti,Nb(Cb),V and Ti and0.0005% for B. iv.Hardness of carbon steel shall be as per NACE MR103.
b) Tensile Test(sample: size/heat/lot)
c) Heat Treatment :Normalized.
4) Visual ,Dimensional & any other Requirement: As per ANSI B 16.5(upto 24) and above as per ANSI B16.47 series B.(RF Finish shall be 125 AARH)
5) General requirement: as per SA788
6) HIC TEST: HIC test is not required.
7) Inspection Agency:IOTECS
8) MTC(Material test certificate as per EN10204/3.1) required: YES
9) Documents Required: Original IRN and MTC duly reviewed by IOTECS.