Professional Documents
Culture Documents
PARALLEL CIRCUIT
CONNECTION
Submitted to:
Engr. Melvin Tubal
Prepared by:
ABIS, SOPHIA
ABALES, DEXTER
BLANCO, JOSHUA
GRACILLA, CLARISSE
LAGARE, LYZA ANDREA
OGNES, ANGELI
NAGUTOM, CYRALYN
SALUD, KATE
VILLAOS, KIMBERLY
BSEE-2
INTRODUCTION:
This report aims to know how the students can create a parallel
circuit connection and how students can perform different
operation on how they resolve problems regarding on measuring
resistance, current and voltage.
EXPERIMENTAL SETUP:
MATERIALS:
Analog and Digital Multi tester
Long nose
Plier
Cutter
9 V Battery
Plywood
Alligator clip
Stranded wire (16mm)
EXPERIMENTALPROCEDURE:
1. Cut the wire into 4-6 parts.
2. Remove half a cm of insulation from both sides of the wires.
3. Attach a wire in an alligator clip then to the positive side of the dry cell and wound
the other end to the left side of a socket with light bulb.
4. Attach another wire again with an alligator clip then to the negative side of the dry
cell.
5. Get another wire and connect to the right side of the light bulb.
6. Add one more bulb to the setup by wounding another wire to the left side of the
first light bulb and connecting the other end to the left side of the second light
bulb.
7. Wound another wire to the right side of the first light bulb and connect it to the
right side of the second light bulb.
voltage, current, etc is that it is not always exact. The multi tester may also
have defects that may affect the actual measurements.