Professional Documents
Culture Documents
Nutshell EIGRP Commands
Nutshell EIGRP Commands
Enabling EIGRP Routing Router(config)# router Router(config-router)# eigrp network AS number (Must be the same on all routers) network-address [wildcard mask]
eigrp
as-number
network-address
mask
Router(config-if)#
auto-summary on by default. EIGRP summarizes automatically between classful boundaries. Must be used for VLSM.
Router(config-if)#bandwidth kilobits Configures the bandwidth used by routing metrics on the outgoing interface. Router(config-if)#ip bandwidth-percent eigrp as-number bandwidth-percentage By default, EIGRP is set to use only up to 50% of the bandwidth of an interface to exchange routing information. Router(config-router)#eigrp log-neighbor-changes This command enables the logging of neighbor adjacency changes to monitor the stability of the routing system and to help detect problems. RTA(config-router)# variance number
The variance command instructs the router to include routes with a metric less than or equal to n times the minimum metric route for that destination, where n is the number specified by the variance command.
Miscellaneous Router(config-router)#
default-metric
56
100
255
10
1500
{k values)
Show commands Router# show ip eigrp neighbors {displays neighbors} Router# show ip eigrp topology Router# show ip eigrp topology all links
displays topology, active/passive (well) state, successors Router# debug eigrp fsm Router# debug eigrp packet
Router# Router# show ip route eigrp show ip protocols {EIGRP routes in routing table}
AS number, filtering, redistribution, neighbors, distance Router# show ip eigrp traffic EIGRP packets sent and received
Redistribution Example 1: EIGRP and IGRP redistributes automatically as long as the same processid is used.
Router(config)#
router
eigrp
44
and Router(config)#
router
igrp
44