Professional Documents
Culture Documents
CB
PRODUCT SPECIFICATIONS:
Input Voltage: 47~63Hz, 90 - 264Vac full range
Input Current: 4A at 100VAC
Inrush Current: 70A peak maximum (Measuring at 230VAC and
full load cold start.);35A peak maximum (Measuring at 110VAC
and full load cold start.)
Harmonic PFC: Power Factor Correction pass EN61000-3-2
class D
Fan Drive: 12VDC/400mA is available to drive an external fan
Transient Response: Output voltage return to within 1% in less
than 500us for a 50% dynamic load peak does not excess 5%
Overshoot: Turn-on and turn-off overshoot should not exceed 5%
over nominal voltage
Efficiency: Minimum 80% on 12-48V models, 70% on 3.3 and 5V
models at 230Vac full load
Turn On Delay: 1 second maximum at 120 VDC
Hold Up Time: 20 Msec minimum at 120 VAC and 80% of rated
maximum load
Adjustability: Output user adjustable +/-5% minimum
Input Circuit Protection: A protected 250V/5A fuse inserted. The
fuse shall be blown only by an internal fault of the power supply,
but no create a fire or shock hazard
Over Current Protection: Current limits at 110-135% of the rated
output current and recovers automatically
Short Circuit Protection: Short circuit can be continuous without
damage and recovers automatically
Over Voltage Protection: Output is protected against over
voltage. Unit latching down will occur when output exceed 130%,
and recycle AC input to reset
Over-Temperature Protection: Power supply protected in the
event of excessive operating ambient 85 degree, and automatic
recovery
Operating Temperature: 0 to 50 degrees C
Storage Temperature: -20 to 85 degrees C
Operating Humidity: 5% to 90% RH, Non-condensing
Storage Humidity: 5% to 95% RH, Non-condensing
MicroPower Direct
www.micropowerdirect.com
232 Tosca Drive Stoughton, MA 02072
E-Mail: sales@micropowerdirect.com
MicroPower Direct
Go Direct - MicroPower Direct - For Product, Performance and Price
Output Range
Regulation
PRL9802SA
3-4V
30A
+/- 1%
50mV
PRL9802SB
5-6V
40A
+/- 1%
50mV
PRL9802SC
12-18V
16.7A
+/- 1%
+/- 1%
PRL9802SD
24-30V
8.34A
+/- 1%
+/- 1%
PRL9802SE
36-56V
5.55A
+/- 1%
+/- 1%
* Providing peak power to 600W within 500uS for all models, longer duty duration need contact manufacture.
* All output range are covered in agencies certification and the preset voltage will be set as standard models if any request is
not standard output then should contact us in advance.
* Maximum 200W continuous output, with minimum 17 cfm forced ventilation.
* Maximum 150W continuous output with air convection, except PRL9802SA and PRL9802SB which power is limited to 22A
* Output is fully isolated.
* Ripple and noise measured from 10KHZ to 20MHz at output terminals with parallel 0.1F ceramic and 22F electrolytic capacitors.
OUTLINE DRAWING: Overall Size: 6.8(L) x 3.8(W) x 1.5(H)inches; Weight: Maximum weight is 650g
H O U S I N G P I T C H 2 .5 m m
( J S - 2 0 0 1 - 0 6 O R E Q U .)
INPUT
Line
Neutral
GND
VO-
VO-
VO+
VO+
OUTPUT
F A N H O U S IN G
P I T C H 2 .5 m m
( J S - 2 0 0 1 - 0 2 O R E Q U .)
A : M O U N T IN G H O L E
S C A L E 4 :1 ( 8 X ) B R E S S
T E R M IN A L B L O C K
( P a r t N o . H D - 3 0 1 -4 P )
M 4 S C R E W 4 P IN S , 1 1 m m C E N T E R
T E R M IN A L B L O C K
M 3 S C R E W 3 P IN S
7 .6 2 m m C E N T E R
( P a rt N o . F T B -7 0 2 - 3 P )
M O L E X P A R T N O . 0 9 - 9 1 - 1 2 0 0 (1 2 P IN S )
M O L E X P A R T N O . 0 9 - 9 1 - 0 5 0 0 (5 P IN S )
P I N N O .2 ,4 N C
Notes:
AC Input Connector: Mating Molex Part No. 09-91-0500 or equivalent (5 pin,3 used) PCB is Labeled: L = Line; N = Neutral; G =
Chassis Ground Mating Pins; Molex Engineering Series 2478, 2578, 8818 or Howder Terminal block Part No. FTB-702-3P (3 pin)
Output Connector: Mating Molex Part No. 09-91-1200 (12 pin)
Howder
Molex
or Howder Terminal block Part No. HD-301-4P (4 pin)
Output Pin Assignment: (See table in right)
VO+ : Pins 1-2
VO+ : Pins 1-6
Logic signal connectors (CN3):
Mating JST XHP-6 or equivalent (CHYAO SHIUNN JS-2001-06)
VO- : Pins 3-4
VO- : Pins 7-12
Mating Pins: JST SXH-002T-P0.6 FOR AWG 30 TO 26
Fan Drive: Mating JST Part No. XHP-2 or equivalent (CHYAO SHIUNN JS-2001-02)
Mounting Inserts: 8 Places M4. Maximum Penetration 4mm see outline drawing for location.
MicroPower Direct
www.micropowerdirect.com
232 Tosca Drive Stoughton, MA 02072
E-Mail: sales@micropowerdirect.com