Professional Documents
Culture Documents
EP82 Starlet Wiring and Connectors PDF
EP82 Starlet Wiring and Connectors PDF
This document details a large amount of wiring information which I could ascertain from the two main wiring looms (Cabin & Engine Bay) that was provided with a 1991 (Gen 1) EP82 Toyota Starlet
GT (4E-FTE) front cut, however much of the wiring layout and information will be appropriate to later Toyota Starlet models (with eg slightly different connectors or wiring colours).
Please note that there are no specific details of wiring connections and connectors in the doors, nor rear wiring loom of the car - due to those parts of the car not included with the front cut.
The front cut was a Manual Transmission 4E-FTE which was not fitted with TEMS or ABS, so no specific details of those components could be provided.
To advise of any corrections, please contact me on the above email address.
Table of Contents
Page
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
Contents
Wiring Loom Layout (To Scale)
Connector ID Quick Reference Table
Connectors 1-15 (Cabin Loom)
Connectors 16-30 (Cabin Loom)
Connectors 31-42 (Cabin Loom)
Connectors 43-57 (Engine Bay Loom)
Connectors 58-72 (Engine Bay Loom)
Connectors 73-90 (Engine Bay Loom)
Connectors 91-97 (Engine Bay Loom)
Connector Pinouts & Conduction Details
Relay, Fuse & Temperature Sensor IDs
Relay Connection & Pin Details
Instrument Cluster Connections & PCB Tracks
Instrument Cluster Wiring Diagram
ECU Pinout Details
ECU Wiring Diagram
Power & Switch Wiring Diagram
A/C Condenser & Radiator Fan Relay Configurations
Page 1 of 19
90
87
88
96
97
89
Passengers Side
72
66
71
65
83
69
92
70
68
84
Fuse &
Relay
Box
54
58
85
Batt
53
Diag.
73
74
77
75
59
78
63
55
Drivers Side
67
A/C
Relays
94
93
91
86
57
82
80
79
76
95
81
60
61
56
62
51
Engine Bay Loom
50
52
64
49
ECU
43
44
48
46 47
2
Additional 5
Connectors
in base of
fuse box
39
36
35
33
40
Cabin Loom
37
45
41 42
3
To LHS
Door
Fuse
Box
38
29
34
G
32
26
31
19
9
24
20
6
10
5
1
Main Battery
Ground/Earth Mount
Rubber Firewall Grommet
22
14
15
21
17
13
ECU
12
23
28 27
To RHS
Door
16
11
30
25
18
Page 2 of 19
Cabin Loom
Circuit Opening Relay
Fan/Blower
Fan/Heater Assembly
TEMS Computer / Module
LHD Speaker (Cabin)
Interior Light Door Switch (Left Door)
To Power Windows (Left Door)
To Power Mirrors (Left Door)
Roof / Dome / Interior Light
Heater & A/C Dash Controls (Fan, Vent Direction, Recirc/Fresh Air)
Air vent Direction Motor
ECU
Cigarette Lighter
Stereo Rear plug
Clock (Upper Dash)
Instrument Cluster (Blue Connector)
Instrument Cluster (White Connector)
Instrument Cluster (Boost Pressure Gauge & Lo/Hi Light)
Turn Signal / Indicator Flasher Module
Relay Light Reminder Module
Brake Pedal Switch
Door Control Module
RHS Speaker (Cabin)
Fog Light On/Off Switch
TEMS Switch
Relay (hardwired) Power Windows
To Power Windows (Right Door)
To Power Mirrors (Right Door)
Interior Light Door Switch (Right Door)
To Rear Wiring Loom
Power Window Control Buttons
Hazard Light Button
Lo/Hi Boost Button
Rear Window Demister Button
Power Mirrors Adjustment Buttons
Ignition Barrel
Steering column combination switch (Rear Wiper)
Steering column combination switch (Front Wipers)
Steering column combination switch (Lights & Indicators)
Foot/Lower Air Direction Motor
To Engine Bay Loom (Connector 46)
To Engine Bay Loom (Connector 47)
#
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
#
85
86
87
88
89
90
91
92
93
94
95
96
97
Connectors are referenced in the following pages with a C- prefix eg C-12 for Connector 12
Page 3 of 19
3. Fan/Heater Assembly
2. Fan / Blower
1
5
1
3
1. Blue-Red
2. Blue-Yellow
3. Blue-Black
4. White-Red
All wires from C-10 (Dash Buttons)
To C-14
Pink & Dark Pink
1. Red
2. Green
3. Blue-Yellow
4. Blue-Red 5. Blue-Green
(all thicker gauge wire to C-22)
1. Light Green
4. Green-Black
1,2,3 to C-35
4,5, to C-31
12. ECU
2. Pink-Black
5. Red-Black
3. Pink-White
1. Blue-Green
2. White-Black
3. To C-6 (Blue-Yellow)
4. From Dome Fuse (Red-White)
1 & 2 not connected (for sunroof?)
14. Stereo Rear Plug
4
3
GND (White-Black)
12V Acc (Grey) From Radio Fuse
Page 4 of 19
2
1
2
4
1
For Connections, See Page 15
3
3
1. GND (White-Black)
2. F C-32 (Light Green)
3. TB C-32 & C-39 (Green-Blue)
Pedal
Switch
N/O
(Normally
Open)
2
1
To C-14
Light Green & Blue
1-4
1
5-9
4
10-13
3-6
3
5-9
30Amp Fuse :
1. Ignition AM1 (White)
2. To C-22 (Blue Thicker gauge)
Relay Coil :
3. From C-22 (Blue-Green)
4. GND (White-Black)
Relay Contact Wires :
5. From C-22 (Blue Thick gauge)
6. From C-27 (Blue-Green Thick gauge)
1. Light Green-Black
2. Blue-Black
3. Light Green-Red
4. Light Green-Black
5. Light Green
1,2 to C-31
3,4,5 to C-35
14-19
5
Light Reminder Module & Dome Light via Diode
To C-20
(Red-Green)
1. Red-Blue
2. Green-Black
3. Green-Yellow
4. Green-Yellow
5. Red-Yellow
6. Yellow-Red
7. Black
8. Green
9. Green-Red 2 Dot 10. Blue-White
11. Green-White
12. Red-Black
13. Blue-Red
14. Yellow-Black
15. Yellow-Blue
16. Blue
17. Blue-Black
18. Blue-Yellow
19. Green-red 1 Dot
For Connections, See Page 11
Page 5 of 19
2
2
1
1
5-10
3-8
1. Red-Black
3. Blue
5. Green-Black
7. Dark Pink
9. Blue-Yellow
2. Light Green
4. Light Green-Black
6. Pink
8. From Radio Fuse (Grey)
10. Blue-Black
1
1. Park lights lighting signal (Green)
2. GND (White-Black)
3. TL (Green-Black)
4. TR (Green-Yellow)
5. F (Light Green)
6. B2 From Haz/Horn Fuse (Green-White)
7. TB (Green-Blue)
8. B1 From Turn Signals Fuse (Red-Blue)
37. Steering column combination switch
(Rear Wiper)
1. GND (Brown)
2. ECU BC (Light Green-Red) & Dash boost
indicator via C-18
1. GND (White-Black)
2. From Rear Demister Fuse (Light Green)
3. To Demister via C-30 (Black)
3
1
6
3
4
3
1. I C-30 (Blue-Yellow)
2. E GND (White-Black)
3. +1 C-30 (Blue-Black)
4. W C-95 (Blue-White)
1. +1 C-49 (Blue-Black)
2. +2 C-49 (Blue-Orange)
3. EW GND (White-Black)
4. W C-95 Washer (White-Blue)
5. +B C-49 (Blue) From Wipers Fuse
6. +S C-49 (Blue-Yellow)
See Page 11 for Conductions
3-7
5-10
1. E GND (White-Black)
2. TL Turn Signals Left (Green)
3. TB Turn Signals 12V (Green-Blue) from
Turn Signals fuse
4. TR Turn Signals Right Green-Yellow (1 Dot)
5. HU Headlights High Beam (Red-Yellow)
6. RF ECU ELS (Red-Green)
7. HL Headlights Low Beam (Red-White)
8. TI To Park Lights (Green)
9. BO From Tail Lights Fuse (Green-White)
10. HO Horn (Green-Yellow 2 Dot) Horn
button shorts this pin to GND
See Page 11 for Conductions
Page 6 of 19
1 2 3
3
1. ECU AC2 2. ECU AC1 3. ECU ACT
Wires connect to
C-40
C-51
C-52
C-68
C-85
C-90
C-92
53. Diagnostics Port (hardwired no connector)
For Connections, See Page 11
To sensors
To Main loom
C-51 & C52
Green -------- 1 --- Green-Blue
Black ---------- 2 --- Black-Yellow
Grey ---------- 3 ----- Green-Red
55. Ignitor
1. GND (Black-Yellow)
2. To HVAC Module C-48 (Green-Blue)
1. GND (Black-Yellow)
2. To HVAC Module C-48 (Green-Red)
57. Unknown
2
1. ECU IGF (Grey-Black)
2. ECU IGT (Light Green-White)
3. IG2 Ignition (Black-Red)
4. Diagnostics Socket IG- (Black)
5. Pin 2 on Coil C-56 (Black-White)
Page 7 of 19
62. Alternator
3
3
2
1
2
1
1. ECU E2 (Brown)
2. ECU PIM (Green)
3. ECU VCC (Green-Red)
63. Unknown
64. ECU
Connector CON-1
Same wires as C-82
1. Green-Red
2. Green-Yellow
(To Rear of Car C-30)
68. Coolant Sensor (To HVAC module)
ECU OX (White)
72. Distributor
3
2
1. ECU NE (White-Blue)
2. ECU G1 (Orange-Blue)
3. ECU G2 (Blue-Green)
4. ECU G- (Blue-Yellow)
Page 8 of 19
73-76. Injectors
2
1
2
1
83. FL Indicator
84. FL Foglight
2
1
1. GND (White-Black)
2. TL (Green-Black)
1
2
1. GND (White-Black)
2. Lights Signal (Green)
1. GND (White-Black)
2. 12V from Cooling Fan or A/C Fan No.2
Relay (Blue-Black)
1. White-Green
2. Green-Yellow
To HVAC module C-48
Page 9 of 19
91. Horn
2
1
2
2
4
From Horn Relay (Green-Red)
1. Black-Red
2. Blue-Black
3. Green-Red
4. Yellow-red
5. White-Yellow
All wires to HVAC module C-48
97. FR Foglight
96. FR Indicator
1. GND (White-Black)
2. Lights Signal (Green)
2
2
1
1. GND (White-Black)
2. TR (Green-Black)
Page 10 of 19
Connection / Function
12V to Fuel Pump
ECU CCO
12V (via EFI relay)
ECU T
ECU VF
ECU E1 (Ground)
ECU OX (Oxygen Sensor)
Ignitor Connector 55, Pin 4
Not Connected to anything
To HVAC module
Not Connected to anything
-
Pin
Switch
Position
OFF
ON
6
B2
O
O
5
F
O
O
7
TB
3
TL
4
TR
Connector 36 : Ignition
Pin
Key
Position
LOCK
ACC
ON
START
5
+B
6
+S
1
+1
O
O
O
O
2
+2
3
EW
4
W
5
AM1
4
ACC
O
O
O
O
O
3
IG1
O
O
6
ST1
1
AM2
2
IG2
O
O
O
O
Pin
Switch
Position
INT
LOW
HIGH
WASH
Pin
Switch
Position
OFF
1
I
O
O
O
3
+1
8
TI
O
O
O
O
O
O
O
O
O
O
O
O
6
RF
High Beam
Flash/Pass
Park
Lights
Main
Lights
2
E
9
BI
4
W
High Beam
Flash/Pass
High Beam
Flash/Pass
O
O
O
1
E
5
HU
O
O
O
O
7
HL
O
O
O
Pin
Switch
Position
LEFT
OFF
RIGHT
2
TL
3
TB
O
O
4
TR
Function
From Instrument/Dash Fuse
Left Indicator TL
Right Indicator TR
Unknown From C-63 & C-82
N/C to Engine Bay Loom
Handbrake Ground
Demister Power
Rear Park Lights T
Unknown From C-63 & C-82
Fuel Pump
Rear Brake Lights
Reverse Light
N/C to Engine Bay Loom
Low Fuel Warning Signal
Fuel Level Signal
Rear wiper power
Rear Wiper Slow speed
Rear Wiper Intermittent
N/C to Engine Bay Loom
Page 11 of 19
2
3
11
ABS Fuse
Slot
4
5
12
ABS
Relay
Slot
10
9
7
13
8
9
8
10
14
15
60A
20A
20A
30A
10A
10A
20A
15A
15A
15A
-
10A
15A
10A
30A
20A
7.5A
10A
7.5A
15A
2
3
4
Page 12 of 19
#11
Main Relay
(N/O)
A/C Fan
No.2 Relay
2
2
3
Part # 90987-02006
1 N/C
#12
Cooler Relay
(N/O)
A/C Fan
No.3 Relay
(N/O)
2
3
#13
EFI Relay
(N/O)
22 Amp rating
Part # 90987-02004
Power Windows
Relay
(N/O)
22 Amp rating
#14
Body
GND
Circuit Opening
Relay
(N/O)
(Connector 1)
#15
4
5
3
Part # 90987-04003
2
2
Horn Relay
(N/O)
1. GND (White-Black)
2. C-48 HVAC (Black-Blue)
3. A/C Fan No. 2 Relay Pin 3 (Blue-Red)
5. A/C Condenser Fan (Blue-White)
4
1. A/C Fan No. 2 Relay Pin 1 & C-85 A/C
Pressure Switch (Light Green-Red)
2. Ignition IG2 (Black-Red)
3. Radiator Fan Fuse (White-Green)
4. A/C Fan No. 2 Relay Pin 5 & Radiator
Fan (Blue-Black)
N/C Relay - Pins 3 & 4 are shorted when
coil is not energized
Battery Charge
TEMS
Handbrake
O/D
ABS
Check Engine
A/T Connector
12V
White Connector
High
Beam
GND
GND
12V
GND
Blue Connector
12V
GND
GND
12V
IG+
IG+
Tacho Signal
IG+
12V
GND
GND
GND
IG+
IG+
GND
IG+
GND
12V
GND
GND
GND
GND
IG+
GND
12V
IG+
Signal
GND
Speedo Signal
IG+
GND
IG+
GND
Signal
IG+
Fuel Gauge
B3
Temperature Gauge
Lights (Positive)
A1
Green T
A2
Black-Red IG2
A3
Yellow-Red
A4
TEMS N (Power)
A5
Pink-White
A6
White
TEMS S (Power)
A7
Pink-Black
A8
Mustard
A9
A12
Tacho
A6
B6
Speedo
O/D Off
A11
Oil Pressure
A8
Handbrake
A3
Exhaust Temperature
A11 Red-Yellow
A12 Yellow-Green
A2
A9
Battery Charge
A4
Engine Check
Fuel Level Warning Light (Ground)
B1
B2
Mustard-Blue
B3
Red-Blue
ABS (Ground)
B4
B5
Brown
Speedo Signal
B6
B7
White-Black
B8
Green-Black
B9
Red-Green
ABS
B11 Green-Yellow
A/T Reverse
B11
B8
B7
Right Indicator
Left Indicator
Green
A5
TEMS (N)
Amber
A7
B12 Red-Black
A1
B9
D1
Yellow
Ground
D2
Black
Signal
D3
Blue
Ignition (IG+)
D4
Red
B4
C2
B1
B12
C1
A10
D2
TEMS (S)
Illumination
High Beam
Lo/Hi Boost Indicator
B10
D3
D1
D4
Page 15 of 19
NOTE : The details on this page have been sourced from publicly accessible PDF detailing all EP82 & EP91 ECUs and pinouts http://street-legal-starlet.nl/Sagittarius/ecu's.pdf. The details are copyrighted to StreetLegalStarlet forums http://www.streetlegal-starlet.nl/forum/, documented by Sagittarius. These details are taken as a screenshot of the single PDF page relating to the Gen1 (Dec 1989 Jan 1992) EP82 Toyota Starlet GT. ECU details for later models can be obtained from the PDF.
Page 16 of 19
NOTE : The details on this page have been sourced from publicly accessible JPG detailing the EP82 (Zenki) ECU wiring diagram. The original JPG is copyrighted to StreetLegalStarlet forums http://street-legal-starlet.nl/Sagittarius/Wiring/SLS%20%20EP82%20Wiring%20diagram%20%28zenki%29.jpg. Corrections made to the original JPG : VF Pin number corrected from CON-1 Pin 15 to 16; CON-2 Pin 7 BC added; Coil input for Main EFI relay moved from ST1 to IG2 line
Lo/Hi Boost Switch
BC 7
CON-2
16
CON-1
Page 17 of 19
Power
Windows
B-Y
Alternator
Y-B
Dash Battery
Light
Battery
(12V)
G-W
Window
Motors
W-B
Clock
R-G
Cigarette Lighter
G-R
1
L-G
Clock
Instrument Cluster
Radio
Brake Pedal
Switch
Stop Lights
Radio
Rear Lights
AM1
W
Light Control
Switch
Tail Lights
Dash
Fuse
Fog Lights
R
W-B
R-B
Fog Light
Switch
Power
Windows
Relay
G-W
Radio
GR
L-R
Ignition Switch
Legend :
W : White
B : Black
G : Green
GR : Grey
LG : Light Green
L : Blue
P : Pink
Y : Yellow
O : Orange
BR : Brown
eg. W-R : White wire, Red trace
ACC
W-L
AM1
IG1
B-Y
ST1
B-W
Rear
Demister
AM2
W-R
AM2
IG2
B-Y
Ignitor
H/Lights
Left
Low Beam
B-W
Relay Light
Reminder
H/Lights
Right
Injectors 1 & 3
G
GR
R-W HL
E W-B
High Beam
R-Y
T Lights
R-B
Low Beam
Dash High
Beam Light
Injectors 2 & 4
ECU
CON-1 #10
From Radio
Fuse
HU
R-G
High Beam
Demister
L-Y
L-B
L-O
Front Washer
B-Y
W-L
From Dash
Fuse
R-W
L-Y
Y-L
Fuel Level
Sender
Check Engine
Light
G-W
ECU
CON-2 W
GR-B
ECU
CON-2 EGW
L-W
B-R
Battery
Ignition
Fuel Level
Warning Light
Rear Washer
Starter Motor
RHS Door
Switch
Wiper motor
Wiper Switch
Wipers
ECU
CON-1 #20
R-G
Dome
Coil
Light Control
Switch
Single wire
Multiple wires
Demister
Switch
LG
B-R
B-R
Power Mirrors
LHS Door
Switch
L-G
TEMS Module
W-B
Exhaust Temp
Light
R-B
R-W
EFI Relay
2
Reverse Switch
4
W-B
W-B
2
Horn Button
GR-Y
GR-R
L-W
Fuel Pump
W-B
L
W-B
A/C Condenser
A/C Pressure
Fan
Switch
Left Indicators
L-W
Coolant Temp
Switch
LG
LG-R
B-R
LG
W-G
LG-R
W-R
W-G 3
L-B
W-G
W-B
3
L-R
W-B 4
Heater
L-W
Fan/Blower
L-R
Left Indicators
A/C Compressor
HVAC Module
B-R
Rad Fan
3
TB
B1
LG-R
Main Relay
TL
A/C
Cooler Relay
3
GR
GR-Y
TR
B2
TL
TR
TB
Turn
Horn
B-R
L-B
Y-R
Turn Signal
Switch
Hazard Switch
ECU CON-2 FC
R-L
CDS Fan
Dash
Handbrake Light
W-B
Handbrake
Circuit Opening
Relay (Connector 1)
ECU
CON-2, +B1
Horn Relay
G-W
B-R
ECU
CON-2, BATT
Haz/Horn
R-B
1
Dash
EFI
W-R
Oil Pressure
Light
ECU
CON-1, STA
G-Y
B-L
A/C On/Off Signal
L-Y
G-R
Radiator
Fan
W-B
Idle Up
Valve
G-L
B-Y
Vacuum
Switch
Valve
Ambient Temp
Sensor
Coolant
Temp
Sensor
Flasher
Relay
GR-L
W-B
Page 18 of 19
This page details the current flow through the relay coils
and switches in various configurations
IG2
Legend :
Coil Energised
Current Flow through relay coils
Current Flow through relay contacts
Cooler Relay
CDS Fan
A/C Condenser
A/C Pressure
Fan
Switch
Main Relay
Coolant Temp
Switch
HVAC Module
Rad Fan
Ignition On
A/C Off
Normal Coolant Temperature
Normal A/C Pressure
No fans running
Radiator
Fan
AM1
IG2
Cooler Relay
CDS Fan
A/C Condenser
A/C Pressure
Fan
Switch
Main Relay
Coolant Temp
Switch
HVAC Module
Rad Fan
Ignition On
A/C On
Normal Coolant Temperature
Normal A/C Pressure
Radiator
Fan
AM1
IG2
Cooler Relay
CDS Fan
A/C Condenser
A/C Pressure
Fan
Switch
Main Relay
Coolant Temp
Switch
HVAC Module
Ignition On
A/C On
High Coolant Temperature or High A/C Pressure
Fans powered in parallel through separate fuses and run at high (full) speed
A/C On/Off Signal
Rad Fan
Radiator
Fan
AM1
IG2
CDS Fan
Cooler Relay
A/C Condenser
A/C Pressure
Fan
Switch
Main Relay
Coolant Temp
Switch
HVAC Module
Rad Fan
Ignition On
A/C Off
High Coolant Temperature
Normal A/C Pressure
A/C Condenser fan not running. Radiator Fan runs as high (full) speed
Radiator
Fan
Page 19 of 19