Professional Documents
Culture Documents
Laborator 9.
Reprezentarea axonometric-izometric (2 1/2D) utiliznd AutoCAD
Laborator 9.
Laborator 9.
proiecie axonometric-izometric
Trasarea conturului bazei piesei
F5 <Isoplane Top>
Command: ellipse
Specify axis endpoint of ellipse or [Arc/Center/Isocircle]: i
Specify center of isocircle: 0,22
Specify radius of isocircle or [Diameter]: 39
Command:
ELLIPSE
Specify axis endpoint of ellipse or [Arc/Center/Isocircle]: i
Specify center of isocircle: 0,84
Specify radius of isocircle or [Diameter]: 39
Command:
ELLIPSE
Specify axis endpoint of ellipse or [Arc/Center/Isocircle]: i
Specify center of isocircle: @
Specify radius of isocircle or [Diameter]: 29
Command:
ELLIPSE
Specify axis endpoint of ellipse or [Arc/Center/Isocircle]: i
Specify center of isocircle: 0,9
Specify radius of isocircle or [Diameter]: 29
Completarea
cilindrilor
prin
trasarea
generatoarelor acestora. Pentru aceasta, este
indicat activarea modului osnap-Tangent .
Command: line
From point: (punctul P1)
To point: (punctul P2)
To point: <R>
(se repet comanda i pentru celelalte generatoare)
Command: l
LINE Specify first point: 0,0
Specify next point or [Undo]: @39<210
Specify next point or [Undo]: @0,84
Specify next point or [Close/Undo]: @10<30
Specify next point or [Close/Undo]: @0,-75
Specify next point or [Close/Undo]: @29<30
Specify next point or [Close/Undo]: c
Laborator 9.
Command: mirror
Select objects: se selecteaz profilul trasat anterior
Specify first point of mirror line: 0,0
Specify second point of mirror line: 0,30
Delete source objects? [Yes/No] <N>: enter