Professional Documents
Culture Documents
Some Theory: Conventions
Some Theory: Conventions
Conventions:
Engineers generally use a sign convention to report the three internal loadings, axial
force (N), share force (Q) and bending moment (Mf). Although this sign convention can be
arbitrarily assigned. The one that is widely accepted will be used here.
A positive shear force Q will cause the beam segment on which it acts to rotate
clockwise.
A positive bending moment Mf will tend to bend the segment on which it acts in
concave upward manner.
The axial (normal) force N is said to be positive if it creates tension (to extend it) in
beam, and negative if it create pressure (to compress it).
The shear force Q is said to be positive if it will cause the beam segment on which it
acts, if rotated for 900 counterclockwise, to create tension (to extend it) in beam, and opposite.
The bending moment Mf is said to be positive if it tend to bend the segment in way
that in bottom part of beam creates tension while in upper part of beam create compression.
Some authors will say: "The Mf is positive if it bend the beam in way that it "keeps water" in.
When a problem is given only in (by) words only and not by sketch, or on sketch with
generally displaced external loads with each of given magnitude is in appropriate table, then it
is ussual to understand that a positive sign in front of:
For bending moment (M) or bending couple (M=F x d) that it's rotation is directed
counterclockwise.
It is good to know that if share forces are positive bending moments will have
increasing (positive) slope, and if share forces are negative bending moments will have
decreasing (negative) slope.