Professional Documents
Culture Documents
Can Length
6.875
Inches Diameters
6 Top
Fold
Top Can
9
18.43
Angle
Notes:
You can make hole
slightly smaller as this
hole helps keep funnel
Bottom Can
shape pushed up against
top of can for a seal. 9%
Angle 9%
80.00
4.5000
13.5000
6.6250
Directions: Funnel will touch can at this point
1- Under Top Diameter put in the hole size
you want in Inches.
2- Under Bottom Diameter put in the Hole
size you want.
3- Change the Start & Angle for the size
Length you want.
4- Moving the Degree setting towards 0
will increase the length. Moving it
towards 90 will decrease the length.
5- Lay out on a cardboard template. Add
3/8" to both sides to interconnect the
2 pieces.
6- Using a Protractor, find the angle
degree and mark. Draw lines from the
start position thru the circle area. Cut out
the area that is color Red shown above.
7- Bend one of the 3/8 down and the other
end up as in the figure above right.
Orange area Only
Airflow
9.00
9%
Add
9% 3/8"
9%
6.875
Funnel will touch can at this point Top Can Length
Top View
Pop
Inlet Pipe in brought in
Rivets
from top and angled Lid
down at 20 degree and
round the inside of
funnel.
Center Finder
45
degree
Wooden Frame
Slots Cut
1/2"
Circular Sheet
Metal Cutter
Ace Hardware
Joining 2 Cans
Can 1 Bend
Tabs
Can 2 Bend
Tabs
1-Create your Google Account ( gma
https://accounts.google.com/signup
2- Go to Link
https://plus.google.com/communities/103583759
unts.google.com/signup
2- Go to Link
mmunities/103583759337363889002