The document outlines the procedure for conducting an insulation resistance test on electrical systems. It specifies using a 1kV Megger for low voltage 440V systems and a 5kV Megger for high voltage systems. Readings should be taken between each phase and earth, as well as between each phase combination. The test procedure was approved.
The document outlines the procedure for conducting an insulation resistance test on electrical systems. It specifies using a 1kV Megger for low voltage 440V systems and a 5kV Megger for high voltage systems. Readings should be taken between each phase and earth, as well as between each phase combination. The test procedure was approved.
The document outlines the procedure for conducting an insulation resistance test on electrical systems. It specifies using a 1kV Megger for low voltage 440V systems and a 5kV Megger for high voltage systems. Readings should be taken between each phase and earth, as well as between each phase combination. The test procedure was approved.
REV: 0 DATE: 18/8/11 PROCEDURE FOR INSULATION RESISTANCE TEST PAGE NO:01 Of 01
1. Insulation resistance test is conducted by Megger
2. For LT (440V) system 1KV Megger is used. 3. For HT system 5KV Megger is used. 4. Following readings are noted 5. Between R phase to Earth 6. Between Y phase to Earth 7. Between B phase to Earth 8. Between R phase to Y phase 9. Between Y phase to B phase 10.Between B phase to R phase.