Professional Documents
Culture Documents
AirLeg MCQ PDF
AirLeg MCQ PDF
1. What is MCAR?
a) Malaysian Civil Airworthiness Requirements.
b) Malaysian Civil Aircraft Requirements.
c) Malaysian Civil Aviation Regulations.
6. A document which approves an aircraft design which conforms to design standards is….
a) CMR
b) Type Certificate
c) C of A
10. Export C of A ….
a) Authorizes ferrying a/c from foreign states.
b) Issued by the authority of country of export.
c) Authorizes aircraft operation for maximum of one year.
28. Which of the following is NOT TRUE regarding Ferry Flight Permit?
a) Can be issued by DCA to Malaysian and Foreign registered aircraft.
b) Issued to aircraft with major structural damage or system defect.
c) Issued to an aircraft with an invalid C of A.
34. Which of following, reflect that Maintenance Schedule requirements with respect to aircraft
maintenance, has been fulfilled
a) CRS.
b) C of A.
c) CMR.
39. With regards to galley equipment, which of the following is a controlled item?
a) equipment which do not require electrical power.
b) equipment which require electrical power.
c) All movable item in the cabin.
42. For transport category a/c, toilet compartment shall have ashtrays on
a) both inside and outside.
b) Only inside.
c) Not required on No Smoking flight.
51. Where would you find the legislation regarding nationality and registration marking of Malaysian
registered aircraft?
a) BCAR
b) MCAR
c) Airworthiness Notices.
53. After completing a 150 hours inspection under LAMS, an LAE must issue
a) CMR.
b) CRS.
c) C of A.
54. Engine Logbooks must be retained for a minimum period of
a) 6 months.
b) 2 years after the engine has been destroyed or removed from service.
c) 2 years after the logbook has been completely filled.
56. A Public Transport aircraft must carry the following documents for flight
a) Aircraft logbook, technical records and BCAR.
b) Technical log, engine logbook, flight manual and load sheet.
c) C of A, Operations Manual, load sheet and technical log.
65. The retention time of an aircraft load sheet, after the flight to which it refers is
a) 3 months.
b) 12 months.
c) 6 months.
70. The Certificate of Maintenance Review will indicate the following except
a) Date of next review.
b) Signatures of all the categories of LAE.
c) Aircraft registration.
73. The following are the conditions for CMR issuance except
a) All necessary CRS have been duly issued.
b) All defects shall be rectified and no deferred defects.
c) All maintenance as per Maintenance Schedule has been carried out.
75. When Malaysia is the Certifying Authority, the Airworthiness Directives issued by DCAM, is
a) CAM AD.
b) VAM AD.
c) DCA AD.
78. Which of the following is NOT TRUE about Technical Log book?
a) Applicable to Public Transport and Aerial Work aircraft.
b) Regulation 29 of MCAR is related to Technical Log.
c) All entries are required to be in 4 copies.
80. Which of the following is NOT TRUE regarding a/c flying under Condition A?
a) Must be registered.
b) Certificate of Fitness for Flight must be issued prior to flight.
c) Need not be registered.
81. Which of the following explains a/c flying under Condition B?
a) Must be registered.
b) Need not be registered.
c) Need not be registered, but must be marked in a manner approved by DCAM.
86. The purpose of the Flight Manual is to state the approved procedures
a) essential for the safe operation of the aircraft.
b) For the maintenance of the aircraft systems.
c) As required by the operator.
87. The C of A will remain valid within its period of validity provided
a) the a/c is maintained in an approved manner.
b) Flights are conducted only over countries of Contracting State.
c) The aircraft is not re-registered.
89. If the commander of the a/c has nothing to report in the Technical Log regarding ‘DEFECTS’,
he must fill the technical log as follows
a) Aircraft free of defects.
b) No entry is required by the pilot.
c) Nil defect.
90. Technical Log entries must be made in
a) Duplicate.
b) Triplicate.
c) Quadruplicate.
93. Parts conforming to the design and airworthiness requirements are stored in
a) Quarantine stores.
b) Bonded stores.
c) Flammable stores.
95. In ATA 100 Specification system, pages numbered 101 to 200 relate to
a) Removal and installation.
b) Troubleshooting.
c) Maintenance practices.
103. Which of the following is TRUE regarding Certificate of Fitness for Flight?
a) Valid for 7 days but for one flight only.
b) Valid for any number of flight s within 7 days, provided there are no defects.
c) Signed by Chief Inspector of Flights.
105. The certification and airworthiness of parts acquired from distributors is the responsibility of
a) Manufacturer.
b) Distributor.
c) User or operator.
111. C of R is issued in
a) one copy.
b) Duplicate copies.
c) Three copies.
116. The nationality and registration marks together with the name and address of the registered
owner shall be
a) displayed in any position inside the aircraft.
b) Inscribed on a fire proof metal plate and affixed in a prominent position near the aircraft main
entrance.
c) Painted in bright colours in a prominent place inside the cabin.
117. An American Export C of A indicates that
a) The a/c, engine or component conform to the FAA regulation and qualify for American C of A.
b) The component or equipment was overhauled in USA.
c) The a/c, engine or component can be exported from Malaysia to USA.
119. If an aircraft has C of A under Transport category (passenger), it can be used for
a) any purpose other than public transport of passengers.
b) The purpose of public transport of passengers only.
c) Any purpose.
123. Who can sign the CRS in technical log for a defect rectification?
a) LAE or persons authorized by an approved organization.
b) LAE or any inspector.
c) LAE only.
124. For a/c registered in Malaysia in aerial work category below 2730 kgs MTWA
a) CMR is not required if flying within Malaysia.
b) CMR must be issued.
c) CMR is valid for 4 months only.
128. If there is no engineer available, who can sign for duplicate inspection of minor inspection or
adjustment away from base
a) Pilot or flight engineer, rated on that a/c type.
b) A/c can only be flown under dispensation.
c) A/c to be grounded until engineer is available.
131. Which of the following documents should NEVER be flown in the aircraft to which they refer?
a) Technical log.
b) CMR.
c) Aircraft Log book.
136. When a major modification grounds the a/c, the validity of the CMR is..
a) invalid indefinitely.
b) Invalid until mod is completed and no. of days have been added back.
c) Valid until unless the CMR expires during the mod period.
154. If a minor repair is carried out in an area but no signatory for CRS..
a) the commander may fly the a/c to the nearest place for certification.
b) Permission is required from the DCA before flying the a/c.
c) Clear the CRS at base.