You are on page 1of 60

MISSIONTM CENTRIFUGAL PUMPS

Magnum™, 2500 Supreme™, Magnum™ XP, Sandmaster™

MissionTM Centrifugal Pumps

One Company Unlimited Solutions


The Evolution

During the 1950’s the Mission® 1780 type “W” pumps


were introduced to replace duplex pumps while
creating the first low pressure mud system. The use
of a high quality concentric type centrifugal pump
allowed abrasive fluids to be mixed and transferred
while reducing initial and maintenance costs for the
drilling industry. The low-pressure mud system with
Mission 1780 Type “W” centrifugal pumps became
the industry standard.

As well depths increased so did the need for heavier


mud weights. When the mud weight began exceeding
14 ppg the need for a pump that could withstand
greater horsepower loads arose. During the 1970’s
Mission organized a design team that engineered the
Mission Magnum. The Magnum was designed to have
the same footprint, flange locations, and drive shaft
diameter as the 1780 “W”. This allowed a 1780 to be
replaced by a Magnum without any skid modifications.
The Magnums were engineered with a 2 1/2” shaft
(3” between the bearings), double row bearings with
an engineered life of over 2 years at 200 HP, larger
impellers and heavier frames. The Magnum allowed
drilling contractors to upgrade their centrifugal pumps
and mix heavier fluids.

The National Oilwell Mission centrifugal pump line has


proven to be the best centrifugal design for handling
abrasive mud. This pump line offers a broad selection of
innovative features for a variety of routine, demanding,
abrasive and corrosive applications. These pumps are
designed for a wide range of flow rates, from a few
gallons per minute to thousands of gallons per minute.

National Oilwell is dedicated to continual improvement


of our product line and offering innovative solutions to
service our customers. Included in this manual are
quality National Oilwell products that have been designed
to meet your needs. The future is being defined and the
solution is available from National Oilwell.
This catalog has been divided into eight major sections.
Each section has been color coded for convenience.

Mission Magnum & 2500 Supreme Pumps 2-14

Sandmaster, Vortex and Magnum XP Pumps 15-18

Shear Pumps 19-20

Pump Sizing Information 21-26

Pump Performance Curves 27-45

Dimensional Data 46-51

Piping Recommendations 52-53

Related Equipment 54-55

Close Coupled Centrifugal Pumps 56

Conversion Table 57

The pictures, photographs, charts, diagrams, drawings, written comments and specifications contained herein
are not to be construed as giving rise to any warranty on the part of Mission, a product of National Oilwell.
Mission makes no warranty, either expressed or implied, beyond that stipulated in the Mission Standard Terms
and Conditions of Sale.
Mission Magnum and 2500 Supreme Pumps

Features of the Magnum®,


2500 SupremeTM, and
Sandmaster® Pumps
Each pump contains the finest materials,
engineering and craftsmanship available
in the industry. Described are like features
of these pump lines and unique features
are described on the following pages.

National Oilwell utilizes unique design


features developed for slurries. Three
major differences from most pump
designs include the concentric
casing, wider impellers and increased
re-circulation areas. Each feature
contributes to reducing wear when
handling abrasive fluids.

Thicker, Stronger, Concentric Casing


All of the pumps feature a concentric casing that is
an average of 37% thicker than conventional pump
casings, and up to 50% thicker for the larger, mud
pumping models. They are pressure rated at 1.5
times the flange rating and are designed with a 1/8”
erosion allowance. The concentric style casing has
Concentric proven to offer the greatest pump life and reduced
Casing downtime. The walls of a concentric style casing are
an equal distance from the impeller throughout the
impeller circumference, which results in a smooth
flow pattern. A volute style casing has a cutwater
point that disturbs the fluid flow pattern creating an
eddy. The concentric casing eliminates vibration,
turbulence and aeration that is caused by the
cutwater point in conventional volute pumps. It also
reduces the high bearing loads and shaft deflection
even at near shutoff flows.

Volute
Casing

2
MISSIONTM PRODUCTS

Wider Impeller, Increased


Re-circulation Area
National Oilwell’s impeller design has wider vanes at the
tip which decreases the velocity of the fluid exiting
the impeller. This eliminates the abrasive jetting effect
that is present with narrow impellers. The distance
between the impeller tip and the casing is greater
resulting in an increased re-circulation area. Lower
velocity rates and increased re-circulation areas
allow the exiting fluid to blend with the re-circulating
fluid reducing turbulence and wear. The entrance
shape of the impeller vanes is more tangential to the
circumference of the suction creating a smoother
flow pattern. Smooth flow is crucial when handling
abrasive fluids.

Wide Tipped Impeller ANSI Style Impeller

Heavy-duty Shaft
The shaft is much larger in diameter than conventional
pump shafts for heavy-duty performance, minimum
deflection and increased operating life of the seal or
packing. With a 2 1/2” diameter at the seal area and
3” diameter between the bearings these pumps can
be direct connected or belt driven.

The shaft area under the packing is protected by a


replaceable, hook type sleeve with one end free to
expand with temperature variation. This sleeve can
be replaced in the field without shaft removal.

Highest Quality Bearings


Advanced front and rear bearing design reduces
both radial and thrust loads. The outboard bearing
is a duplex set of angular contact bearings with high
thrust load capabilities and zero endplay. This bearing
set features 24 large balls that are preloaded so that
each bearing carries an equal load.

National Oilwell utilizes an inboard bearing that is


a single row roller bearing with high radial load
capabilities. This bearing was selected to replace
the previously utilized double row bearing due to
its engineered bearing life of over 2.2 times the L10
life of previously utilized double row ball bearings.

Bearing Lubrication Options


Oil or grease lubrication is available. Grease lubrication
is the factory standard. Oil lubrication is recommended
for pump speeds in excess of 2400 RPM. Oil lubricated
pumps must be maintained in a horizontal level position.

3
Mechanical Seal Options
Type I Mechanical Seal
A type I single tungsten carbide vs. tungsten carbide
mechanical seal is standard. Tungsten carbide has
proven itself as a highly abrasive resistant material
with a Ph range of 7 to 14. For applications with a
lower Ph level the silicon carbide vs. silicon carbide
mechanical seal is recommended with its Ph range
from 0-14. Both mechanical seals are lubricated by
the fluid being transferred and require the pump to
remain primed during operation.

When the pump is subject to high temperature fluids,


oil base muds with low aniline points, running dry or OlympiaTM Double
extremely abrasive fluids the OlympiaTM cartridge type Mechanical Seal
double mechanical seal is the solution. Utilizing a
barrier fluid between the two seals ensures the seal
faces remain lubricated even when the pump is run
dry. The fluid being transferred has virtually no effect
on the seal since the barrier fluid is in contact with the
seal faces. Another benefit of the double seal is the
ability to remove the cartridge from the pump and
then place it back into operation. This allows the
stuffing box to be replaced without requiring a new
mechanical seal.

Custom mechanical seal options can be provided for


specific applications.
Centrifugal Equipped with Olympia Seal

Versatile Stuffing Box


An easily removable stuffing box allows these
pumps to be customized to meet customer needs.
Stuffing Box with Dual Bolt Holes
The different options available are stuffing boxes to
accommodate:

• Shaft packing
• Single mechanical seal
• OlympiaTM Double mechanical seal with barrier fluid

The packed box has a tapped opening to the


lantern ring to allow grease lubrication or a flush
line to be attached.

Dual stuffing box bolts are positioned 180 degrees


apart to hold the stuffing box in position during
casing removal. When only one stuffing box bolt is
used the stuffing box remains in position on one
side while the other side moves with the casing,
causing the casing to bind and make removal difficult.

Casing Jack Bolts


Casing jack bolts are an added feature to the
Magnum and 2500 Supreme pump lines. Jack bolts
allow the casing to be mechanically removed
eliminating the need for pry bars or striking the
casing during maintenance. This feature simplifies
maintenance and eliminates damage to the casing
and pedestal during disassembly.

4
MISSIONTM PRODUCTS

Solid Frame Base


The solid frame base strengthens the pump and
eliminates broken feet that occur with pumps
equipped with a split base.

Fluid End Materials


Various fluid end materials are available that allow
these pumps to be utilized for a variety of applications.
Standard pumps are supplied with a hard iron fluid
end but can be upgraded to stainless steel, aluminum
bronze, MagnachromeTM, or Supreme Hard. These
materials are available for select sizes and can be
purchased as a complete or fitted fluid end.

Magnachome material is a proprietary material


exclusive to National Oilwell and is formulated
specifically for its high abrasion resistant qualities.
Magnachrome is approximately 3 times harder
than Hard Iron. The Supreme Hard material is
approximately 2 times harder than Hard Iron.

Technical Support and Parts Availability


With locations and distributors throughout the world, National Oilwell ensures our customers can obtain technical
assistance and pump parts in a timely manner. Engineering support, literature and electronic manuals are available
to help properly size and service equipment.

Superior Packaging and Labeling


All parts are properly packaged to protect the equipment during shipping. The material is clearly marked to allow our
customers to ensure they are getting OEM manufactured parts and allow packers and service hands to confirm they
have the correct equipment without having to open the packaging and expose the equipment to external elements.

Magnum & 2500 Supreme


National Oilwell is dedicated to providing a full line of products to meet the needs of our customers. Realizing
customer needs and priorities may differ, National Oilwell provides two separate pump lines with like operating
and dimensional characteristics. Following are the unique features of the Magnum and 2500 Supreme.

Magnum* 2500 Supreme*


Open impeller design that lowers axial thrust loads and is equipped with Semi Open impeller design that reduces the amount of solids that enter
an anti-loosening impeller lock bolt to ensure the pump is not damaged the stuffing box extending the life of the mechanical seal or packing
if run in reverse. (Anti-spin bolt is not available on 3x2x13 models) and the life of the stuffing box. (Available on 5x4x14 – 10x8x14 models)
Lip seals and exclusion seal to retain lubricants and protect bearings Labyrinth seals to offer maximum bearing protection from external
from external contamination. contamination. Labyrinth seals rotate with the shaft eliminating
shaft wear.
Fluid end parts available with Magnachrome corrosive and abrasive Fluid end parts available with Supreme Hard material that has a 400
resistant material. Magnachrome impellers have a 400 Brinell Brinell hardness. The standard impeller, casing wear pad and stuffing
hardness and Magnachrome casings and stuffing boxes feature box are Ductile Iron to ensure even wear characteristics.
a 600 Brinell hardness.
One piece casing Casing provided with replaceable casing wear pad on
4x3x13 – 10x8x14 models.

*The Magnum and 2500 Supreme are available through select distributors.

5
Magnum Features

1 Thick, strong concentric casing provides extended life 11 Lip and exclusion seals for bearing protection
over conventional volute designs. The concentric 12 Optional flanged bearing housing available for
design minimizes turbulence and abrasive wear. hydraulic drive
2 Wide open-vane impeller creates lower axial thrust for 13 External adjustment of impeller clearance extends
improved bearing life. pump performance life.
3 Casing gasket recessed for protection. 14 Large heavy-duty shaft reduces deflection for longer
4 Replaceable stuffing-box cover with dual stuffing life of packing and mechanical seals.
box bolts 15 Solid base offering rigidity and strength
5 Optional stuffing boxes available for single and double 16 Casing jack bolts simplify casing removal
mechanical seal applications and can be configured 17 Easily accessible front access drain, when requested.
for flush lines. 18 Back vanes reduce collection of solids at stuffing box
6 Long-life no-adjustment mechanical seal available for and reduce box pressure.
near zero leakage. 19 Smooth impeller eye for minimum turbulence and
7 Replaceable shaft sleeve prevents shaft wear. higher efficiency.
8 Single row roller bearings for increased bearing life. 20 Anti-loosening impeller lock bolt to eliminate pump
9 Oil lubrication for bearings available upon request and damage in case of improper motor hook-up.
recommended for pump speeds in excess of 2400 RPM. 21 Full pipe diameter entrance for minimum turbulence
10 Duplex angular contact bearings eliminate shaft end and maximum efficiency.
play and increases bearing and seal life.

See pages 27-40 for pump performance curves


See page 46 for dimensional data

6
MISSIONTM PRODUCTS

2500 Supreme Features

1 Thick, strong concentric casing with replaceable casing 10 Duplex angular contact bearings eliminate shaft end
wear pad provides extended life over conventional play and increases bearing and seal life.
volute designs. The concentric design minimizes 11 Labyrinth seals for maximum bearing protection are
turbulence and abrasive wear. The wear pad allows standard. Lip seals are recommended for
the casing to be repaired at a lower cost than replacing oil-lubricated pumps.
the entire casing. 12 Optional flanged bearing housing available for
2 Wide semi open impeller creates lower axial thrust for hydraulic drive.
improved bearing life. The semi open design reduces 13 External adjustment of impeller clearance extends
the concentration of solids behind the impeller pump performance life.
extending the life of the mechanical seal or packing 14 Large supreme-duty shaft reduces deflection for longer
and stuffing box. life of packing and mechanical seals.
3 Casing gasket recessed for protection. 15 Solid base offering rigidity and strength.
4 Replaceable stuffing-box cover with dual stuffing 16 Casing jack bolts simplify casing removal.
box bolts. 17 Replaceable casing wear pad.
5 Optional stuffing-boxes available for single and double 18 Easy accessible front access drain.
mechanical seal applications and can be configured 19 Back vanes reduce collection of solids at stuffing box
for flush lines. and reduce box pressure.
6 Long-life no-adjustment mechanical seal available for 20 Smooth impeller eye for minimum turbulence and
near zero leakage. higher efficiency.
7 Replaceable shaft sleeve prevents shaft wear. 21 Full pipe diameter entrance for minimum turbulence
8 Single row roller bearings for increased bearing life. and maximum efficiency.
9 Oil lubrication for bearings available upon request and
recommended for pump speeds in excess of 2400 RPM.

See pages 27-40 for pump performance curves


See page 46 for dimensional data
7
8
Magnum Parts List
Item Qty Part Number Process # Description Material Item Qty Part Number Process # Description Material
1* 1 See Below See Below Casing Hard Iorn 10E 2 3932-2 601408560 Nut, I.B. Brg. Cover Stl
1A 1 10399-46-1 648403012 Gasket, Casing Vellumoid 10F 1 20620-01 648408409 Exclusion Seal, I.B. Brg. Cvr. Buna-n
1B 12 3932-61 648402014 Nut, Casing Stl 10G 1 21641-01 661010033 Grease Fitting Stl
1C 12 3862-76 648401115 Stud, Casing Stl 10H 1 648411908 Grease Fitting Stl
1D 1 8505-04-01 86485503 Plug, Casing Drain Stl 11 1 N/A 661009010 Bearing, Inboard Vendor
1E 1 8505-04-01 646400507 Plug, Flush Line Iron 12 1 20624-01-01 644308504 Housing, O.B. Bearing Iron
2* 1 See Below See Below Impeller Hard Iorn 12A 1 7496-253 648402295 Seal, O.B. Brg Housing Buna-n
2A 1 19110-72 648405082 Seal, Impeller Viton 12B 4 3861-138 648401057 Bolts, O.B. Brg. Housing Stl
2B 1 7300239 Washer, Impeller Stl 12C 2 3932-62 658404702 Nut, O.B. Brg. Housing Jam Stl
2C 1 7415648 Bolt, Impeller Lock Stl 13 1 20617-01-01 641103296 Cover, O.B. Bearing Iron
3*# 1 22223-01-30 641116157 Stuffing Box, Mech. Seal Hard Iorn 13A 1 661010020 Grease Zerk, O.B. Brg. Cvr. Stl
3*& 1 20614-01-30 643365042 Stuffing Box, Packed Hard Iorn 13B 1 7496-26 072200017 O-ring, O.B. Bearing Cover Buna-n
3A 2 3861-117 648401016 Bolt, Stuffing Box Stl 13C 1 20619-02 648408359 Oil Seal, O.B. Brg. Cover Buna-n
3B& 1 19368-01 601499403 Grease Fitting Stl 13D 2 3861-139 648401081 Bolt, O.B. Brg. Cover Stl
4 1 20622A 641103338 Gland Assy., Packing Bronze 14 1 N/A 648408201S Bearing, O.B. (2 Req’d) Vendor
5A# 1 22451-1 648414308 Seal, Mechanical Tungsten Carbide 14A 1 6124-4 648402105 Lockwasher, O.B. Bearing Stl
5A~ 1 25014-04M-B 661007005 Packing, Shaft Graphite/Acrylic 14B 1 6123-4 648402055 Locknut, O.B. Bearing Stl
6 2 B3701A 601102494 Bolt Assy, Gland Stl Casings - Includes Studs, Nuts & Gasket
7 1 20612-02-33 646490557 Shaft AISI 4140 1* 1 19203-01-30A 641101753 Casing, 3x2x13 Hard Iron
7A# 1 20943-21 641102182 Sleeve, Shaft (M.S. Pump) 416SS 1* 1 19205-01-30A 641101902 Casing, 4x3x13 Hard Iron
7A& 1 20613-21G-7A 641102181 Sleeve, Shaft (Pack Pump) 416SS/Ceramic 1* 1 19222-01-30A 641102058 Casing, 5x4x14 Hard Iron
7B 1 4372-5-21 601212392 Key, Shaft 416ss 1* 1 19122-01-30A 641101456 Casing, 6x5x11 Hard Iron
7C 1 23444-01-72 648415156 Seal, Shaft Sleeve Viton 1* 1 19123-01-30A 641101605 Casing, 6x5x14 Hard Iron
8 1 22210-1A 641116108 Deflector Assembly Bronze 1* 1 19763-01-30A 641102157 Casing, 8x6x11 Hard Iron
9 1 20618-12-1 644302499 Frame, Grease Lubricated Cast Iron 1* 1 19117-01-30A 641101308 Casing, 8x6x14 Hard Iron
9A! 1 8505-05 601474737 Plug, Oil Drain Iron 1* 1 20937-01-30A 641102322 Casing, 10x8x14 Hard Iron
9B! 1 18471 648403608 Plug, Oil Fill Iron Impellers
9C 1 8505-05 601474737 Plug, Frame Drain Iron 2* 1 19204-XX-30 Varies Impeller, 3x2x13 Hard Iron
9D 1 8267-01 601473689 Breather Stl 2* 1 19206-XX-30 Varies Impeller, 4x3x13 Hard Iron
9E 1 8478-3 601174584 Oiler Assembly 2* 1 19224-XX-30 Varies Impeller, 5x4x14 Hard Iron
9F! 1 A 662014131 662014131 Dip Stick Stl 2* 1 19121-XX-30 Varies Impeller, 6x5x11 Hard Iron
9G 3 2538-1H Bolt, Casing Jack Stl 2* 1 19121-XX-30 Varies Impeller, 6x5x14 Hard Iron
10A 1 20626 644303109 Cover, Inboard Bearing Iron 2* 1 19121-XX-30 Varies Impeller, 8x6x11 Hard Iron
10B 1 20625 648408706 Gasket, I.B. Brg. Cover Vegetable Fiber 2* 1 19116-A0-30 Varies Impeller, 8x6x14 Hard Iron
10C 1 20619-01 648408300 Oil Seal, I.B. Brg. Cover Buna-n 2* 1 21867-XX-30 Varies Impeller, 10x8x14 Hard Iron
10D 2 3861-1 601407505 Bolt, I.B. Brg. Cover Stl

XX - Impeller Code - First X equals diameter of impeller in inches minus 4. Therefore 10” = 6, 9”= 5, 8”=4, etc… 14” use letter A.
Second X equals frational data in 1/8’s. Therefore 1/8” = 1, 1/4” = 2, 1/2” = 4, etc…Thus a 10.5” impeller is coded as 64, a 12” impeller is coded as 80, a 13.25” impeller is coded as 92 etc…
Notes:
* - Casings, Impellers and Stuffing Boxes are also available as Stainless Steel, Aluminum Bronze or Magnachrome - See local dealer for Part Numbers.
# - Used for pumps equipped with mechanical seal only.
& - Used for pumps equipped with packing only.
! - Used for oil lubricated pumps only.
~ - Packing available in various materials - standard material shown
MISSIONTM PRODUCTS

9
10
2500 Supreme Parts List
Item Qty Part Number Process # Description Material Item Qty Part Number Process # Description Material
1* 1 See Below See Below Casing, Includes 1 thru 1E Hard Iron 12A 1 H7496-253 648402295 Seal, O.B. Brg Housing Buna-n
1A 1 10399-46-1 648403012 Gasket, Casing Vellumoid 12B 4 H3861-138 3861-138 Bolts, O.B. Brg. Housing Stl
1B 12 3932-61 3932-61H Nut, Casing Stainless Steel 12C 2 H3932-62 658404702 Nut, O.B. Brg. Housing Jam Stl
1C 12 H2507-3 648401115 Stud, Casing Stl 13 1 H20617A 20617H Cover, O.B. Bearing Ductile Iron
1D* 1 See Below See Below Wear Pad, Includes stds, nuts & gskt 13A 1 661010020 Grease Zerk, O.B. Brg. Cvr. Stl
1E 1 8505-2H 601474703 Plug, Casing Drain Stl 13B 1 H7496-26 072200017 O-ring, O.B. Bearing Cover Buna-n
2* 1 See Below See Below Impeller Hard Iron 13C 1 H2564-3 2564-3H Labyrinth Seal, O.B. Brg. Cvr. Buna-n
2A 1 H19110-72 648405082 Seal, Impeller Viton 13D 2 H3861-139 3861-139-4 Bolt, O.B. Brg. Cover Stainless Steel
3*# 1 H22223-01-30 22223H Stuffing box, Mech. Seal Ductile Hard Iorn 14 2 H20616-1S 648408201S Bearing, O.B. (2 Req'd) Vendor
3*& 1 H20614-01-30 20614H Stuffing Box, Packed Ductile Hard Iorn 14A 1 H6124-4 648402105 Lockwasher, O.B. Bearing Stl
3A 2 H3861-117 3861-117 Bolt, Stuffing box Stl 14B 1 H6123-4 648402055 Lucknut, O.B. Bearing Stl
3B& 1 19368-1H 19368-1H Grease Fitting Stl Casings - Includes Studs, Nuts & Gasket
4 2 H20622-4A 20622AH Gland Assy., Packing Stainless Steel 1* 1 H19203-01-30A 19203AH Casing, 3x2x13 Hard Iron
5A# 1 H22451-1A 22451K Seal, Mechanical Tungsten Carbide 1* 1 H19205-01-30A 19205AH Casing, 4x3x13,w/ wear pad Hard Iron
5B~ 1 8264-24-OB 648402600 Packing, Shaft 1* 1 H19222-01-30A 19222AH Casing, 5x4x14,w/ wear pad Hard Iron
6 2 20629 601102494 BOLT,GLAND Stl 1* 1 H19122-01-30A 19122AH Casing, 6x5x11,w/ wear pad Hard Iron
7 1 H20612-02-33 646490557 Shaft AISI 4140 1* 1 H19123-01-30A 19123AH Casing, 6x5x14,w/ wear pad Hard Iron
7A# 1 H20613-21A 646492505 Sleeve, Shaft (M.S. Pump) 416SS 1* 1 H19763-01-30A 19763AH Casing, 8x6x11,w/ wear pad Hard Iron
7A& 1 H20613-21G-7A 646490656 Sleeve, Shaft (Pack Pump) 416SS/Ceramic 1* 1 H19117-01-30A 19117AH Casing, 8x6x14,w/ wear pad Hard Iron
7B 1 H4372-5-21 601212392 Key, Shaft 416ss 1* 1 H20937-01-30A 20937AH Casing, 10x8x14,w/ wear pad Hard Iron
7C 1 23444-01-72 648415156 Seal, Shaft Sleeve Viton Impellers and Casing Wear Pads
8 1 22210-1A 641116108 Deflector Assembly Bronze 2* 1 H19204-XX-30 Varies Impeller, 3x2x13 Open Ductile Hard Iron
9 1 H17444 17444H Frame, Grease Lubricated Cast Iron 2* 1 H19206-XX-30 Varies Impeller, 4x3x13 Open Ductile Hard Iron
9A! 1 H8505-1 8505-1 Plug, Oil Drain Iron 2* 1 H2523-XX-30 Varies Impeller, 5x4x14 Semi Open Ductile Hard Iron
9B! 1 8505-2H 601474703 Plug, Oil Iron 2* 1 H2524-XX-30 Varies Impeller, 6x5x11 Semi Open Ductile Hard Iron
9C 1 601474737 Plug, Frame Drain Iron 2* 1 H2524-XX-30 Varies Impeller, 6x5x14 Semi Open Ductile Hard Iron
9D 1 H8267-1 601473689 Breather Stl 2* 1 H2524-XX-30 Varies Impeller, 8x6x11 Semi Open Ductile Hard Iron
9E 1 H2565-1 2565-1H Plug, Oil Fill Plastic 2* 1 H2525-A0-30 Varies Impeller, 8x6x14 Semi Open Ductile Hard Iron
9F! 1 H2539-3 2539-3H Dip Stick Stl 2* 1 H2526-XX-30 Varies Impeller, 10x8x14 Semi Open Ductile Hard Iron
9G 2 H2538-1 2538-1H Bolt, Casing Jack Stl 1E 1 H2501-01-30A 2501-37AH Wear Pad, 4X3X13 Casing Ductile Hard Iron
10A 1 H17950 17950H Cover, Inboard Bearing Iron 1E 1 H2502-01-30A 2502-37AH Wear Pad, 5X4X14 Casing Ductile Hard Iron
10B 1 H20625 648408706 Gasket, I.B. Brg. Cover Vegetable Fiber 1E 1 H2503-01-30A 2503-37AH Wear Pad, 6X5X11 Casing Ductile Hard Iron
10C 1 H2564-4 2564-4H Labyrinth Seal, IB Brg Cvr Buna-n 1E 1 H2504-01-30A 2504-37AH Wear Pad, 6X5X14 Casing Ductile Hard Iron
10D 2 H3861-1 3861-1H Bolt, I.B. Brg. Cover Stl 1E 1 H2505-01-30A 2505-37AH Wear Pad, 8X6X11 Casing Ductile Hard Iron
10E 1 661010033 Grease Fitting Stl 1E 1 H2506-01-30A 2506-37AH Wear Pad, 8X6X14 Casing Ductile Hard Iron
11 1 N/A 661009010 Bearing, Inboard Vendor 1E 1 H2527-01-30A 2527-37AH Wear Pad, 10X8X14 Casing Ductile Hard Iron
12 1 H20624-01-01 20624H Housing, O.B. Bearing Iron

XX - Imp. Code - First X equals diameter of impeller in inches minus 4. Therefore 10” = 6, 9”= 5, 8”=4, etc…14” use letter A.
Second X equals frational data in 1/8's. Therefore 1/8” = 1, 1/4” = 2, 1/2” = 4, etc…Thus a 10.5” impeller is coded as 64
Notes:
* - Casings, Imp. & Stuff Boxes are available as Supreme Hard or Aluminum Bronze
# - Used for pumps equipped with mechanical seal only.
& - Used for pumps equipped with packing only.
! - Used for oil lubricated pumps only.
MISSIONTM PRODUCTS

~ - Packing available in various materials - standard material shown

11
Vertical Magnum Parts List
Parts Common to all Vertical Magnums
Item Quantity Part Number Description
1 1 662014039 Pump-Base
6 1 648414308 Mechanical Seal
7 12 648401115 Casing studs
8 12 648402014 Casing Nuts
11 1 648403012 Casing Gasket
15 1 643367048 Mech Seal Stuffing Box
19 1 662010051 Impeller Anti-rotation Bolt
20 1 Contact Factory Electric Motor
22 1 641103338 Packing Gland
23 1 661007023 Back-up Packing
24 & 25 2 601102494 Gland Bolts
26 1 648405082 Impeller O-ring
27 8 601482417 Set Screw
28 1 646400507 Casing Drain plug
29 1 7618024 Anti-Spin Bolt Washer
Not Shown 2 648401016 Stuffing Box Bolts

12
MISSIONTM PRODUCTS

Parts Specific by Pump Size


Item # 2 3 5 8 9 10 12 16 17
Casing Assy.
H.I. (1) H.I. Impeller
Base Includes Suction Suction Suction (1) (P/N Base Base
Pump Companion studs, nuts, Suction Flange Flange Flange varies by Flange Flange
Size Flange (1) and gasket Elbow (1) Nut Stud Gaskets (2) diameter) Nut Stud
3x2x13 662014044 641101753 665002001 648402014 601408305 601475189 641215603 601408552 601208285
4x3x13 662014043 641101902 665002002 648402014 601408305 601475346 641217005 601408552 601208285
5x4x14 662014042 641102058 665002003 648402014 648401115 601475254 641217831 601408552 601208285
6x5x11 662014041 641101456 665002004 648402014 648401115 601475338 641211602 601408552 601208285
6x5x14 662014041 641101605 665002004 648402014 648401115 601475338 641212105 601408552 601208285
8x6x11 662014040 641102157 665002005 648402014 648401115 601475320 641211602 601408552 601208285
8x6x14 662014040 641101308 665002005 648402014 648401115 601475320 641209903 601408552 601208285
10x8x14 641102322 641221007 601408552 601208285

Parts Specific by Motor Frame Size


Item # 4 14 13 21 27 30 31
Motor Motor
Outboard Inboard Shaft Motor Motor
Motor Motor Shaft Sleeve Shaft Sleeve Shaft Sleeve Set Adapter Adapter
Frame Adapter (1) (1) (1) Key (1) Screw (6) Studs (4) Nuts (4)
215JP 662014045 662013010 662013009 601212251 75634012 601408412 658404702
254JP 662014045 662013010 662013009 601212251 75634012 601408412 658404702
256JP 662014045 662013010 662013009 601212251 75634012 601408412 658404702
284JP 662014055 662013010 662013009 601212251 75634012 601408305 658404702
286JP 662014055 662013010 662013009 601212251 75634012 601408305 658404702
324JP 662014055 662013010 662013009 601212251 75634012 601408305 601408552
326JP 662014055 662013010 662013009 601212350 75634012 601408305 601408552
364JP 662014055 662013012 662013011 601212350 75634012 601408305 601408552
365JP 662014055 662013012 662013011 601212350 75634012 601408305 601408552
404TCZ 662014055 662013012 662013011 601212350 75634012 601408305 601408552
405TCZ 662014055 662013012 662013011 601212350 75634012 601408305 601408552
444TCZ 662014055 662013012 662013016 601212350 75634012 601408305 601408552

13
Versatile Drive and Mounting Options
Unitization services and options compliment the
centrifugal pump line. National Oilwell centrifugal pumps
are available as horizontal electric, vertical electric,
close coupled electric, horizontal diesel, overhead
belt, side belt and hydraulic driven pumping units.
The horizontal electric units are fabricated on a steel
channel base engineered to provide proper alignment
with minimal shimming requirements. Diesel driven
units are provided with full instrumentation, batteries
and fuel tanks. Side overhead belt units feature a
small footprint and allow the pump to be operated at
the lowest possible speed, which extends pump life
significantly. Vertical units require the least amount of
deck space and are available as close coupled or
direct connected. Close coupled horizontal models
require the least amount of cubic space and eliminate
pump and driver alignment concerns. Hydraulic adapters
are available with SAE size “C” and “D” adapters.

Grease lubricated pumps can be mounted vertically or


horizontally and upright or upside down. The casing can
be rotated to any angle but the discharge should always
be oriented above the suction to prevent air pockets
from forming. Custom unitization services are available.

14
MISSIONTM PRODUCTS

Sandmaster, Vortex and Magnum XP Pumps

SANDMASTER® PUMPS
The compact and adaptable Sandmaster centrifugal Common applications include:
pump includes virtually all of the features of the Cement
Magnum I. Sandmasters are more compact in Charge Pump
design and can be adapted for hydraulic motor drive. Blender
These features make Sandmaster pumps ideal for Waterwell Drilling
use in applications such as oilfield frac trucks as Other Mobile uses
well as blending and pump charging for water well
drilling applications. Available Sizes:
3x2x13 6x5x14
All parts for these pumps are identical to the Magnum 4x3x13 8x6x11
except for the frame and shaft. The frame and shaft 5x4x14 8x6x14
have been shortened 4” to reduce the length of 6x5x11 10x8x14
the pump. When space is a premium and prime
mover options are limited, the Sandmaster is the
pump of choice.

See pages 27-40 for pump performance curves


See page 47 for dimensional data
15
VORTEX PUMPS
The VORTEX centrifugal pump offers proven Common applications include:
performance of the MAGNUM I adapted with a Pulp and paper
concentric vortex casing. The VORTEX also features Primary metals
identically sized suction and discharge flanges, and Municipal sewage treatment
a high performance vortex designed impeller. Chemical process industry

The vortex impeller produces a smooth hydraulic Available Sizes:


whirlpool of fluid in front of the impeller creating a 3x3x14
vacuum. Fluid circulates through the casing with 4x4x14
minimal fluid passing through the impeller. This 6x6x14
smooth action increases fluid velocity and pressure
while minimizing turbulence resulting in reduced
particle degradation. Solids smaller than the
discharge flow easily, without clogging.

The vortex design eliminates the eye of the impeller


reducing the possibility of vapor lock; making it an
excellent selection for high suction lift applications
where net positive suction head is low. Other benefits
of the vortex design include lower radial loads,
decreased shaft deflection and increased bearing life.
The vortex is designed to pump continuously. Even
when the suction runs dry the vortex pump can
re-prime without vapor locking and transfer fluid
once positive suction feed has been restored.

See pages 43-45 for pump performance curves


See page 48 for dimensional data

16
MISSIONTM PRODUCTS

MAGNUM XP PUMPS
The MAGNUM XP is ideally suited for pumping high Common applications include:
volumes of heavy slurries that are abrasive, corrosive, Sand slurry
or just plain tough to pump. The MAGNUM XP 8x6x18, Supply boat mud transfer
12x10x23 and 14x12x22 can deliver flow rates up to Slag
7500 GPM and head pressures up to 540 feet. Fly ash
Bottom ash
The compact overall dimensions of the MAGNUM XP Dredge tailings
make it an excellent choice for high volume mobile and Food processing
stationary applications where a small footprint is critical. Blending
Paper pulp processing
The MAGNUM XP is designed for continuous operation Waste slurries
with minimal maintenance. The low stuffing box pressure Sewage
and extra-heavy shaft design are engineered to provide Fluid supercharging
maximum seal life. The unique casing flow divider on the Spent liquor
12x10x23 and 14x12x22 cuts the radial load in half, Nickel shot
doubling bearing life. The heavy-duty bearings are Copper, bauxite, and quarry slurries
permanently lubricated to minimize maintenance. Lead and zinc ore and tailings

Available Sizes:
8X6X18
12x10x23
14x12x22

See pages 40-42 for pump performance curves


See page 50 for dimensional data

17
Magnum XP Parts List
Item # Description Qty. Base Part Number Processing Number Item # Description Qty. Base Part Number Processing Number
1 Casing, 14X12X22 1 24022-01-30A 651120206 25 Bearing, Outboard (14X12 ) 1 20616-2 658413307
Casing, 12x10x23 25008-01-30A 662001001 Bearing, Outboard (12X10 & 8X6) 2 661009001
Casing, 8x6x18 25289-02-30A 662002089 26 Seal, Bearing Cover 1 7496-267 658408802
2 Nut, Casing 32 3932-61 648402014 27 Lock Washer 1 6124-6 658407002
3 Stud, Casing (14X12 & 12X10) 32 3862-86 658403308 28 Lock Nut, Bearing 1 6123-6 658406509
Stud, Casing (8X6) 16 3862-90 601208285 29 Oil Seal, Bearing Cover 2 20619-04 658413638
Stud, Casing (8X6) 16 3862-92 648401118 30 Drive Screws 6 12530 601482417
4 Gasket, Casing (14x12x22) 2 10399-55-01 658410501 31 Nameplate 1 23017 601501505
Gasket, Casing (12x10x23) 25012-01-01 661010001 32 Shaft 1 24028-33 656420007
Gasket, Casing (8x6x18) 25012-02-05 662010032 33 Key, Coupling 1 4372-30-21 658405055
5 Cover, Front (14x12x22) 1 24021-01-30 654310309 34 Cover, Bearing O.B. 1 24033-01-01 654314004
Cover, Front (12x10x23) 25009-01-30 662014003 35 Bolts, Bearing Cover 2 3861-139 648401081
Cover, Front (8x6x18) 25291-02-30 662014129 36 Washer, Bearing Cover 2 3936-19-L8 648402030
6 Impeller, 14x12 Clockwise Rot. 22” 1 24024-X0-HS 662005003 37 Nuts, Bearing Housing 2 3932-62 658404702
Impeller, 12x10 Clockwise Rot. 23” 25010-Y0-30 662005002 38 Bolt, Bearing Housing 4 3861-138 648401057
Impeller, 8x6 Clockwise Rot. 18” 25292-T0-30 662005018 39 Washer, Flat 2 3936-19-L8 648402030
7 Seal, Impeller Nose 1 7496-158 658408109 40 Bolt, Packing Gland 2 3861-165 601408289
8 Key, Impeller 1 4372-29-21 658405006 41 Gland, Packing Half 2 24034-01-13 654315100
9 Nose, Impeller ( Hex Design) 1 24025-04-25L 652309601 42 Packing Set 1 8264-344-K 658409503
Nose, Impeller (Two Flat Design) 24025-01-25L 652309600 43 Screw, Cap 2 3909-04-87 658404207
Nose, Impeller (2 Flat Ion Nitride) 24025-03-25L 662014054 44 Plug, Grease 1 8505-1 601474695
10 Screw, Set 1 14430-19 658411400 45 Breather 1 8267-1 601473689
11 Jam Nut 1 24026-25L 658414255 46 Plug, Fitting 1 19368 661010020
12 Seal, Impeller 1 7496-153 658408059 58 Plug, Pipe 2 2/1/05 658409859
13 Mechanical Seal (Crane Type) 1 24036 658416102 59 Plug, Pipe 1 6/1/05 658410006
14 Stuffing Box, Mech. Seal (14X12) 1 24027-01-30 653322305 60 Tag, Mechanical Seal 1 22566 603445727
Stuffing Box, Mech. Seal (12X10) 24027-02-30 662014002 Packed Split-Box and Wearplate
Stuffing Box, Mech. Seal (8X6) 25290-02-30 662014128 47 Wearplate, Split Box 1 24023-01-XX 654310507
15 Bolt, Stuffing Box 2 3861-117 648401016 48 Packing Set 1 8264-345-K 658409552
16 Sleeve, Shaft 1 24029-21BZ 656422201 49 Nut and Washer Assembly 2 22216-02 658413935
17 Seal, Sleeve 1 7496-234 658408505 50 Bolt, Split-Box 2 3861-168 1/2-13x4 lg Gr 5
18 Slinger 1 24030-01-13 654311604 51 Stuffing Box, Split 2 24037-01-87 654317007
19 Seal, Slinger 1 7496-238P 658408554 52 Latern Ring Half 2 24039-13 658418207
20 Oil Seal, Inboard Bearing 2 20619-03 658413604 53 Fitting, Grease 1 19368-01 601499403
21 Bearing, Inboard 1 20615-2 658413000 54 Screw, Cap 2 3909-13-87 658404405
22 Frame 14X12 1 24031-01-01 654312008 Auxiliary Tools
Frame 12X10 24031-02-01 662014001 55 Tool, Impeller Nose & Nut 1 24040 658420203
Frame 8X6 25293-02-01 662014130 Tool, Impeller Nose (HEX) Standard Hex Socket
23 Housing, Bearing 1 24032-01-01 654313006 56 Tool, Impeller Removal 1 24041 658420252
18 24 Seal, Bearing Housing 1 7496-272 658408901 57 Tool, Shaft Holder 1 24042 658420302
MISSIONTM PRODUCTS

Shear Pumps

TurboShearTM System
National Oilwell’s TurboShearTM System reduces the
cost of mixing polymers and clays while improving
mud properties. Shearing the polymers eliminates
fish eyes and prevents polymer chaining (long
strings), which cannot pass through shaker screens.
Pre-hydrating clays improves viscosity per pound of
clay, reduces water loss and improves filter cake
properties. Additionally, the TurboShear System can
be used to dissolve salt and mix oil-base fluids.

Adding clays directly to an active mud system does


not result in mud properties equal to those achieved
with pre-hydration in a high shear system. When
clays are added to the active mud system, high shear
cannot be applied to the clays since degradation of
drill solids and barite will occur. Clay that has not
been properly hydrated when added to an active
mud system often continues to hydrate for several
days, during which the viscosity level increases.
Additional water to reduce viscosity may require
disposing of excess mud, which increases costs.
Hydrating clays and shearing polymers in a separate
compartment, prior to introduction to the active mud
system, ensures quality mud properties.

The TurboShear pump is available as a belt-driven or


diesel-driven package including a hopper, mud gun
and transfer line orifice plate. A complete system,
including skid, tanks and piping, is also available

The TurboShear System utilizes the following six


methods for shearing:
1. Fluid enters pump through the inlet ports and
impacts the shear plate.
2. Fluid passes through the teeth of the shear plate,
which is turning at 2200 RPM.
3. Fifty percent of the fluid is re-circulated through
the four nozzle scoops and is jetted through 44
nozzles against the shear plate and incoming fluid.
4. Liquid shear occurs at more than 5000 feet per
minute. The tip speed of the turbine is more than
7000 feet per minute, causing a liquid shear to
occur in addition to the mechanical shear.
5. Shearing occurs as the fluid is jetted into the
hydration tank through the mud gun at more than
6000 feet per minute.
6. The product is sheared between the fluid leaving
the nozzle and the venturi throat of the hopper.

Available Sizes:
6x5
8x6

19
Supreme Shear Pump
The industrial industry discovered that liquid shear
occurs between solids when the fluid speed exceeds
5,000 feet per minute. Therefore, an impeller size
and speed that produces an impeller tip speed over
5,000 feet per minute causes liquid shear.

When engineering the impeller vane curve, it was


designed so a solid particle will move straight out
with minimum contact with the impeller (at the pump’s
best efficiency point). When shearing solids is desired
it is beneficial to reverse this engineering practice.
Allowing the solids to drag across the impeller vane
causes a mechanical shear. To accomplish this the
pump output volume can be restricted to half its
best efficiency point. This makes the solids drag on
the face of the impeller vane. The Supreme Shear
pump features Tungsten Carbide chips adhered to
the face of the impeller to give a rough surface that
assists in the degradation of solids.

By controlling the impeller size and speed National


Oilwell can provide a Supreme Shear pump that
incorporates both the liquid and mechanical shear
techniques to reduce the size of solids.

The most common use for this application is shearing


drill cuttings and injecting them behind the intermediate
casing. Testing has shown that the drill cuttings can
be reduced to 50 micron by using the Supreme Shear
pump. Operating the pump at designed levels and
adding solids until the liquid has a range of 11-13 ppg
proves to be most effective. Operating less then
11 ppg does not provide enough solids for the liquid
shear to occur. Operating greater than 13 ppg
results in the material becoming too viscous.

20
MISSIONTM PRODUCTS

Pump Sizing Information

HOW TO SELECT YOUR PUMP


1. Before you size the pump, you need to know: 4. Formulas
1.1 The Pump Speed 4.1 To Convert Head in Feet to Pressure in Pounds Per
This depends on what kind of drive you put on the pump; Square Inch:
3500,1750 or 1150 RPM for 60 Hz motors and 3000,1500
or 1000 RPM for 50 Hz motors. Variable speed curves Feet of Head X Specific Gravity = PSIG
are provided for diesel, belt drive and hydraulic motors. 2.31
1.2 Total Head Required
The total head (TH) required is the summation of vertical 4.2 To convert Pressure in Pounds Per Square Inch (PSI) to
elevation (He) and friction head (Hf) plus the head Head in Feet:
required at the end of the piping. TH=He + Hf + head
required at of the end of piping. PSIG x 2.31 = Feet of Head
Specific Gravity
To calculate Friction Head loss SEE PAGE 23.
1.3 Flow Rate 4.3 Specific Gravity of Mud = Mud Weight (lbs/gal)
The flow requirement in GPM or cubic meters per hour. 8.34
1.4 The specific gravity of the fluid or the weight of the
fluid to be pumped such as the mud weight in ppg. 4.4 HP required = Curve HP x Specific Gravity
2. After obtaining the above information.
2.1 Find the required flow rate on the bottom or top scale 5. Pump Sizing Rules
and draw a straight line up or down. 5.1 Volume leaving pump increases until the volume
2.2 Find the total head at the left or right hand scale and pumped causes Total Head losses equal to its impeller
draw a straight line to the right or left. output head.
2.3 Locate the intersection of the above two lines and pick 5.2 It will help in the selection of impeller size if the friction
the nearest impeller size. Impellers are available in 1/4” loss curve is plotted on the pump curve.
increments. Also a set of horsepower lines gives you 5.3 Pressure or Head in Feet (meters)
the horsepower requirement for pumping water (It is When the pump is running pressure will build up. Pressure
best to choose a motor size larger than the minimum developed by the centrifugal pump is always specified as
required). If you pump fluid other than water, you have to Head in Feet liquid. The relation between PSI and head
adjust the required HP(kW) by multiplying the specific is shown in 4.1-4.2. When sizing centrifugal pumps it is
gravity to the HP (kW) rating based on water. crucial to work in feet of head rather than PSI. PSI varies
3. NPSH with the fluid weight while feet of head is a constant.
Net positive suction head is the useful pressure existing 5.4 Centrifugal Pump Rotation
at the suction flange of the pump to push water into the Stand at the drive end to determine the pump rotation.
impeller vanes. It is measured in feet (meters) of head. A right had rotation pump turns clockwise looking from
It is called NPSH Available (NPSHa). NPSH Required the motor end. All the pumps featured in this catalog
(NPSHr) is read from the pump curve at the designed are right hand rotation.
pump impeller, RPM, and flow rate. NPSH on the curve,
is the lowest NPSH that will prevent the formation of Conversion Factors:
vapor bubbles which cause cavitation.
To convert...........................into..........................multiply by
Most customers are not concerned about NPSH problems. m3/hr GPM 4.4
However over 50% of all rigs do have NPSH problems. m3/min GPM 264
These problems are due in part to high mud temperatures liters/min GPM 0.264
and poor suction design. You should check your net liters/sec GPM 15.9
positive suction head (NPSH). Barrels/day GPM 0.02917
cubic feet Gallons 7.481
NPSHa = Ha + He - Hf - Hvp kg/cm2 PSI 14.223
M3 Gallons 264
Where: meters Feet 3.28
NPSHa = NPSH Available Bars PSI 14.7
NPSHr = NPSH Required Kg/cm2 PSI 14.2
Ha = atmospheric head feet grams/cu. cm. SpGr. 1
He = elevation head feet (lowest possible liquid level
above or below pump center line) BHP = GPM X Feet X Sp.Gr.
Hf = Friction head feet (suction line friction losses) 3960 x Efficiency
Hvp = Vapor pressure of fluid at pumping temperature
SEE PAGE 26. kW = m3/hr x meters x Sp.Gr.
367 x Efficiency
The NPSHr as shown on the curves is the minimum NPSH
required by the pumps. If the NPSHa is greater then the Efficiency from curve written as .XX
NPSHr the pump will perform. If the NPSHa is less then
NPSHr then the pump will cavitate and some changes to
the suction conditions are necessary. Possible solutions
are reducing the flow rate, increasing the suction pipe
size, selecting a larger pump or lowering the pump speed.
21
Affinity Laws

If there is a known operating point and a different Example 2:


operating point is required the following algebraic If a system exists and a particular operating point
formulas can be used to accurately predict what and the elevation are known it is possible to calculate
changes should be made to alter the flow or head a new operating point by using the following friction
and what the resulting horsepower requirements loss formulas. Assume a system exists that has 20
will be. A pumps performance can be altered by feet of elevation and the pump is transferring water
changing the speed or by changing the impeller 500 GPM and the pressure gauge reads 50 PSI at
diameter. Note that while the speed formulas the pump discharge. What pressure head is required
are very reliable, the impeller diameter to produce 1000 GPM?
formulas are accurate only for small
variations in diameter. First convert PSI to feet

Speed Formulas or Impeller Diameter Formulas Pressure Head = 50 PSI * 2.31 / 1.0 Sp.Gr.
(Valid for small variations Pressure Head = 115 Feet
in dia. only, max 1”)
Flow: Subtract lift of 20 feet since this is a constant:
GPM1 = RPM1 or GPM1 = Dia1 115 feet pressure head – 20 feet elevation = 95 feet
GPM2 RPM2 GPM2 Dia2 of system friction loss at 500 GPM

Total Differential Head: Use the following formula to determine the new
TDH1 = RPM12 or TDH1 = Dia12 pressure head required to produce 1000 GPM in
TDH2 RPM22 TDH2 Dia22 this system:

Horsepower: Friction loss 1 = GPM12 or X = 10002


HP1 = RPM13 or HP1 = Dia13 Friction loss 2 GPM22 95 5002
HP2 RPM23 HP2 Dia23
or X = 95 (1000/500)2 = 380 Feet
Example 1:
An 8x6x14 pump with an 11” impeller is operating Add back the lift:
1000 GPM at 103 feet and requires 48 HP when 380 + 20 = 400
pumping water. A contractor wants to be able to
increase the discharge pressure to 115 feet. What It would therefore be necessary to size a pump for
will be the required impeller diameter, HP, and 1000 GPM at 400 feet to obtain the desired flow
resulting flow rate? rate of 1000 GPM in the existing system.

Answers:
____________ DIA
____________ GPM
____________ HP Required

New Imp Dia:


115 = X2 or 1.0566 * 11 = X or 11.62” = X
103 112

New Flow rate:


X = 11.62 or 1.056 * 1000 = X or 1056 GPM = X
1000 11

HP Required:
X = 11.623 or 48 * 1.177 = X or 56 HP = X
48 113

22
MISSIONTM PRODUCTS

SYSTEM HEAD REQUIREMENT WORK SHEET

CONDITIONS
Liquid Pumped _____________________ Flow Rate (GPM) ____________
Calculated Feet of Head _____________ (line “6”) Specific Gravity ____________ Temperature _________ º F

1. Suction: Pipe Size __________ inches.

(1a) Vertical Distance (liquid surface to pump center line +/-). Positive number if above pump center line or negative
number if below pump center line _______________ feet.

(1b) Total length of suction line _______________ feet.

(1c) Straight pipe equivalent of suction fittings:

Type Qty. Equiv. Ft. per Fitting Total Equiv. Ft.


(Ref. table on page 25) of Straight Pipe
Elbow ______ x _________________________ = _________________
Tee Running ______ x _________________________ = _________________
Tee Branched ______ x _________________________ = _________________
Swing Check ______ x _________________________ = _________________
Globe Valve ______ x _________________________ = _________________
Butterfly Valve ______ x _________________________ = _________________
(1c) Sum Total = _________________

(1d) Add (1b) and (1c) = _______________ equivalent feet of straight suction pipe.

(1e) Convert to friction loss head: (1d) x Head Loss (Ref. table on page 24) = ____feet of head (friction loss)
100

2. Discharge: Pipe Size __________ inches.

(2a) Vertical Distance (centerline of pump to highest point in discharge system +/-) _______ feet.

(2b) Total length of discharge line ______________ feet.

(2c) Straight pipe equivalent of discharge fittings:

Type Qty. Equiv. Ft. per Fitting Total Equiv. Ft.


(Ref. table on page 25) of Straight Pipe
Elbow ______ x _________________________ = _________________
Tee Running ______ x _________________________ = _________________
Tee Branched ______ x _________________________ = _________________
Swing Check ______ x _________________________ = _________________
Globe Valve ______ x _________________________ = _________________
Butterfly Valve ______ x _________________________ = _________________
_______________ ______ x _________________________ = _________________
(2c) Sum Total = _________________

(2d) Add (2b) and (2c) = _________________ equivalent feet of straight discharge pipe.

(2e) Convert to friction loss head: (2d) x Head Loss (Ref. table on page 24) = ____ feet of head (friction loss).
100

3. Pressure required at discharge point _____________ psig x 2.31 = ____________ feet of head.
Sp.Gr.
4. Total Friction Head (Hf) = (1e) + (2e) ___________

5. Total Elevation Head (He) = (2a) - (1a) ___________

6. Total Head Required at Pump Discharge = Hf + He + line “3” = ______________ feet of head required.1

1
NOTE: NPSHa must also be considered. See page 21 for NPSHa calculation method. 23
FRICTION OF WATER IN PIPES C=100
GPM V F V F V F V F V F V F GPM
2” PIPE 3” PIPE 4” PIPE 5” PIPE 6” PIPE 8” PIPE
30 3.06 3.69 1.36 0.53 0.77 0.13 30
40 4.08 6.40 1.81 0.91 1.02 0.22 40
50 5.11 9.90 2.27 1.38 1.28 0.34 0.82 0.11 50
60 6.13 13.40 2.72 1.92 1.53 0.48 0.98 0.16 60
70 7.15 17.04 3.18 2.56 1.79 0.63 1.14 0.21 0.79 0.09 70
80 8.17 22.50 3.63 3.28 2.04 0.81 1.31 0.27 0.91 0.11 80
90 9.19 28.00 4.08 4.08 2.30 1.01 1.47 0.34 1.02 0.14 90
100 10.21 35.80 4.54 4.96 2.55 1.22 1.63 0.41 1.14 0.17 100
125 12.76 50.90 5.68 7.50 3.19 1.85 2.04 0.62 1.42 0.26 125
150 15.32 76.00 6.81 10.50 3.83 2.59 2.47 0.87 1.70 0.36 0.96 0.09 150
175 17.86 92.50 7.95 14.00 4.47 3.44 2.86 1.16 1.99 0.48 1.12 0.12 175
200 20.40 129.00 9.08 17.90 5.10 4.41 3.27 1.49 2.27 0.61 1.28 0.15 200
225 10.20 22.30 5.74 5.48 3.68 1.85 2.55 0.76 1.44 0.19 225
250 11.30 27.10 6.38 6.67 4.08 2.25 2.84 0.93 1.60 0.23 250
275 12.50 32.30 7.02 7.96 4.50 2.68 3.12 1.11 1.76 0.27 275
300 13.60 37.90 7.65 9.34 4.90 3.13 3.41 1.30 1.91 0.32 300
350 15.90 50.40 8.93 12.40 5.72 4.20 3.97 1.73 2.23 0.43 350
400 18.20 64.60 10.20 15.90 6.54 5.38 4.54 2.21 2.55 0.55 400
450 11.50 19.80 7.36 6.68 5.10 2.75 2.87 0.68 450
500 12.80 24.10 8.18 8.12 5.68 3.34 3.19 0.82 500
550 14.00 28.70 8.99 9.69 6.24 3.99 3.51 0.98 550
600 15.30 33.70 9.81 11.40 6.81 4.68 3.82 1.15 600
650 16.60 39.10 10.60 13.20 7.38 5.43 4.15 1.34 650
700 17.90 44.90 11.40 15.10 7.94 6.23 4.47 1.53 700
750 18.90 51.30 12.30 17.20 8.51 7.08 4.78 1.74 750
800 13.10 19.40 9.08 7.98 5.10 1.97 800
900 14.70 24.10 10.20 9.92 5.74 2.44 900
1000 16.30 29.30 11.40 12.10 6.38 2.97 1000
1100 18.00 35.00 12.50 14.40 7.02 3.55 1100
1200 19.56 41.20 13.60 16.90 7.66 4.17 1200
1300 21.19 48.00 14.80 19.60 8.30 4.83 1300
1400 22.82 54.80 15.90 22.50 8.93 5.54 1400
1500 24.45 62.40 17.00 25.50 9.55 6.30 1500
1600 18.20 28.80 10.20 7.10 1600
1800 20.52 35.90 11.50 9.83 1800
2000 22.80 43.60 12.80 10.70 2000

V = Velocity feet per second


F = Friction head in feet
Loss of head in feet, due to friction, per 100 feet of ordinary pipe and velocity in feet per second.
Values taken from Williams & Hazen tables, based on coefficient C = 100. For new pipes multiply friction loss value by 0.70.

Values of C for various types of pipe are given below together with the corresponding multiplier which should apply to the tabulated values of the head loss, hf.

24
MISSIONTM PRODUCTS

Values of C
RANGE: High = Average Commonly
best, smooth, well laid value for used value
Low = good, clean for design
TYPE OF PIPE poor or corroded new pipe purposes
Cement - asbestos 160-140 150 140
Fibre - 150 140
Bitumastic-enamel-lined iron or steel centrifugally applied 160-130 148 140
Cement lined iron or steel centrifugally applied - 150 140
Copper, brass, lead, tin or glass pipe and tubing 150-120 140 130
Wood-stave 140-110 120 110
Welded and seamless steel 150-80 140 100
Continuous-interior riveted steel (no projecting rivets or joints) - 139 100
Wrought iron 150-80 130 100
Cast-iron 150-80 130 100
Tar-coated cast iron 145-80 130 100
Girth-riveted steel (projecting rivets in girth seams only) - 130 100
Concrete 152-85 120 100
Full-riveted steel (projecting rivets in girth and horizontal seams) - 115 100
Vitrified - 110 100
Spiral-riveted steel (flow with lap) - 110 100
Spiral-riveted steel (flow against lap) - 100 90
Corrugated steel - 60 60

Table Correction Multipliers


Value of C… 150 140 130 120 110 100 90 80 70 60
Multiplier to correct tables 0.47 0.54 0.63 0.71 0.84 1.00 1.22 1.58 1.93 2.57

Friction Loss in Pipe Fittings in Terms of Equivalent Feet of Straight Pipe


Gate Long Std. Std. Swing Angle Globe
valve radius tee tee check valve valve
Nominal Actual - 90º or - - Close valve - -
Pipe Inside full 90º 45º std. thru branch retun - full full full Butterfly
Size Diameter open elbow elbow flow flow bend open open open valve
1 1/2 1.61 1.07 4.03 2.15 2.68 8.05 6.71 13.4 20.1 45.6
2 2.067 1.38 5.17 2.76 3.45 10.3 8.61 17.2 25.8 58.6 7.75
2 1/2 2.469 1.65 6.17 3.29 4.12 12.3 10.3 20.6 30.9 70.0 9.26
3 3.068 2.04 7.67 4.09 5.11 15.3 12.8 25.5 38.4 86.9 11.5
4 4.026 2.68 10.1 5.37 6.71 20.1 16.8 33.6 50.3 114.0 15.1
5 5.047 3.36 12.6 6.73 8.41 25.2 21 42.1 63.1 143 18.9
6 6.065 4.04 15.2 8.09 10.1 30.3 25.3 50.5 75.8 172 22.7
8 7.981 5.32 20 10.6 13.3 39.9 33.3 58 99.8 226 29.9
10 10.02 6.68 25.1 13.4 16.7 50.1 41.8 65 125 284 29.2
12 11.938 7.96 29.8 15.9 19.9 59.7 49.7 72 149 338 34.8
14 13.124 8.75 32.8 17.5 21.8 65.6 54.7 90 164 372 38.3
16 15 10 37.5 20 25 75 62.5 101 188 425 31.3
18 16.876 16.9 42.2 22.5 28.1 84.4 70.3 120 210 478 35.2
20 18.814 12.5 47 25.1 31.4 94.1 78.4 132 235 533 39.2

Calculated from data in Crane Co. - Technical Paper 410


25
Properties of Water
Vapor
pressure
Temperature Temperature Specific of water,
Degrees - F Degrees - C Gravity absolute
40 4.4 1.001 0.30
50 10 1.001 0.40
60 15.6 1.000 0.60
70 21.1 0.999 0.80
80 26.7 0.998 1.20
90 32.2 0.996 1.60
100 37.8 0.994 2.20
110 43.3 0.992 3.00
120 48.9 0.990 4.00
130 54.4 0.987 5.20
140 60 0.985 6.80
150 65.6 0.982 8.80
160 71.1 0.979 11.20
170 76.7 0.975 14.20
180 82.2 0.972 17.90

Theoretical Discharge of Nozzles in U.S. Gallons Per Minute


Velocity
of
Head discharge Diameter of nozzle in inches
psi feet* ft/sec. 3/8 1/2 5/8 3/4 7/8 1 1 1/8 1 1/4 1 3/8 1 1/2 1 3/4 2 2 1/4 2 1/2 2 3/4 3 3 1/2 4
10 23.1 38.6 13.3 23.6 36.9 53.1 72.4 94.5 120 148 179 213 289 378 479 591 714 851 1158 1510
15 34.6 47.25 16.3 28.9 45.2 65.0 88.5 116.0 147 181 219 260 354 463 585 723 874 1041 1418 1850
20 46.2 54.55 18.8 33.4 52.2 75.1 102.0 134.0 169 209 253 301 409 535 676 835 1009 1203 1638 2135
25 57.7 61.00 21.0 37.3 58.3 84.0 114.0 149.0 189 234 283 336 458 598 756 934 1128 1345 1830 2385
30 69.3 66.85 23.0 40.9 63.9 92.0 125.0 164.0 207 256 309 368 501 655 828 1023 1236 1473 2005 2615
35 80.8 72.20 24.8 44.2 69.0 99.5 135.0 177.0 224 277 334 398 541 708 895 1106 1335 1591 2168 2825
40 92.4 77.20 26.6 47.3 73.8 106.0 145.0 188.0 239 296 357 425 578 756 957 1182 1428 1701 2315 3020
45 103.9 81.80 28.2 50.1 78.2 113.0 153.0 200.0 253 313 379 451 613 801 1015 1252 1512 1802 2455 3200
50 115.5 86.25 29.7 52.8 82.5 119.0 162.0 211.0 267 330 399 475 647 845 1070 1320 1595 1900 2590 3375
55 127.0 90.50 31.1 55.3 86.4 125.0 169.0 221.0 280 346 418 498 678 886 1121 1385 1671 1991 2710 3540
60 138.6 94.50 32.5 57.8 90.4 130.0 177.0 231.0 293 362 438 521 708 926 1172 1447 1748 2085 2835 3700
65 150.1 98.30 33.8 60.2 94.0 136.0 187.0 241.0 305 376 455 542 737 964 1220 1506 1819 2165 2950 3850
70 161.7 102.10 35.2 62.5 97.7 141.0 191.0 250.0 317 391 473 563 765 1001 1267 1565 1888 2250 3065 4000
75 173.2 105.70 36.4 64.7 101.0 146.0 198.0 259.0 327 404 489 582 792 1037 1310 1619 1955 2330 3170 4135
80 184.8 109.10 37.6 66.8 104.0 150.0 205.0 267.0 338 418 505 602 818 1070 1354 1672 2020 2405 3280 4270
85 196.3 112.50 38.8 68.9 108.0 155.0 211.0 276.0 349 431 521 620 844 1103 1395 1723 2080 2480 3375 4400
90 207.9 115.80 39.9 70.8 111.0 160.0 217.0 284.0 359 443 536 638 868 1136 1436 1773 2140 2550 3475 4530
95 219.4 119.00 41.0 72.8 114.0 164.0 223.0 292.0 369 456 551 656 892 1168 1476 1824 2200 2625 3570 4655
100 230.9 122.00 42.1 74.7 117.0 168.0 229.0 299.0 378 467 565 672 915 1196 1512 1870 2255 2690 3660 4775

The actual quantity discharged by a nozzle will be less than the above table. A well tapered smooth nozzle may be assumed to flow 97 to 99% of the values in the tables.
Mud gun nozzles will flow approximately 85% of the above table and hopper nozzles will flow approximately 75% of the above table.
*Head in feet basis water at approximately 60º F

26
MISSIONTM PRODUCTS

Pump Performance Curves

UNDERSTANDING PUMP
PERFORMANCE CURVES
The head vs. flow curves on the following pages give
you the performance of the Magnum, 2500 Supreme,
Magnum Vertical, 2500 Vertical and Sandmaster pumps
at various speeds and with various impeller sizes. The
horsepower (HP) rating is based on pumping water with
a specific gravity of 1.0. The flow is measured in US liquid
gallons per minute (GPM). The total differential head is
measured in feet. There are also a series of Efficiency
and Net Positive Suction Head Required (NPSHr) lines
showing the pump hydraulic efficiency and minimum
NPSHr. The performance curves are plotted based on
actual test results for each size of pumps running at
various RPM and with various impeller sizes.

To determine the HP required for your system you will


need to determine the Specific Gravity (Sp.Gr.) of the fluid
being transferred and then multiply the Sp.Gr. by the HP
shown on the curve. To determine Sp.Gr.:

Specific Gravity = ppg of fluid


8.34

27
28
MISSIONTM PRODUCTS

29
30
MISSIONTM PRODUCTS

31
32
MISSIONTM PRODUCTS

33
34
MISSIONTM PRODUCTS

35
36
MISSIONTM PRODUCTS

37
38
MISSIONTM PRODUCTS

39
40
MISSIONTM PRODUCTS

41
42
MISSIONTM PRODUCTS

43
44
MISSIONTM PRODUCTS

45
Dimensional Data

Magnum & 2500 Supreme Dimensions

PIPE FLANGES * SUCTION PIPE PIPE FLANGES * DISCHARGE PIPE


PUMP SIZE Wt. Lbs. SIZE DRILLING SIZE DRILLING A B E F G L P X Y Z CP DD
3 x 2 x 13 440 3 4 HOLES 3/4"DIA 6" B.C. 2 4 HOLES 3/4"DIA 4 3/4" B.C. 9 19 5/8 3 1/2 15 7/16 17 7/8 8 3/4 2 5/16 10 1/4 3 3/4 7 29 1/4 9
4 x 3 x 13 436 4 8 HOLES 3/4"DIA 7 1/2" B.C. 3 4 HOLES 3/4"DIA 6" B.C. 9 19 5/8 3 1/2 15 7/16 17 7/8 9 3/8 2 5/16 10 1/4 4 1/4 6 3/4 29 3/8 9
5 x 4 x 14 485 5 8 HOLES 7/8"DIA 8 1/2" B.C. 4 8 HOLES 3/4"DIA 7 1/2" B.C. 9 19 5/8 3 1/2 15 7/16 19 10 3/4 2 5/16 11 5 6 1/8 30 9 11/16
6 x 5 x 11 507 6 8 HOLES 7/8"DIA 9 1/2" B.C. 5 8 HOLES 7/8"DIA 8 1/2" B.C. 9 19 5/8 3 1/2 15 7/16 17 7/8 12 1/16 2 5/16 11 5 3/4 6 30 5/8 9
6 x 5 x 14 550 6 8 HOLES 7/8"DIA 9 1/2" B.C. 5 8 HOLES 7/8"DIA 8 1/2" B.C. 9 19 5/8 3 1/2 15 7/16 21 12 1/16 2 5/16 11 5 3/4 6 30 5/8 10 1/2
8 x 6 x 11 583 8 8 HOLES 7/8"DIA 11 3/4" B.C. 6 8 HOLES 7/8"DIA 9 1/2" B.C. 9 19 5/8 3 1/2 15 7/16 20 13 1/4 2 5/16 14 6 1/4 8 3/8 31 1/4 10
8 x 6 x 14 616 8 8 HOLES 7/8"DIA 11 3/4" B.C. 6 8 HOLES 7/8"DIA 9 1/2" B.C. 9 19 5/8 3 1/2 15 7/16 23 9/16 13 1/4 2 5/16 14 6 1/4 8 3/8 31 1/4 12
10 x 8 x 14 810 10 12 HOLES 1"DIA 14 1/4" B.C. 8 8 HOLES 7/8"DIA 11 3/4" B.C. 9 19 5/8 3 1/2 15 7/16 22 3/8 13 11/16 2 5/16 14 3/16 6 11/16 8 31 1/4 11 3/16

* THE ABOVE DRILLING IS ANSI STANDARD 125 lb. CAST IRON OR ANSI SERIES 150 STEEL FLAT FACE. ALL FLANGE HOLES ARE THRU CLEARANCE HOLES.

Magnum & 2500 Supreme OB Skid Unitization Dimensions

Pump Dimensions are in inches


Size CP X Y Z D
3X2X13 29-1/4 10-1/4 3-3/4 7 5-1/2
4X3X13 29-3/8 10-1/4 4-1/4 6-3/4 6-1/8
5X4X14 30 11 5 6-1/8 7-1/2
6X5X11 30-5/8 11 5-3/4 6 8-3/4
6X5X14 30-5/8 11 5-3/4 6 8-3/4
8X6X11 31-1/4 14 6-1/4 8-3/8 10
8X6X14 31-1/4 14 6-1/4 8-3/8 10
10X8X14 31-1/4 14-3/16 6-11/16 8 10.5

MOTOR DIMENSIONS ARE IN INCHES


FRAMES BASE HA HB HC HD HE HG C SP* AB**
182T-215T OB-7 19 49-1/2 33-1/2 8 17-1/4 15 19 1 10.25
254T-286T OB-1 19 55 39 8 17-1/4 15 27-1/2 1 13.25
324T-365T OB-2 26 61 45 8 24-1/4 15 33-1/2 1 18.8
404T-405T OB-3 26 66 50 8 24-1/4 16 38-1/2 1 20.5
444T-445T OB-4 30 72 56 8 28-1/4 17 44-1/2 1 26.25

* Unless spacer coupling is utilized.


** Approximate maximum to outside of conduit box
Tolerences +/- 1/8”
46 NOTE: Dimensions are for reference only. Certified drawings should be requested for construction purposes.
MISSIONTM PRODUCTS

Sandmaster Dimensions

PIPE FLANGES * SUCTION PIPE PIPE FLANGES * DISCHARGE PIPE


PUMP SIZE Wt. Lbs. SIZE DRILLING SIZE DRILLING A B E F G L P X Y Z CP DD
3 x 2 x 13 475 3 4 HOLES 3/4" DIA. 6" B.C. 2 4 HOLES 3/4" DIA. 4 3/4" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 17 7/8 10 7/16 4 10 1/4 3 3/4 7 25 1/16 8 15/16
4 x 3 x 13 491 4 8 HOLES 3/4" DIA. 7 1/2" B.C. 3 4 HOLES 3/4" DIA. 6" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 17 7/8 11 1/16 4 10 1/4 4 1/4 6 3/4 25 1/8 8 15/16
5 x 4 x 14 520 5 8 HOLES 7/8" DIA. 8 1/2" B.C. 4 8 HOLES 3/4" DIA. 7 1/2" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 19 12 7/16 4 11 5 6 1/8 25 13/16 9 1/2
6 x 5 x 11 550 6 8 HOLES 7/8" DIA. 9 1/2" B.C. 5 8 HOLES 7/8" DIA. 8 1/2" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 17 7/8 13 3/4 4 11 5 3/4 6 26 3/8 8 15/16
6 x 5 x 14 609 6 8 HOLES 7/8" DIA. 9 1/2" B.C. 5 8 HOLES 7/8" DIA. 8 1/2" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 21 13 3/4 4 11 5 3/4 6 26 3/8 10 1/2
8 x 6 x 11 659 8 8 HOLES 7/8" DIA. 11 3/4" B.C. 6 8 HOLES 7/8" DIA. 9 1/2" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 20 14 15/16 4 14 6 1/4 8 3/8 27 1/16 10
8 x 6 x 14 701 8 8 HOLES 7/8" DIA. 11 3/4" B.C. 6 8 HOLES 7/8" DIA. 9 1/2" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 23 9/16 14 15/16 4 14 6 1/4 8 3/8 27 1/16 11 13/16
10 x 8 x 14 705 10 12 HOLES 1" DIA. 14 1/4" B.C. 8 8 HOLES 7/8" DIA. 11 3/4" B.C. 15 1/4 17 3/4 6 9/16 11 1/4 22 3/8 15 3/8 4 14 3/16 6 11/16 8 27 1/16 11 3/16

* THE ABOVE DRILLING IS ANSI STANDARD 125 lb. CAST IRON OR ANSI SERIES 150 STEEL FLAT FACE. ALL FLANGE HOLES ARE THRU CLEARANCE HOLES.

47
Vortex Dimensions

PIPE FLANGES * DISCHARGE PIPE PIPE FLANGES * SUCTION PIPE


PUMP SIZE Wt. Lbs. SIZE DRILLING SIZE DRILLING A B E F G L P X Y Z CP DD
3x3 505 3 4 HOLES 3/4"DIA 6" B.C. 3 4 HOLES 3/4"DIA 6" B.C. 9 19 7/16 3 1/2 15 7/16 19 13 15/16 2 5/16 11 6 1/4 7 1/4 32 9 1/2
4x4 566 4 8 HOLES 3/4"DIA 7 1/2" B.C. 3 8 HOLES 3/4"DIA 7 1/2" B.C. 9 19 7/16 3 1/2 15 7/16 20 15 2 5/16 11 7/8 6 7/16 7 1/4 32 13/16 10
6x6 618 6 8 HOLES 7/8"DIA 9 1/2" B.C. 6 8 HOLES 7/8"DIA 9 1/2" B.C. 9 19 7/16 3 1/2 15 7/16 22 17 3/4 2 5/16 13 7/8 7 13/16 7 1/4 34 3/16 11

* THE ABOVE DRILLING IS ANSI STANDARD 125 lb. CAST IRON OR ANSI SERIES 150 STEEL FLAT FACE. ALL FLANGE HOLES ARE THRU CLEARANCE HOLES.

Piping Flanges* Dimensions In Inches


Discharge Pipe Suction Pipe
Pump Size Size Drilling Size Drilling K L M N O
3x3 3 4 Holes 3/4 D-6 B.C. 3 4 Holes 3/4 D-6 B.C. 7 11/16 32 7 1/4 11 6 1/4
4x4 4 8 Holes 3/4 D-7 1/2 B.C. 4 8 Holes 3/4 D-7 1/2 B.C. 8 9/16 33 1/4 7 1/4 11 7/8 6 7/16
6x6 6 8 Holes 7/8 D-9 1/2 B.C. 6 8 Holes 7/8 D-9 1/2 B.C. 9 15/16 34 1/4 7 1/4 13 7/8 7 9/16

* The above drilling is ANSI standard 125lb. cast iron or ANSI series 150 flat face steel flange.

Motor Frame Base No. A B C D E F


143T 15901-3 12 15/16 16 9/16 7 3/4 7 15/16 6 1/2 13 1/4
145T 15901-3 12 15/16 16 9/16 7 3/4 7 15/16 7 14 1/4
182T 15901-3 12 15/16 17 9/16 9 3/8 7 1/4 7 3/4 14 9/16
184T 15901-3 12 15/16 17 9/16 9 3/8 7 1/4 8 1/4 15 9/16
213T 15901-3 12 15/16 18 7/16 11 9 1/4 9 5/8 17 7/8
215T 15901-3 12 15/16 18 7/16 11 9 1/4 10 3/8 19 7/16
254T 15901-3 12 15/16 19 7/16 13 10 1/2 12 3/8 22 3/4
256T 15901-3 12 15/16 19 7/16 13 10 1/2 13 1/4 24 9/16
284T 15901-3 12 15/16 20 5/32 14 1/2 12 5/16 14 1/8 26 5/8
284TS 15901-3 12 15/16 20 5/32 14 1/2 12 5/16 12 3/4 25 1/4
286T 15901-3 12 15/16 20 5/32 14 1/2 12 5/16 14 7/8 28 1/8
286TS 15901-3 12 15/16 20 5/32 14 1/2 12 5/16 13 1/2 26 3/4
324T 15901-3 12 15/16 21 3/8 16 7/8 14 7/16 15 3/4 28 15/16
324TS 15901-3 12 15/16 21 3/8 16 7/8 14 7/16 14 1/4 28 1/8
326T 15901-3 12 15/16 21 3/8 16 7/8 14 7/16 16 1/2 31 1/8
48
326TS 15901-3 12 15/16 21 3/8 16 7/8 14 7/16 15 29 5/8
MISSIONTM PRODUCTS

Vertical Magnum Dimensions

Vortex
Motor Frames AB AG CP P Motor Wt.
3x3x14 4x4x14 6x6x14
213P 9 20 61 65 65 11 310
215P 9 20 61 65 65 11 360
254P 10 1/2 24 66 69 69 13 1/4 380
256P 10 1/2 24 66 69 69 13 1/4 410
284P 13 26 3/4 67 71 71 14 620
286P 13 26 3/4 67 71 71 14 640
324P 14 1/4 29 71 74 74 17 885
326P 14 1/4 29 71 74 74 17 910
364P 15 31 73 76 76 18 1200
365P 15 31 73 76 76 18 1470
Assembled unit weight 825 855 965
less motor – pounds

Vortex
Pipe Flanges Dimensions In Inches
Suction Pipe Discharge Pipe
Pump Size Size Bolt Pattern Size Bolt Pattern A E G VD VS VY X Z
3x3x14 3 4 Holes 3/4 D-6 B.C. 3 4 Holes 3/4 D-4 3/4 B.C. 22 1/2D 5 5/16 1 27 3/4 16 1/4 7 1/4 11 7 1/4
4x4x14 4 8 Holes 3/4 D-7 1/2 B.C. 4 8 Holes 3/4 D-7 1/2 B.C. 22 1/2D 5 5/16 1 27 3/4 16 3/16 9 11 7 1/4
6x6x14 6 8 Holes 7/8 D-9 1/2 B.C. 6 8 Holes 7/8 D-9 1/2 B.C. 22 1/2D 5 5/16 1 29 1/2 21 13/16 9 1/2 13 7 1/4

Magnum
Motor Frames AB AG CP P Motor Wt.
3x2x13 4x3x13 5x4x14 6x5x11 6x5x14 8x6x11 8x6x14
213P 9 20 56 57 58 59 3/4 59 3/4 60 60 11 310
215P 9 20 56 57 58 59 3/4 59 3/4 60 60 11 360
254P 10 1/2 24 60 61 62 64 64 65 65 13 1/4 380
256P 10 1/2 24 60 61 62 64 64 65 65 13 1/4 410
284P 13 26 3/4 62 3/4 63 64 3/4 66 66 67 1/4 67 1/4 14 620
286P 13 26 3/4 62 3/4 63 64 3/4 66 66 67 1/4 67 1/4 14 640
324P 14 1/4 29 65 66 67 69 69 70 70 17 885
326P 14 1/4 29 65 66 67 69 69 70 70 17 910
364P 15 31 67 68 69 71 71 71 72 18 1200
365P 15 31 67 68 69 71 71 71 72 18 1470
Assembled unit weight 800 820 855 885 925 960 990
less motor – pounds

Magnum
Pipe Flanges Dimensions In Inches
Suction Pipe Discharge Pipe
Pump Size Size Bolt Pattern Size Bolt Pattern A E G VD VS VY X Z
3x2x13 3 4 Holes 3/4 D-6 B.C. 2 4 Holes 3/4 D-4 3/4 B.C. 22 1/2D 5 5/16 1 25 1/4 13 3/4 7 1/4 10 1/4 7
4x3x13 4 8 Holes 3/4 D-7 1/2 B.C. 3 8 Holes 3/4 D-6 B.C. 22 1/2D 5 5/16 1 25 3/4 14 9 10 1/4 6 3/4
5x4x14 5 8 Holes 7/8 D-8 1/2 B.C. 4 8 Holes 7/8 D-7 1/2 B.C. 22 1/2D 5 5/16 1 26 1/2 16 1/4 8 1/2 11 6 1/8
6x5x11 6 8 Holes 7/8 D-9 1/2 B.C. 5 8 Holes 7/8 D-8 1/2 B.C. 22 1/2D 5 5/16 1 26 1/4 18 9 1/2 11 6
6x5x14 6 8 Holes 7/8 D-9 1/2 B.C. 5 8 Holes 7/8 D-8 1/2 B.C. 22 1/2D 5 5/16 1 26 1/4 18 9 1/2 11 6
8x6x11 8 8 Holes 7/8 D-11 3/4 B.C. 6 8 Holes 7/8 D-9 1/2 B.C. 22 1/2D 5 5/16 1 26 3/4 21 14 14 8 49
8x6x14 8 8 Holes 7/8 D-11 3/4 B.C. 6 8 Holes 7/8 D-9 1/2 B.C. 22 1/2D 5 5/16 1 26 3/4 21 14 14 8 3/8
Magnum XP Dimensions

PIPE FLANGES* SUCTION PIPE PIPE FLANGES* DISCHARGE PIPE


PUMP SIZE Wt. Lbs. SIZE DRILLING SIZE DRILLING A E G L X Y Z CP DD
8 x 6 XP 1,200 8 12 HOLES 7/8" -9UNC-2B 13" B.C. 6 12 HOLES 7/8" DIA. 10 5/8" B.C. 16 13/32 6 7/8 25 1/4 16 1/32 16 5 5/32 10 19/32 30 13/32 12 7/16
12 x 10 XP 1,950 12 12 HOLES 3/4" -10UNC-2B 17" B.C. 10 12 HOLES 1" DIA. 14 1/4" B.C. 16 13/32 6 7/8 33 5/8 18 11/16 22 6 15/16 13 1/2 31 1/2 16 13/16
14 x 12 XP 1,850 14 12 HOLES 1" -8UNC-2B 18 3/4" B.C. 12 1 16 13/32 6 7/8 37 3/4 18 3/8 19 7/16 6 5/8 14 9/16 31 3/16 18 13/16

* THE ABOVE DRILLING IS ANSI STANDARD 150 SERIES FLAT FACE EXCEPT THE 8 X 6 XP IS ANSI 300 SERIES FLAT FACE. ALL DISCHARGE FLANGE HOLES ARE THRU CLEARANCE HOLES EXCEPT AS NOTED.

1 THE DISCHARGE FLANGE DRILLING FOR THE 14 X 12 XP HAS 12 HOLES, 10 HOLES THRU 1" DIA. & 2 HOLES TAPPED 7/8 -9UNC-2B AS SHOWN, ON A 17" DIA. B.C.

50
MISSIONTM PRODUCTS

Electric Motor Dimensions

Average values of full load


amperes at motor terminals

Three phase A-C induction type


squirrel cage and wound motor

Motor HP 230 Volts 460 Volts 575 Volts


1 3.60 1.80 1.40
1 1/2 5.20 2.60 2.10
2 6.80 3.40 2.70
3 9.60 4.80 3.90
5 15.20 7.60 6.10
7 1/2 22.00 11.00 9.00
10 28.00 14.00 11.00
15 42.00 21.00 17.00 Electric Motor Approximate Dimensions
20 54.00 27.00 22.00 Frame D E 2F H U N-W AA BA
25 68.00 34.00 27.00 143T 3.50 2.75 4.00 .34 .875 2.25 3/4 2.25
30 80.00 40.00 32.00 145T 3.50 2.75 5.00 .34 .875 2.25 3/4 2.25
40 104.00 52.00 41.00 182T 4.50 3.75 4.50 .41 1.125 2.75 3/4 2.75
50 130.00 65.00 52.00 184T 4.50 3.75 5.50 .41 1.125 2.75 3/4 2.75
60 154.00 77.00 62.00 213T 5.25 4.25 5.50 .41 1.375 3.38 1 3.50
75 192.00 96.00 77.00 215T 5.25 4.25 7.00 .41 1.375 3.38 1 3.50
100 240.00 120.00 96.00 254T 6.25 5.00 8.25 .53 1.625 4.00 1-1/4 4.25
125 296.00 148.00 118.00 256T 6.25 5.00 10.00 .53 1.625 4.00 1-1/4 4.25
284T 7.00 5.50 9.50 .53 1.875 4.62 1-1/2 4.75
284TS 7.00 5.50 9.50 .53 1.625 3.25 1-1/2 4.75
286T 7.00 5.50 11.00 .53 1.875 4.62 1-1/2 4.75
286TS 7.00 5.50 11.00 .53 1.625 3.25 1-1/2 4.75
324T 8.00 6.25 10.50 .66 2.125 5.25 2 5.25
324TS 8.00 6.25 10.50 .66 1.875 3.75 2 5.25
326T 8.00 6.25 12.00 .66 2.125 5.25 2 5.25
326TS 8.00 6.25 12.00 .66 1.875 3.75 2 5.25
364T 9.00 7.00 11.25 .66 2.375 5.88 2-1/2 5.88
364TS 9.00 7.00 11.25 .66 1.875 3.75 2-1/2 5.88
365T 9.00 7.00 12.25 .66 2.375 5.88 2-1/2 5.88
365TS 9.00 7.00 12.25 .66 1.875 3.75 2-1/2 5.88
404T 10.00 8.00 12.25 .81 2.875 7.25 3 6.62
404TS 10.00 8.00 12.25 .81 2.125 4.25 3 6.62
405T 10.00 8.00 13.75 .81 2.875 7.25 3 6.62
405TS 10.00 8.00 13.75 .81 2.125 4.25 3 6.62
444T 11.00 9.00 14.50 .81 3.375 8.50 3 7.50
444TS 11.00 9.00 14.50 .81 2.375 4.75 3 7.50
445T 11.00 9.00 16.50 .81 3.375 8.50 3 7.50
445TS 11.00 9.00 16.50 .81 2.375 4.75 3 7.50
447T 11.00 9.00 20.00 .81 3.375 8.50 3 7.50
449T 11.00 9.00 25.00 .81 3.375 8.50 3 7.50

AB, O, P and C dimensions vary by motor rating. Contact National Oilwell for these dimensions.
Dimensions vary for each motor manufacturer. All dimensions are approximate.

51
Piping Recommendations

52
MISSIONTM PRODUCTS

53
Related Equipment

Associated Products Manufactured


and Distributed by National Oilwell.
EnviroHopperTM
Dust Collecting

Custom Design Brake/Winch


Cooling Systems

4” & 6” Mud Hoppers

Fire Suppression Systems

54
MISSIONTM PRODUCTS

IEC Explosion Proof Diesel Fuel


Motor Controls Filtration Systems

Explosion Proof Electric Motors

Low Pressure
Mud Guns

High Pressure
Washdown Systems

Potable/Sanitary
Water Pressure Sets

55
Close Coupled Centrifugal Pumps

National Oilwell manufactures compact close


coupled centrifugal pumps for the 1180, Magnum
and 2500 Supreme pump families.

1180 SpaceSaver® Centrifugal Pumps


National Oilwell’s line of Mission SpaceSaver Type “S”
pumps have a very small footprint for applications
where space is a premium. These heavy duty pumps
require minimum mounting space and are close
coupled eliminating couplings and coupling alignment
considerations.

The SpaceSaver pump line has been proven in mud


pump liner coolant service, general rig water supply,
micro-tunneling mud mixing and a variety of
additional applications.

Explosion proof 50 and 60 HZ motors are maintained


in stock ranging from 2 to 10 HP.

Close Coupled Magnum and 2500


Supreme
National Oilwell continues to provide new product
design to fulfill customer needs. Close coupled Magnum
and 2500 Supreme pumps utilize the same fluid end
and perform identically to the standard Magnum and
2500 Supreme. The close coupled adapter bolts
directly onto the motor frame and the impeller
attaches to the motor shaft. This configuration
eliminates the need for a large base, coupling,
coupling guard and alignment considerations.
This configuration reduces weight and requires the
minimum cubic space of any other configuration.

56
MISSIONTM PRODUCTS

Conversion Table
Multiply By To Obtain
Atmospheres 1.01325 Bars
Atmospheres 33.9 Feet of water
Atmospheres 14.7 Lbs / sq. inch
Bars 0.98692 Atmospheres
Bars 1.0197 kg / cm2
Bars 14.7 PSI
Barrels - oil 42 Gallons - oil
Barrels (42 U.S. gal) / day 0.02917 GPM
BTU 3.927 x 104 Horsepowers - hrs.
Centimeters 0.3937 Inches
Cubic cm / sec 0.0158502 GPM
Cubic feet 0.02832 Cubic meters
Cubic feet / sec. 448.831 GPM
Cubic Inches 4.329 x 10-3 Gallons
Cubic meters / hr 4.4033 GPM
Cubic meters / min 264 GPM
Feet 0.3048 Meters
Feet of head Specific Gravity ÷ 2.31 PSI
Feet of Water 0.0295 Atmospheres
Foot - pounds 5.050 x 10-7 Horsepower hrs.
Gallons 3785 Cubic centimeters
Gallons 0.1337 Cubic feet
Gallons 231 Cubic inches
Gallons 3.785 Liters
Pints 8 Gallons
Quarts 4 Gallons
Gallons - Imperial 1.20095 U.S. gallons
Gallons water 8.34 Pounds of water
Gallons / hour 0.016667 GPM
GPM 34.286 Barrels (42 u.s. gal.) / day
GPM 1.4286 Barrels (42 u.s. gal.) / hr.
GPM 0.2272 m3 / hr
GPM 1440 Gallons / day
GPM 3.7878 Liters / min
grams/cu. cm. 1 Sp.Gr.
Horsepower hrs. 2546 B.T.U.
Horsepower hrs. 1.98 x 106 Foot - lbs.
Kilograms / cm2 14.223 PSI
Kilograms / sq. meter 1.422 x 10-3 PSI
Kilopascal 0.145 PSI
Kilowatts 1.341 Horsepower (U.S.)
Kilowatt hours 3414.4 B.T.U.
Liters/min 0.2642 GPM
Liters/sec 15.9 GPM
Meters 3.28 Feet
Miles 5280 Feet
Miles / hr 1.609 Kilometers / hr.
Miles / hr 0.8689 Knots
Millimeters 0.03937 Inches
PSI 0.06895 Bars
PSI 0.070307 kg / cm2
PSI 6.895 Kilopascals
Drilling Solutions
National Oilwell International Locations
Sales & Service Locations
Australia
Mailing Address 21 Mine Street
P.O. Box 4638, Houston, TX 77210 Redbank, QLD 4301, Australia
Phone: 713-462-4110 Phone: 61-7-3280-2800
Fax: 713-937-7151 Fax: 61-7-3280-2899

Customer Service Centers Brazil


Rua Prefeito
Lifting and Handling
Corporate Headquarters Alice, TX Aristeu Ferreira da Silva no.70
Phone: 361-664-9572 Novo Cavaleiros
10000 Richmond Ave. Fax: 361-664-8991 Macae, Roe de Janeiro
Houston, TX 77042 USA Brazil
Phone: 713-346-7500 Casper, WY Phone: 55-222-773-5401
Fax: 713-346-7959 Phone: 307-235-2751
Fax: 307-235-9003 Dubai
P.O. Box 61490, RA/08-TA06
Edmonton, Canada Jebel Ali Free Zone, Dubai, U.A.E.
Phone: 780-414-2100 Phone: 971-4-833-8776
Fax: 780-944-3980 Fax: 971-4-883-8795 Well Service and Completion Solutions

Houston, TX Germany
Phone: 713-462-4110 Eddesser Strabe 1
Fax: 281-517-0340 Postfach 31232
Edemissen-Berkhopen
Kilgore, TX Germany
Phone: 903-983-3531 Phone: 49-5176 90326
Fax: 903-983-5212 Fax: 49-5176 90532

New Iberia, LA Indonesia Downhole Solutions


Phone: 337-365-2582 Jakarta Stock Exchange Building
Fax: 337-365-0120 Jalen Jend. Sudirman Kav. 52-53
Jakarta 12190
Odessa, TX Indonesia
Phone: 915-368-0014 Phone: 62-21-515-9886
Fax: 915-368-0171
Netherlands
Oklahoma City, OK Gooiland 12
Phone: 405-670-8771 1948 RC Beverwijk, The Netherlands
Fax: 405-670-8775 Phone: 31-251-240504 Production Solutions
Fax: 31-251-240954
Singapore
30 Tuas Basin Link Norway
Singapore 638786 Lagerveien 8, P.O. Box 8181
Phone: 65-861-1566 4069 Stavanger, Norway
Fax: 65-861-0796 Phone: 47-51-818181
Fax: 47-51-800547
For your nearest
National Oilwell Distributor, Russia
call 1- 800-800-4110 Novukuznetskaya Supply Chain Management
(within United States) Street 11, Suite 311
or 713- 462-4110 Moscow 113184
(outside of United States) Phone: 7502-225-1930

Scotland
Badentoy Road
Badentoy Industrial Park, Portlethen
Aberdeen, Scotland AB12 4YA, UK
Phone: 44-1224-783060
Fax: 44-1224-783266 Engineering and Project Management

Venezuela
Avenida 4, Bella Vista
Entre Calles 75 y 76
Torre Ejectiva, Piso 6
Maracaibo, Edo. Zulia, Venezuela
Phone: 58-261-7933636
Fax: 58-261-7933025

© Copyright - National Oilwell 2003 5M


w w w . n a t o i l . c o m 0001-0567-90 REV A.

mission.cp@natoil.com

You might also like