Professional Documents
Culture Documents
Designofreinforc00burk PDF
Designofreinforc00burk PDF
AT 573
THE DESIGN OF A REINFORCED
'^
CONCRETE CHIMNEY
A THESIS
PRESENTED BY
S. J. BURKE
TO THE
PRESIDENT AND FACULTY
OF
BACHELOR OF SCIENCE
IN
CIVIL ENGINEERING
JUNE 2, 1921
APPROVED
OF TECHNOLOGY
ILLINOIS INSTITUTE
PAUL V.GALVIN LIBRARY
35 WEST 33RD STREET
CHICAGO, IL 60616
^ //^,
Dean of Cnltural Studies
Digitized by the Internet Archive
in 2009 with funding from
CARLI: Consortium of Academic and Research Libraries in Illinois
http://www.archive.org/details/designofreinforcOOburk
}0 ~J >->.-'
page.
Introduction 1
Foundation 34
Estimate of cost 30
Lining 34
33B40
IM)BBTEDNBSS
INTHDUOTIQN .
screenings.
same.
face to grate surface 50:1, flue 100* long with two right
33479 B.T.U.
NOTATION
nature of the fuel and the air excess used in burning the
fuel.
^
Therefore Dc - 0.085 Pc x T
F" Tc
Assuming Pa.= P - 14.7 and T=r 492 equation (2) reduces to;
"320 lOlO
high.
boiler room.
the top. Plue opening will be made 12' -0" high by 5'-0"
GENERAL PaSGRIPTIQIL
house.
NOTATION
tance";
at lee side;
windward side;
of concrete.
VBETICAL HBINgQRCEMEHT
projected area.
this section.
height.
¥=1 h (B^b/-/Sb )
3
1 hr:25»
3
e _ 43 = .69
r- "52:4
P - As- 5.5 ^
~ .00197
I "2880
top.
1 h _ 125-41.66*
3 " 3 "
1,830,000 x 12=21,950,000"!
e= M, 21.950.000"!^ - 61.2"
f- 359;o00f
Since the resultant force falls far outside of the kern of the
r=(6.28-.371)12=: 70.91"
where 6,28 is outer radius, .371 is half the thickness of the
shell in feet.
e - 61.2 -.863
r"''^7^1
With f ^ and is limited to 500# per square inch, and 15,000^ per
The from the diagram figure 5 with m^3.32 and _e -.863; p will
equal .002,fs/fo=18
J3
J^
is 5'-0" wide.
considered).
V'= 1 h (B^-h-*-/Bb)
3 -
B^Tzr*-- 3.1416 x 7.08-157 square feet
Y=l h (B+h+/^)
3 e
B=77 r^ -3.1416 X 6.21 =121.2 square feet
IS
W=3780 X 150^566,000#
The outer dianeter of the average section ahove the
e= M -. 46,100.000 - 81.4"
W 556,000
(The amount of material taken out for the flue v/ill be ap-
• m = 500 -4.0
T25"
Therefore with m^4.0, e=1.03, p^ .0025 f s /fc=27.0
f^=27 X 500-13500
A5=Ap:^.0025 X 4527=11.4
These values are O.K. Use 30, 5/8" square rods A^-11.7
16
values are taken the same as at the section 175 ft. from
f 5=440 X 27^11,190
Since these values are fairly high the same amount
top.
To investigate the amount of reinforcement neces-
14.92».
1 h ^200366.66'
3 3
V 1 h (Bf b^/^)
3
e^ M , 62.250.000 -84.7"
W 734,000
ra = 500^4.0
T25
Then from the diagram #5, p-.0025 l^ I fc-27.
is Q^.Y^,
A5''Ap-.0025 X 5875.2-14.7
Using 3/4 inch square rods, the numher required is 27.
If
NQTATIQH
HQRIZOMTAL PLgllMJHGBIlEI^
fc=-T K Ee mo fs^T K Ss ms
The values m^ & msare multipliers which depend on the
the chimney they are cooled. The lower part of the chimney
and outer shell of the chimney will not be greater than 200
degrees Fahrenheit.
The center of the steel is placed 3" from the outer sur-
fc=407,which is O.K.
f^^T K Es ms
^5 = 30,000,000 pounds per square inch.
Ha 6.285 - 1.13
The rods will "be placed 3" from the edge of the concrete.
kt- 3 - .337
fc=T K Eo mo
f^=200 X .000006 X 2,000,000 x .16 fc=384'^
fs=T K S^ ms
The rods will "be placed 2i- inches from the edge of the con-
crete.
fs = T K E5 nis
The percentage
^ of steel is .1964 =.00436
9 X 5.00
The hoops will be placed 2" from the edge of the concrete.
k»rr2 = .4
NOTATION
The base will be made a square 34* x 34*. The diagonal dis-
Since these valije s are not excessive the base will be con-
OOMPUTATIUN OF WEIGHT.
p= „ M
p- 1.545.000 - .0015
16000 x .87 X 12 X 80^
will be ^
"^
734.000 --. 15. 5#. As this value is well with-
562 X 84
ESTIMTE OF COST.
cubic yards.
598 barrels.
Vertical steel.
approximately 125* from the top. Used 22, 5/8" square rods.
approximately 175* from the top. Used 30, 5/8" square rods.
HORIZOIWAL RSINFOROmiSNT
F0U1€)ATI0N STEEL
rods is 68.
round rods.
FQIM)ATION
LINING
Labor $200.00
MISGBLLANEOIB
Pulley 35.00
Forms 180.00
Scaffold 200.00
Tool§,etc., 25.00
THE LINING-
crete from the excessive heat of the gases, that are just
•^mm mmm^m^mt
,
J-?-
34- S ^oiJ^c>Hoo3
I
^.l>.^>»^>.^>>/J^JJ^JJJ^ JJ JJJJ-WrF.7^
75-0
ms,/S'6LOA/^
\zO_
THESIS
/es/gn ofc^ r\e.tnforce.J
A/^A^OUa /A/ST/TUT£ i
1
^^t^w*
jT