Professional Documents
Culture Documents
ROTARY KILN
According to DTS Doc No: "XXX-000-V-00-A"
Plant : "Name of the plant" Revision: "A"
Item : "XXX-000-V-00-A" Date: "02/10/2009"
All units are given in SI (metric) system All cells must be filled with a
Lines indicated "X" must be filled at tender phase value, use of N/A if needed
Designation Units Data
1 General
X Guaranteed output tph
X Maximum design output tph
X Kiln shel inside diameter m
X Shell length m
X Extension at feed end m
X Cast nose rings m
X Total length m
X Slope of kiln %
X Nominal speed rpm
X Maximum speed rpm
X Kiln speed with auxiliary drive rpm
Distance of supports from lower end to : #
X support N° 1 m
X from N° 1 to N° 2 m
X from N° 2 to N° 3 m
X Location of Girth gear m
2 Kiln load #
2.1 Refractory (Starting from the lower end for each type :) #
X Location m
X Length m
X Type #
X Thickness mm
X Density t/m3
X Provide a complete arrangment drawing of refractory #
2.2 Material
X Kiln filling internal refractory diameter %
Density t/m3
2.3 Coting #
X Location m
X Length m
X Thickness mm
X Density t/m3
2.4 Loading on supports Vertical load
X support N° 1(Feed end) t
X support N° 2 t
X support N° 3 t
3 TECHNICAL SPECIFICATIONS
3.1 Power
X Absorbed power at nominal speed due to the load kW
X Absorbed power at nominal speed due to the friction kW
Absorbed power at maximum speed due to the load kW
Absorbed power at maximum speed due to the friction kW
X Installed motor power kW
X Motor speed rmp
X Provide a complete calculation note of kiln power
3.2 Shell
X Shell plate thickness under tyre mm
X each side of tyre mm
X under drive gear mm
X burning zone mm
X Steel grade in burninig zone #
X Yield strength MPa
X Steel grade in other zones #
X Yield strength MPa
X Maximum bending stress under tyre MPa
X Maximum bending stress in the burning zone MPa
X Maximum bending stress in other section MPa
X Provide a complete calculation note including : bending moments, deflection, bending stress, forces,,,