Professional Documents
Culture Documents
Didik Suprayogo
Bahan Bacaan:
http://www.fao.org/docrep/R4082E/r4082e06.htm
IRRIGASI
Fungsi spesifik:
1. mengambil air dari sumber (diverting)
2. Membawa/mengalirkan air dari sumber ke lahan
pertanian (conveying)
3. mendistribusikan air kepada tanaman (distributing)
4. mengatur dan mengukur aliran air (regulating and
measuring)
SISTEM IRRIGASI?
The conveyance system assures the transport of water from the main
intake structure or main pumping station up to the field ditches.
The field application system assures the transport of water within the
fields.
The drainage system removes the excess water (caused by rainfall and/or
irrigation) from the fields.
Pumping station
conveyance system
The intake structure is built at the entry to the irrigation system (see Fig. 70). Its
purpose is to direct water from the original source of supply (lake, river, reservoir
etc.) into the irrigation system.
PUMPING STATION
In some cases, the irrigation water source lies below the level of the irrigated
fields. Then a pump must be used to supply water to the irrigation system (see
Fig. 71).
PUMP
There are several types of pumps, but the most commonly used in irrigation is the
centrifugal pump.
The centrifugal pump (see Fig. 72a) consists of a case in which an element, called an
impeller, rotates driven by a motor (see Fig. 72b). Water enters the case at the center,
through the suction pipe. The water is immediately caught by the rapidly rotating
impeller and expelled through the discharge pipe.
BENDUNGAN URUGAN TANAH DAN
WADUK PERTANIAN (EMBUNG)
Macam Pondasi:
Batuan pejal; kadang ada masahan bahaya bocor, untuk itu perlu sementasi / injeksi
bahan semen
Pasir halus yang seragam, bila dibawah “kepadatan kritis” (void ratio dimana tanah
mengalami deformasi walupun tanpa merubah volume), maka pondasi ini harus
dikonsolidasi untuk mencegah aliran akibat beban penggenangan
Pasir kasar dan kerikil, pada saat penggenangan akan mengalami konsolidasi,
pelapisan bahan kedap air di bagian muka diperlukan untuk mencagah kebocoran,
Liat yang plastis, tekanan geser yang diakibatkan oleh berat bendungan harus lebih
kecil dari pada ketahanan geser bahan pondasi, side slope yang lebih mendatar
diperlukan untuk mengurangi tekanan geser
RANCANGAN YANG DISESUAIKAN BAHAN YANG TERSEDIA
e = 23/3 = 7.6 m
L = (2Z + h – e/2) cot α + W + 0.3M
L = (2X3 +23 – 7.6/2) x 1 +6+6.9 = 38.1 m
q = (4 x 0.0176 x 23 x 23)/ (9X 38.1)
q = 0.1086 m3/ d per lineal meter of length
PERLAKUAN PONDASI
Kurang 15 m < tajam dari 3:1 bagian depan dan 2:1 bagian
belakang,
Bahan urukan kasar 3:1 atau 4:1
Top width bendungan < 5 m = 2.4 m,
Top width > 5 m W = 0.4 H + 1
Mechanical Spillways
CONVEYANCE AND DISTRIBUTION
SYSTEM
A cardboard sheet is lifted on one side 2 cm from the ground (see Fig. 79a). A small ball is
placed at the edge of the lifted side of the sheet. It starts rolling downward, following the
slope direction. The sheet edge is now lifted 5 cm from the ground (see Fig. 79b), creating a
steeper slope. The same ball placed on the top edge of the sheet rolls downward, but this time
much faster. The steeper the slope, the higher the velocity of the ball.
Water poured on the top edge of the sheet reacts exactly the same as the ball. It flows
downward and the steeper the slope, the higher the velocity of the flow.
Water flowing in steep canals
can reach very high velocities.
Soil particles along the bottom
and banks of an earthen canal
are then lifted, carried away by
the water flow, and deposited
downstream where they may
block the canal and silt up
structures. The canal is said to
be under erosion; the banks
might eventually collapse.
DROP STRUCTURES AND CHUTES
Drop structures or chutes are required to reduce the bottom
slope of canals lying on steeply sloping land in order to avoid
high velocity of the flow and risk of erosion. These structures
permit the canal to be constructed as a series of relatively flat
sections, each at a different elevation (see Fig. 80).
Drop structures take the water abruptly from a higher section
of the canal to a lower one. In a chute, the water does not drop
freely but is carried through a steep, lined canal section. Chutes
are used where there are big differences in the elevation of the
canal.
DISTRIBUTION CONTROL
STRUCTURES
48
Pengertian Dasar
49
Peralatan Pengukuran
50
Untuk debit yg sedang dan besar
( > 5 lt/det) maka diperlukan alat ukur yang
lebih baik dan lebih teliti
Peralatan tersebut antara lain dinamakan
current meter, yakni alat yang berfungsi
mengukur kecepatan aliran air dg sangat
teliti.
51
Dasar Perhitungan
• Rumus dasar:
• Q=AxV
Dimana :
Q = debit aliran (m3/det)
A = Luas penampang aliran (m2)
V = Kecepatan aliran air (m/det)
52
PENGUKURAN AIR DI PIPA
FAKULTAS PERTANIAN
UNIVERSITAS BRAWIJAYA
Debit Aliran Melalui Pipa
Debit aliran yang melalui pipa dapat diukur
debitnya dengan cara meletak suatu alat yang
disebut meter air.
Q =C A (2gh)1/2 C= 0.6
Prinsip kerja alat ini adalah merubah kecepatan
aliran air menjadi putaran baling-2 (propeller) dan
kemudian dirubah dalam satuan debit.
Alat elektrik, singnal listrik, solar panel, transmisi
radio
Meteran air
54
Mengukur debit air yang keluar dari Pipa
Q = A x V atau
Q = Vol / waktu
Ember
55
Contoh perhitungan
• Volume ember 6 liter:
• Waktu pengambilan air = 2 detik
• Maka debit aliran adalah
• Q = 6/2 = 3 liter/detik
56
Memperkiraan debit yg
lewat Pipa tertutup
Q =AxV
A = Luas penampang pipa (cm2 atau inc2)
V = Kecepatan aliran lewat pipa (m/dt)
Contoh perhitungan :
Kondisi Pipa dianggap penuh air, maka
A = ¼ µ d2, , d = diameter pipa ( 4 inci=10 cm)
A = ¼ x3,14 x(10) 2 = 78,5 cm2
57
PENGUKURAN AIR DI SALURAN
TERBUKA
FAKULTAS PERTANIAN
UNIVERSITAS BRAWIJAYA
Debit Air pada Saluran Irrigasi / Sungai
59
Contoh Gambar
1 2
60
Gambar Current Meter
61
62
PERSYARATAN PENGUKURAN DEBIT DI SUNGAI
63
1. Lokasi Pengukuran
64
Jangan Pada aliran turbulen/bergolak Yang
disebabkan oleh batu-batu, vegetasi,
penyempitan lebar alur sungai
dilakukan pada alur sungai yang stabil atau lurus,
lokasi pengukuran debit mudah didatangi, tidak
tergantung dari keadaan cuaca khususnya pada
musim penghujan atau pada saat terjadi banjir;
65
2. Jumlah dan waktu pengukuran;
66
• Sedangkan periode pelaksanaannya
tergantung daripada musim.
• Pada musim kemarau pada umumnya
cukup satu sampai dua kali selama
keadaan aliran masih tetap rendah.
• Pada musim penghujan memerlukan
frekuensi pengukuran yang lebih banyak,
yaitu minimal 3 kali
67
Lengkung Debit
1,4
Tinggi air
(m)
1
0 2 5
Debit air
(m3/det)
68
3. Peralatan, tenaga pelaksana dan
dana
• Gabus, curret meter, arloji, meteran dll
• Mininal 1 -2 orang
• Tergantung situasi
69
Bangunan Pengukur Debit pada
Saluran Irigasi
1.Bangunan Cipoletti
Berbentuk Segi empat H
2.Bangunan Thomson B
Berbentuk setitiga
H
Q = a Hb
70
www.themegallery.com
• Pintu Sorong
B
Bila sungainya besar?
Bagaimana cara mengukurnya?
h =…m?
73
FIELD APPLICATION SYSTEMS
With sprinkler irrigation, artificial rainfall is created. The water is led to the field
through a pipe system in which the water is under pressure. The spraying is
accomplished by using several rotating sprinkler heads or spray nozzles (see
Fig. 94a) or a single gun type sprinkler (see Fig. 94b).
www.themegallery.com Company Logo
www.themegallery.com Company Logo
Irigasi dalam budidaya tanaman tebu di GMP : tujuan
In drip irrigation, also called trickle irrigation, the water is led to the field
through a pipe system. On the field, next to the row of plants or trees, a tube is
installed. At regular intervals, near the plants or trees, a hole is made in the
tube and equipped with an emitter. The water is supplied slowly, drop by drop,
to the plants through these emitters (Fig. 95).
www.themegallery.com Company Logo
www.themegallery.com Company Logo
www.themegallery.com Company Logo
DRAINAGE SYSTEM
(A drainage system is necessary to remove excess water from the irrigated land. This
excess water may be e.g. waste water from irrigation or surface runoff from rainfall. It
may also include leakage or seepage water from the distribution system.
Excess surface water is removed through shallow open drains (see Surface drainage,
Chapter 6.2.1). Excess groundwater is removed through deep open drains or
underground pipes (see Subsurface drainage, Chapter 6.2.2).
TUGAS KUALITAS AIR IRIGASI
1. Pemerintah telah mengeluarkan Perturan Pemerintah No 77 Tahun 2001
tentang Irigasi (lihat di bahan kuliah yang bersama tugas ini), untuk itu
buat ulasan keterkaitan peraturan tersebut terkait dengan sistem irigasi
dilapangan dalam usaha pertanian yang anda observasi.
2. Pemerintah telah mengeluarkan standar kualitas Air Irigasi berdasarkan
Peraturan Pemerintah No 82 tahun 2001 (lihat di bahan kuliah yang
bersama tugas ini) , untuk itu dari standar tersebut, melalui studi literatur
deskripsikan teknik mengukur masing-masing standar kualitas air irrigasi
tersebut. Mengapa kualitas tersebut penting bagi pertanian.
3. Kualitas Air di sepanjang Sungai Brantas telah di lakukan monitoring
secara periodik oleh Perum Jasa Tirta, tetapkan wilayah pengairan yang
memenuhi / tidak memenuhi standar air irrigasi berdasarkan Peraturan
Pemerintah No 82 tahun 2001 , dari waktu kewaktu.
4. Melalui kajian literatur, beri rekomendasi bagaimana cara agar wilayah
pengairan yang tidak memenuhi standar kualitas air irigasi menjadi air
irigasi yang memenuhi standar kualitas air irigasi bagi usaha pertanian.
STRATEGI KONSERVASI AIR