Professional Documents
Culture Documents
Choosing Steel Sub-Grade Example PDF
Choosing Steel Sub-Grade Example PDF
Choosing Steel Sub-Grade Example PDF
Q; G
10,00 [m]
Basic data
This material is copyright - all rights reserved. Use of this document is subject to the terms and conditions of the Access Steel Licence Agreement
Yield strength
Steel grade S355 EN 1993-1-1
Table 3.1
The maximum thickness is 16 mm < 40 mm, so : fy = 355 N/mm2
A1.2.2 (1)
Example: Choosing a steel sub-grade
EN 1993-1-10
This material is copyright - all rights reserved. Use of this document is subject to the terms and conditions of the Access Steel Licence Agreement
TEd = & 30 °C
Moment diagram
M
431,1 kNm
EN 1993-1-10
t
f y(t) % f y,nom & 0 ,25 ( §2.3.2
t0
Example: Choosing a steel sub-grade
where:
t = 16 mm (flange thickness)
t0 = 1 mm
16
f y(t) % 355 & 0,25 ( % 351 N/mm²
1
Note: fy(t) may also be taken as ReH-value from the product standard
EN10025
1. Conservative method
Input values:
Element thickness: t % 25 mm * t f % 16 mm
Created on Monday, January 09, 2012
Example: Choosing a steel sub-grade
2. Exact Determination
Linear interpolation can be used in applying Table 2.1 of EN 1993-1-10 for
the actual value of the proportion of the nominal yield strength.
Temperature:
TEd % &30 °C TEd % &30 °C
Max permissible element thickness for S355JR
t () Ed % 0,75 f y(t)) % 15 mm t () Ed % 0,50 f y(t)) % 30 mm
g
Document Ref: SX005a-EN-EU Sheet 6 of 6
u
CALCULATION SHEET
i
Table 2.1
o
,
c
y
a
s
d
i
n
o
l
Quality Record
Reference(s)
ORIGINAL DOCUMENT
TRANSLATED DOCUMENT