Job Title: 8 Stripping and waxing floors Job Performed By:
REQUIRED PERSONAL PROTECTIVE EQUIPMENT: Non-slip footwear, goggles, gloves
GENERAL NOTES:
JOB SAFETY ANALYSIS:
Step Description Hazard Controls
1 Prepare area of floor to be Back Injury--Foot--Hand--Muscle Strain-- Make sure plugs are grounded, assess muscle strength,--Buddy stripped. All furniture etc should Electrocution system, get help for large or heavy objects. be removed prior to starting stripping job.--Check all equipment for frayed wires, loose plugs 2 Scrape gum from floor, scrape Back Injury--Cut Proper operating procedure should be followed, bend knees, not corners to remove build-up. back. Care should be used if using a razor to remove gum. 3 Sweep floor. Bring floor stripping Trip--Spill--Splash--Collision Arrange equipment in an orderly fashion equipment to the area including floor scrubber, driveblock, stripping pad, doodlebug, scraper (putty knife), wet vacuum, stripping boots, bucket of clean rinse water treated with neutralizer, and mops. 4 Prepare stripping solution Splash--Spill--Chemical-Corrosive Personal protective equipment (PPE) should include the following; according to instructions on chemical goggles, gloves as per MSDS container Refer to MSDS
Page 1 of 2 Print Date: Jun/06/2007
5 Follow "Mopping floors" job safety analysis procedures to apply stripper to a small area. 6 After waiting 15 minutes scrub Slip--Fall note: the floor becomes You must wear non-slip footwear, such as stripping boots area with stripping pad attached extremely slippery when stripper is to the floor scrubber applied 7 Pick up dirty solution in scrubbed Fall--Slip--Muscle Strain Follow safe work procedures for mopping floors area with a wet vacuum. Rinse floor with water and neutralizer 8 Allow floor to "air dry". Return equipment that will not be used for waxing procedure to storage area. 9 WAXING PROCEDURE Slip, fall Set up "Wet floor" signs 10 Pour wax in bucket Muscle Strain Assess muscle strength 11 Apply wax with wax mop using figure 8 pattern (while walking backwards). Do not wring out mop to avoid bubbles in wax which may cause the "fish eye" effect. 12 Allow wax to dry and repeat previous step.