1、 锅炉吹灰一次 soot blowing of boiler first stage 2、 打开(关闭)事故放水 [Open/close] emergency drainage water 3、 锅炉升温(升压) temperature/pressure of boiler rising 4、 锅炉定排一次 periodic blowdown of boiler one time 5、 冲洗就地水位计 flushing the local water level meter 6、 投入连锁 put the interlock into operation 7、 投入给石油焦机 put the sponge coke feeder into operation 8、 间断给焦(连续给焦)discontinuously/ continuous feeding coke 9、 锅炉上水 filling boiler with water 10、 水压试验 hydraulic test 11、 锅炉本体检查 boiler proper inspection (as a whole) 12、 锅炉叫水 determine the boiler water level 13、 辅机送电 auxiliary equipment energization/operation 14、 辅机检查 auxiliary equipment inspection 15、 风机轴承温度 bearing temperature of air fan 16、 风机测振 measure vibration of air fan 17、 投入(解列)辅机冷却水 put the auxiliary equipment into operation/ Put off/disconnect auxiliary equipment 18、 投入连排(加药) put the continuous blowdown/dosing into operation 19、 投入减温水 put the attempration/desuperheating water into operation 20、 清通给石油焦机 clean up and dredge the sponge coke machine 21、 打开(关闭)省煤器再循环 [open/close] economizer to circulate 22、 投入(解列)床上(床下)油枪 put the oil gun above /under bed into/out of Operation; 23、 启动(解列)油泵 startup (shutdown) oil pump 24、 油压控制在 3.0Mpa oil pressure is controlled at 3.0Mpa. 25、 校对水位计 calibrate the water level 26、 电除尘投伴热、投入电除尘 put heat tracing of ESP and ESP into operation 27、 锅炉本体送照明 power on the lighting of boiler proper 28、 风机事故跳闸 emergency trip of air fan 29、 事故报警 emergency alarm 30、 临界流化状态 critical fluidized status 31、 床料厚度 the thickness of bed material 32、 油枪雾化试验 the atomization test of oil gun 33、 停炉检修 boiler outage for maintenance 34、 清通放渣管 dredge the slag discharging pipe 35、 输渣设备投入 put the slag conveying equipment into operation 36、 氧量控制 oxygen control 37、 控制床温 control bed temperature 38、 调整燃烧 adjust combustion 39、 带负荷 increase load 40、 一、二次风配比 the distribution ratio of primary and secondary air fan 41、 开启(关闭)疏水 open(close)drainage 42、 严禁操作 no operating 43、 增加(减小)给焦量 increase/decrease sponge coke feeding amount 44、 开启(关闭)空气门: open/close air valve 45、 填写热力检修工作票: fill in the work permit of thermodynamic maintenance 46、 工作票的签发 issue the work permit 47、 做安全措施 take the safety measures 48、 严禁合闸 no closing the switch/do not close the switch 49. 炉膛 furnace 50. 水冷壁 water wall 51. 燃烧器 burner 52. 过热器 superheater 53. 再热器 reheater 54. 减温器 attemperator/desuperheater 55. 省煤器 economizer 56. 空气预热器 air preheater (rotary air heater) 57. 静电除尘器 electrostatic precipitator 58. 吸风机 I.D.F /induced draft fan 59. 引风机 F.D.F /forced draft fan 60. 给水泵 feedwater pump 61. 皮带输煤机 belt conveyor 62. 给煤机 coal feeder 63. 碎煤机 coal crusher 64. 磨煤机 coal mill 65. 旋风分离器 cyclone separator 66. 吹灰器 sootblower 67. 卸料机 material unloader 68. 暖风器 steam air heater (air preheater) 69. 石油焦:sponge coke