Professional Documents
Culture Documents
Set B: Eastern Visayas State University
Set B: Eastern Visayas State University
College of Engineering
Civil Engineering Department
a 273.7 kN b 1516.84 kN
c 90.32 kN d 1140.48 kN
10 . (b) Based on the bearing capacity of bolts.
a 764.12 kN b 1140.48 kN
c 1013.76 kN d 1692.98 kN
11 . (c) Based on block shear stress.
a 446.22 kN b 666 kN
c 219.78 kN d 592 kN
12 . A square hollow steel strut shown in Figure STLD 1802 with a
wall thickness, t1 = 12 mm is pin connected to two gusset
plates, having a thickness t2 = 12 mm, which are welded to the
base plate having a thickness of 12 mm and fastened to a
concrete base by 4 - 16 mm diameter anchor bolts. Diameter of
pin is 16 mm. Compressive load P = 48 kN, θ = 30°.(a) Calculate
the bearing stress between the strut and the pin.
a 0.4946 b 0.5138
c 0.1696 d 0.826
46 . (b)What is the maximum Ratio of actual to allowable bending
stress for combination of 0.75(D+L+W) load?
a 0.2898 b 0.4181
c 0.4325 d 0.6983
47 . (c) What is the maximum Ratio of actual to allowable bending
stress for combination of (D+L) load if one line of sag rod was
placed at mid-span?
a 0.4074 b 0.5853
c 0.608 d 0.9774
48 . A restrained beams with a span of 4 meters has a rectangular
cross-section (150 mm. × 300 mm.). The unit weight of the
material used is 500 N per cubic meters. The beam is to carry a
superimposed uniformly distributed load of 20 N/m. What is the
maximum bending stress of on the Beam?