Professional Documents
Culture Documents
Discussion On Excel File
Discussion On Excel File
You are to provide the following data in excel sheet : sheet1 at input
data portion.
Note : PAU, MAY & MAZ may be brought from Staad output sheet or
given manually. The axis system is kept at par with Staad file and
hence, no problem to copy & paste. If the section fails with above data,
u just change B or D or Fck or Percent steel and “click”. U can
experiment with the data which is the best set of input data by
changing it at your convenience.
REMARKS = Whether the section fails or passes under the acting load
is indicated in this column and also indicating the type of failure.
After writing the results for 1st row of data, program checks whether
you have put an “END” in the next row, if yes, program terminates and
if no, again another set of data is read for further calculation and
verification. This process continues till your “END” (written by you at
the next row of ur last data row in column C) is realized by it. You can
provide 7994 (= 8000-6) rows of data at a time. But more the data,
time of processing will also be more. Don’t be nervous to see the time
taken. Pls. wait until cursor changes.
After giving a new input, you are to click on the button named “click on
me to get output”. Try it now only with one row of data. Data may be
whatever you like. 1st you check with a known set of data for which you
have already calculated. See whether the Moment capacities,
Interaction Ratio & AlphaN values are OK.
In the input data portion, u can delete or add any row as required. U
can also clear/delete all the data contents or output contents below
row 6, if u require. Just keep in mind, after giving ur input data, put the
word END in the next row.
U may provide or may not provide the Member No and Node No. These
are kept only for information.
With Regards,
Bijay Sarkar
M-09748510409
Kolkata.