Professional Documents
Culture Documents
Gate Barrier Manual PDF
Gate Barrier Manual PDF
Intelligent barriers
Instruction
1) Outline Features 2
2) Production Type 2
4) Working environment 3
6.4)Electrical connections 11
6.5)Debug 13
7) What to do if... 13
Rider. 14
Packing list 18
Fig.1
Fig.2
6) Barriers installation and debug
Fig.3
6.1) Installation for the mechanism.
6.1.1)Select the right barriers production code and fix the barr-iers base with screws refer the
diagram.
6.1.2)Demount the cover of the bars tray. And mount the bar onand fixed it by the screws on
compress board. And then cover the barrier's cover.
6.1.3)Unlock the clutch by clutch handle clockwise .move bar-rier's bar by hand to the horizontal
position and vertical position by hand. Make sure that and lock the clutch dev-ice. And
power on the system.
Fig.4
Fig.5
6.2.4)Adjust the bars when the bar move to vertical position by hand or the bar come back for
hitting something.
6.2.4.1)If the bars is unsteady at the vertical position you can make the bar stop at the position
refer the Fig. 7 and adjust the pull spring tighten or loosen. Make the bars stop at that
position steady.
6.2.4.2)If the bar librate too much when come back for hitting something .you can power off first
and unlock the clutch by clutch key . then move the bar to the vertical position and
continue the step 6.2.4.1). If the bars is unsteady still after step 6.2.4.1), you can select
the follow way :
a change the pull spring link position from hole 1 to hole 2 .
b change the pull spring type then readjust the bar againby step 6.2.4.1).
(The date above just match with the bar produced by out company)
B.Installation:
a.Select a right spring and insert it into the spring canister.
b .Put the spring and the canister into the Spring base.
c. Insert the screw thread pole from the top hole of the flat to the center of the spring, and use the
right screw to fix it on to the right hang hole.
d.Install the gasket and the Adjust screw at the bottom of the sc-rew thread pole,deasil spin the
Adjust screw to adjust the str-ess of the spring and make the bar balance.
Rider
If the radio controller or phototest are not match with the machi-ne, you must make their
radio code identical with the machine. Step:
Read the code:
The radio code is signed behind the matched radio controller and on the transformer of
the barrier controller.
How to code :
Open the radio controller cover, take out the battery. You can see the code pad on the PCB,
the code is from right to left, the first code on the right.Short the middle pad and the above
pad stands for 1, short the middle pad and the bottom pad stands for 0, N/C stands for X.
The follow code is:10XX0X1X
Packing list