Professional Documents
Culture Documents
Digimatic code
1. Pin assignments and signals 3. Data format
1 9 9 1
Compatible socket: d1 d2 d3 d4 d5 d6 d7 d8 d9 d10 d11 d12 d13
Sumitomo 3M : V Low-Proheader
2 10 10 2 Model: 7610-5002XX or equivalent
Gage plug External device ALL "F" Measured value
socket Sign (+: 0, -: 8)
Decimal point (0-5) e.g.0 000000.
1 00000.0
Pin No. Signal I/O Description 5 00.0000
1 GND — Signal ground
Unit (mm: 0, inch: 1)
2 DATA Output Measurement data-output terminal
3 CK Output Synchronized clock-output terminal • Data is output as 13-digit (52-bit) based on 4 bits = 1 digit.
4*1 N.C. — Not used • Data is output in order from d1 to d13. Each digit is output in the order of LSB to
5 REQ Input Input for data transmission request from external device MSB.
• Measurement data is output in the order of MSD to LSD.
6* 1
ORIG Input Input for absolute-origin setting signal • The sign, measurement data, decimal position and unit are output in BCD based on
7*1 N.C. — Not used positive logic (0=L, 1=H).
8*1 N.C. — Not used
9*1 +5V — Power supply (+5V ±10%)*2
10*1 GND(F.G.) — Frame ground 4. Timing chart
*1 : LGD, LGS uses a unique specification.
All others use the common Digimatic output specification (10-pin, square). t5 t6 t7
*2 : Current consumption of LGD,LGS: Idd=20mA max.
REQ
CK
DATA
2. I/O electrical specifications t1 t2 t3 t4
t8
• Output terminal format: CK, DATA
N-channel open drain ORIG
Maximum output current: 400µA max. (when Vol=0.4V) Absolute origin setting active
30