Professional Documents
Culture Documents
200mm
VACUUM PUMPS
110mm
36
REFRIGERANT SERVICE TOOLS
Infrared (NDIR type) leak detector
INFRARED
Code No.LD316E
( NDIR TYPE ) R32
Freon HFO - 1234yf Infrared sensor
LEAK DETECTOR applicable
High-performance &
high-sensitivity infrared sensor !!
Long life !!
VACUUM PUMPS
Accurate leak detection with high - performance,
high - sensitivity with infrared sensor
(NDIR type), and 9 stages colour indicator.
PEEKHOLD Mode
Image of Leakage
CM mode
Detect with Higher Sensitivity
■ By pressing【CM】, detection
sensitivity increases to 3g /
GAS LEAKAGE DETECTION & PREVENTION
year.
For normal detection, detect
with standard mode and for 70mm
detection with better
sensitivity set the detection
sensitivity to 3g / year.
R410A, R407C, R404A, R507A, R134a, R12, R22, R500, R502,
Applicable refrigerant
HFO1234yf, R32, R245fa, etc
LED light at the probe tip
Detection method Infrared type
■ By pressing【LED light ON / OFF】, Gas introduction method Gas suction system
lights up. Sensitivity High : 4g / yr, Medium : 7g / yr, Low : 14g / yr, CM mode : 3g / yr
With the light, can detect for refrigerant Power Rechargeable lithium battery
leackages in internal system, ceiling, Time Reaction time : less than 1sec / Warm up : about 30 secs
and basement easily. Detection method Buzzer & 9 staged LED
Weight 495g
Temperature range working : 0 ~ 50°C / storage : –10 ~ 60°C
Standard accessories Leak check bottle, Spare filter × 5, AC adapter, Body cover, Storage case
37
REFRIGERANT SERVICE TOOLS
UV Light
■ With high brightness UV LED Light,
can detect the leakage of A / C
containing fluorescent agent.
38
REFRIGERANT SERVICE TOOLS
Infrared (NDIR type) CO2 leak detector
VACUUM PUMPS
Repair part
CO2 Sensor : Code No.Y69398 Filter Kit (10pcs) : Code No.Y69397
63mm
Leak detector
Gas detection of HC refrigeration storage room, gas pipe, gas heater, etc.
Indicator displays the value of leak in 6 stages.
Low battery LED Indicates when the battery needs to be replaced.
Automatic calibration & zero setting. High sensitive
detection of
Gas Mate
Code No.LB706600
HC (flammable)
Isobutane
Gas detection of HC refrigeration storage room, gas pipe, gas heater, etc
Hydrocarbon gas and other gases can be detected with the advanced technology
Sensitive to 5ppm methane
Auto zero setting for ignoring background gas levels in test area
High sensitive
detection of
Applicable refrigerant
Methane, Natural gas, Propane, Butane, Isobutene, Ammonium, combustible gas
Cyclopentane, Ethan, Ethanol, etc
215mm such as HC !
Detecting method Semiconductor Sensitivity 5ppm (mathane)
1.5V Alkaline battery × 2
Power (40 hours) Weight 700g (includes battery)
39
REFRIGERANT SERVICE TOOLS
DIRECT DETECTION Big Blu Big Blu for Low Temperature PAT.
Bubbles bulge and 0.95L 3.8L For refill 0.95L 3.8L For refill
easy to find a leakage. Item 0.95L 3.8L for refill 0.95L (low temperature) 3.8L for refill (low temperature)
Code No. RT100S RT100G RT150S RT150G
Amount 0.95L 3.8L 0.95L 3.8L
Temperature range 1.6 ~ 80°C − 34 ~ 94°C
oxide film
1/4"
Realize piping without leakage !
Length Code No. Length Code No. Pressure Primary side : 0 ~ 25MPa / Secondary side : 0 ~ 15MPa
10m XP415 30m XP405 Secondary adjustable pressure 0 ~ 8.0MPa
20m XP425 40m XP435 Hose Proof pressure : 6.8MPa / Burst pressure : 27.5MPa
Regulator for airtight test, 1/4" hose for nitrogen 3m × 2, Pressure gauge with T cheese,
Standard accessories
ø80mm single manifold, Adapter for different diameter 1/4" × 5/16", Case
40
REFRIGERANT SERVICE TOOLS
Mirror for a detection
INSPECTION
Stainless steel mirror with 360° rotatable ball joint.
Extendable handle up to 700mm.
ø95mm
95 × 50mm
50 × 32mm
Round
Y78100
Square・Large
VACUUM PUMPS
Y78101
Square・Small
Y78102
Inspection camera.
41
REFRIGERANT SERVICE TOOLS
Stepped sealant
Many cases of refrigerants leak from ■ Coated Loctite sealant.
flare fittings. If use Flaretite when ■ Special technology not to mix the sealant in the system.
installation and maintenance of
refrigeration equipment, it prevents Easy installation tional
Conven torque
ng
refrigerant leakage from flare fittings. tighteni
OK!!
■ You can use your torque wrench to tighten.
■ Just snap the Flaretite onto the end of male flare.
e 5MPa
Leakag
3 hours
age
at
after N leak
o
charged
with
2MPa nitrogen
scratch
Date / 2011.12.9
〈 Test condition 〉 Flare surface of Flare surface of
copper tube male flare
❷
❸ ❷
■ Flaretite has been used for more than 5 years by major refregiration equipment Applicable to all kinds of refrigerant & refrigeration oil
manufacturer.
■ Flaretite has attracted a public attention in California where the regregerant
leakage is serious problem as it prevents refrigrant leakage from flare.
42
REFRIGERANT SERVICE TOOLS
Refrigerant "Leak - Free" seal
Flaretite PAT.
More th
an
5 yoefars
Loctite sealant For scratch on the flare nce!!
experie
Prevernt even large leakage by the Loctite Loctite sealant
sealant and the stepped copper gasket. Enter the scratch fills scratch on
Loctite sealant protects the face of fitting the flare and
from over- tightening. prevents leakage.
For repairing of filters, maintenance, and an
Loctite (No.517) does not harm refrigerant
equipment due to inert substance. Loctite sealant
expansion valve of existing HVAC equipment !!
VACUUM PUMPS
3/4" (10pcs) FT1234 1
Flaretite Cu PAT.
More th
an
Stepped copper gasket with patented tab. (※)
Copper seal is suitable for various flare fitting.
10 oyfears
nce!!
Rated for all common gases and fluids. experie
Applicable to angle gap of flare and gap between center of pipes.
43
REFRIGERANT SERVICE TOOLS
Flaretite for general flare fitting (For all common gases and fluids) PAT.
Same technology as refrigeration seals prevents all
For leak prevention from flare fitting of Hydraulic • Fuel • Gases. Back order common gas and fluiad leakage from flare fitting !
(JIC 37° flare • SAE 45° flare)
For leak prevention from plubming and connecting part of hose of Hydraulic equipment, Various type of seals for various flare fittings,
Garbage truck, Construction machine, Press machine, Injection moulding machine. gases & fluids and environment !
Standard carbon steel seals 304 Stainless steel seal with Loctite Vibra Seal coating
Size
LOCTITE Angle
1/8" 1/4" 3/8" 1/2" 5/8" 3/4" 7/8" 1" 1 ~ 1/4" 1 ~ 1/2" 2"
517 37° − 304 304 304 304 304 − 304 304 − −
Rated for – 40 ~ 148°C, JIC 37° flare
Marine and corrosive environment seals 316 Stainless steel seal with Loctite Vibra Seal coating
Size
LOCTITE Angle
1/8" 1/4" 3/8" 1/2" 5/8" 3/4" 7/8" 1" 1 ~ 1/4" 1 ~ 1/2" 2"
37° 316 316 316 316 316 316 316 316 316 316 316
517 45° − 316 316 316 316 316 − − − − −
45° − Cu Cu Cu Cu Cu − − − − −
Rated for – 40 ~ 148°C, JIC 37° flare, SAE45° flare
High temp. oil and stea seals 316 Stainless steel seal with Loctite high temp graphite coating
Size
LOCTITE Angle
1/8" 1/4" 3/8" 1/2" 5/8" 3/4" 7/8" 1" 1 ~ 1/4" 1 ~ 1/2" 2"
37° 316 316 316 316 316 316 316 316 316 316 316
17015
37° Cu Cu Cu Cu Cu Cu Cu Cu Cu − −
Rated for – 40 ~ 648°C, JIC 37° flare
Refrigeration seals Copper seal with standard loctite Vibra seal coating
LOCTITE Angle
1/4" 3/8" 1/2" 5/8" 3/4"
517 37° Cu Cu Cu Cu Cu
Nylog PAT.
For flare For valve opener For gasket
Does not harm system as the component of Nylog is refrigeration oil. Leak prevention from flare, valve opener,
Nylog blue for sealing flare surface under high pressure of new type regrigerant.
gasket, screw and O-ring.
Prevents troubles due to the leak of HFC refrigerant.
44