Professional Documents
Culture Documents
IMPERIAL COLLEGE OF
ENGINEERING AND
RESEARCH
INDEX
02 Fixture Assembly 02
10 Crosshead Assembly 22
12 V-Block Assembly 27
Figure 2 Dimensions and views of the flange Figure 3 Dimensions and views of the Bolt
Fixture Assembly
Create all the components of the Fixture assembly and then assemble them, as shown in
Figure 1. The details of the components of the Fixture assembly are shown in
Figures 2 through 5.
Shock Assembly
In this project, you will create all components of the Shock assembly and then assemble
them, as shown in Figure 1. Also create an exploded state of the assembly, as shown in
Figure 2. The dimensions of the components are shown in Figures 3 through 10.
Piston stroke
Crank throw.
3) Conrod.
1) Crankcase-block.
5) Piston.
2) Crankshaft. 4) Pin.
Figure 6 Left-side view of the Bracket Figure 7 Sectioned front view of the
Figure 8 Dimensions of the Washer, Cap Screw, Turn Screw, and Nut
Pulley Support Assembly 3
Figure 4 Views and dimensions of Brasses, Nut, Lock Nut, and Bolt
Press Tool Assembly 1
Figure 2 The exploded view of the Press Tool as- Figure 3 Figure showing the Bottom Plate
sembly
2 Student Project
Figure 4 Dimensions and views of the Top Figure 5 Dimensions and views of the Guide Pillar
Plate and Guide Bush
Double Bearing Assembly 1
Figure 1 The completed Double Bearing Figure 2 The exploded view of the Double
assembly Bearing assembly
Figure 3 Top view of the Base Figure 4 Top view of the Cap
Figure 5 Front view of the Base Figure 6 Front view of the Cap
2 Student Project
Figure 7 Dimensions and drawing views of the Bushing and the Bolt
Bench Vice Assembly 1
Figure 4 Views and dimensions of various components of the Bench Vice assembly
Bench Vice Assembly 3
Figures 5 Views and dimensions of various components of the Bench Vice assembly
Crosshead Assembly 1
Crosshead Assembly
In this project, you will create all components of the Crosshead assembly and then assemble
them, as shown in Figure 1. Also you will create an exploded state, shown in Figure 2. The
dimensions of the components are shown in Figures 3 through 7.
Figure 5 Top view of the Arm Figure 6 Sectional front view of the Arm
V-Block Assembly
Create all the components of the V-Block assembly and then assemble them, as shown in
Figure 1. The dimensions of the components are shown in Figures 2 and 2.
Figure 4 Front view of the Wheel Figure 5 Sectioned side view of the Wheel
2 Student Project
Figure 3 Front and right-side views of the Stock Figure 4 Top and front views of the Adjusting Screw
Support Roller Nut
Figure 7 Views of the Support Adjusting Screw Figure 8 Top and front views of the Thrust
Bearing