Professional Documents
Culture Documents
MAINTENANCE MANUAL
1. General
A. This section gives the procedures to remove and install the control-column position switch.
B. The control-column position switch is a component of the electromechanical gust lock system. It is
installed in the area below the cockpit floor.
C. The procedures in this section are given in the sequence below. The tasks identified with (♦) are
part of the Scheduled Maintenance Requirements Document (SMRD).
AIRCRAFT WITH
CONTROL-COLUMN POSITION SWITCH - ELECTROMECHANI-
27-71-11-000-801-A
REMOVAL CAL GUST LOCK
AIRCRAFT WITH
CONTROL-COLUMN POSITION SWITCH - ELECTROMECHANI-
27-71-11-400-801-A
INSTALLATION CAL GUST LOCK
Copyright © by Embraer S.A. All rights reserved - See title page for details.
AIRCRAFT
MAINTENANCE MANUAL
TASK 27-71-11-000-801-A
EFFECTIVITY: AIRCRAFT WITH ELECTROMECHANICAL GUST LOCK
REFERENCE DESIGNATION
F. Consumable Materials
Not Applicable
G. Expandable Parts
Not Applicable
H. Persons Recommended
I. Preparation
SUBTASK 841-002-A
(1) Put the control column fully forward.
Copyright © by Embraer S.A. All rights reserved - See title page for details.
AIRCRAFT
MAINTENANCE MANUAL
(3) Make sure that the safety pins of the landing gears are installed AMM TASK
32-00-01-910-801-A/200.
(2) Remove the bolt (1), washer (4), and nut (3) to remove the switch (5) from the support.
Copyright © by Embraer S.A. All rights reserved - See title page for details.
AIRCRAFT
MAINTENANCE MANUAL
A
ZONES
123
124 B
DET. A
5. SWITCH
1. BOLT
4. WASHER
3. NUT
2. SPLICES
DET. B
145AMM270555.MCE
Copyright © by Embraer S.A. All rights reserved - See title page for details.
AIRCRAFT
MAINTENANCE MANUAL
TASK 27-71-11-400-801-A
EFFECTIVITY: AIRCRAFT WITH ELECTROMECHANICAL GUST LOCK
REFERENCE DESIGNATION
F. Consumable Materials
Not Applicable
G. Expandable Parts
Not Applicable
H. Persons Recommended
Copyright © by Embraer S.A. All rights reserved - See title page for details.
AIRCRAFT
MAINTENANCE MANUAL
(3) Use the bolt (1), washer (4), and nut (3) to connect the switch (5).
(2) Do the operational check of the electromechanical gust lock system. Refer to AMM
TASK 27-71-00-700-801-A/500.
Copyright © by Embraer S.A. All rights reserved - See title page for details.