Professional Documents
Culture Documents
CB Micro-Carbon™ II Series
Filter Cartridges
Performance Specifications
Filter grade1
5 µm
6 0.4 10 25.4/10
5 20 50.8/20
4 30 76.2/30
3 0.2
2
1
0 0
1 2 3 4 5 6 7 8 9 10
Flow rate (gpm), water at 68°F
5 Flow rate is for a 25.4 cm (10 in) cartridge. For liquids other than water,
multiply differential pressure by fluid viscosity (cP).
Unit conversion: 1 bar = 100 kPa.
Applications
Taste, Particulate
Organics Odor, Color Chlorine Removal
Water
Drinking ✔ ✔ ✔ ✔
Utilities ✔ ✔ ✔ ✔
Chemicals
Single Pass ✔ ✔ ✔
Recirculating Use pre-filter
WARNING: Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the system.
NOTE: These cartridges contain a very small amount of carbon fines (very fine black powder). After installation, flush the cartridge for a minimum of 5 minutes to remove
all traces of the fines before using the water. You should run (flush) the tap at least 20 seconds prior to using water for drinking or cooking purposes. This is particularly
important if the tap has not been used daily.
CAUTION: Filter must be protected against freezing, which can cause cracking of the filter and water leakage.