DOC NO.:0822-40-96-03-31REV.: 0 Dt: 29.01.2009 SHEET NO.: 15 of 16 GENERAL
1 Tag Nos. HV-1212
2 Service FEED WATER ISOLATION VALVE (IBR) 3 Ambient Temperat 50oC 4 Qty 1 No 5 Fluid / State STEAM 6 DP Shut-off 75.00 SERVICE CONDITIONS
25% 50% 75% 100%
7 Operating Process Design Unit MCR MCR MCR MCR 8 Temperature 105 105 105 105 200 ºC 9 Flow rate 5.4 10.8 16.1 21.5 21.5 T/hr Kg/cm² 10 Inlet Pressure 41.3 42.89 45.52 52.89 75 (g) Kg/cm² 11 Outlet Pressure 41.3 42.89 45.52 49.19 75 (g) 12 DENSITY 954.7 13 Valve Duty ON / OFF Type 14 Valve type GATE 15 ValveSizePort Size NB 80 16 Valve thrust CORRESPONDING TO DP SHUTOFF 17 Body Rating 600 18 Body Material and CS 19 Body Seat Type Integeral 20 Type of Bonnet Material STD/Integral Same as body material 21 Bonnet Gasket Graphoil VALVE
22 Disc material same as body material.
Leakage class at 23 Class IV full closure 24 Valve Stroking TimLess than 25 Sec. 25 Valve travel range 100% 26 Pipe mateOD/Thick SA 106 Gr B 88.9 / 5.49 27 End Connection ( BW ASME B 16.25 28 End Facetype to Face BW to ASME B16.25 29 Dimension As per ISA Standard 30 mm Direction of flow LATER 31 Gland Packing Mate GRAFOIL 32 Type Rising stem outside screw and yoke TRIM
33 Disc seat material STELLITED
34 Body seat ring STELLITED 35 Seat Material STELLITED 36 Valve design ASME B16.34/API 600 CODES CODES 37 Face to face dimenASME B16.10, ASME B16.25 & ISA Standard 38 Testing standards API 600 / API 598 39 Pressure / temperaASME B16.34