Professional Documents
Culture Documents
Version 1.0
Questions: Level 1
A Core
B Cladding
C Buffer jacket
D Strength member
6 What is the full form of the abbreviation
OTDR?
A Optical Time Domain Resolves
B Optical Time Domain Reflectometer
C Optical Time Domain Reflector
D Optical Time Domain Refractor
Questions: Level 1
A Amplifier
B Oscillator
C Modulator
D Multiplexer
3 How many input lines are available in BCD
to 7 segment decoder IC?
A Six
B Four
C Three
D Eight
4 Which type of seven segment display all the
8 anodes are left free?
A Common base type
B Common anode type
C Common anode type
D Common cathode type
A Rheostat
A Low cut off mode B Transistor
B High cut off mode C Zener diode
C Buck operation mode D Potentiometer
D Boost operation mode
8 What is the name of the static device that
4 Which part of the computer is connected by converts fixed DC input voltage into variable
the 20/24 ATX connector from the SMPS DC output?
unit? A DC chopper
A Mother board B Buck converter
B Hard disc drive C Boost converter
C CPU cooler fan D AC link chopper
D DVD ROM / writer
A Clipping
B Clamping
C Chopping
D Switching
8 What is the function of electronic circuit part
marked ‘X’?
A Servo motor
B Motor power control
C Isolation transformer
D Toroidal auto transformer
5 Which type of operation is performed by the
circuit?
A Sensor
B Comparator
C Servo amplifier
D Buck boost transformer
9 What type of transformer is used in
automatic voltage stabilizer?
A Linear regulation A Auto transformer
B Boost operation B Step up transformer
C Fly wheel operation C Isolation transformer
D Buck boost operation D Step down transformer
A Inverted output
A Control B Regulated output
B AC input C Adjustable output
C Feed back D Unregulated output
D Frequency output 16 Which circuit is provided in control section of
11 What is the function of the circuit? SMPS to drive the power switching
transistor?
A Input filter circuit
B Opto isolator circuit
C Rectifier and filter circuit
D Pulse width modulator circuit
17 Which type of core is used in the SMPS
A Sine wave inverter transformer?
B Servo voltage stabilizer A Air core
C Grid tied charge system B Solid iron core
D Switched mode power supply C Ferrite ceramic core
12 Which type of connector is used to supply D Laminated magnetic core
power from SMPS to the computer mother 18 What is the function of opto-coupler in
board? SMPS circuit?
A SATA connector A Controls the pulse width
B Peripheral connector B Isolate the output section
C 20/24 Molex connector C Generates switching pulses
D PCI express connector D Stops RF interference signals
13 Which circuit is used in SMPS for voltage 19 Which transformer has common winding for
regulation? both primary and secondary?
A Clipping A Auto transformer
B Clamping B Step up transformer
C Switching C Step down transformer
D Amplification D Tapped primary transformer
14 What is the switching frequency of SMPS
used in computer?
A 5 kHz
B 10 kHz
C 15 kHz
D 20 kHz
A Digital Controller
A Amplifier
B Battery Charger
B Battery charger
C Load relay
C Multiplexer
D Voltage regulator
D Full adder
3 Which type of mounting method is used in
6 What is the range of specific gravity of lead
battery installation?
acid battery, under discharged condition?
A 1.11 to 1.14
B 1.14 to 1.17
C 1.17 to 1.26
D 1.26 to 1.28
7 What is the full form of the abbreviation
CVT?
A Constant Vector Transformer
B Constant Voltage Transformer
C Constant Virtual Transformer
A Tier mounting
D Constant Volatile Transformer
B Rack mounting
C Shaft mounting
D Cabinet mounting
A Fast charging
B Flash charging
C Trickle charging
D WiFi charging
12 What is the function of preset R5 in the
circuit?
A Silicon
B Geothermal
C Amorphous
D Utility supply
7 What is the name of the SPV system?
A Chemical energy into electrical energy
B Solar energy into electrical energy
C Wind energy into electrical energy
D Tidal energy into electrical energy
2 Which material coverts the light energy into
electricity? A Hybrid system
A LED B Standalone system
B Converter C Interactive system
C Solar cells D Grid connected system
D Photo diode 8 Which formula is used to find the size of PV
3 Which type of energy generation produces module in Watt-peak (WP)?
air pollution? Daily energy Consumption
A
A Wind energy Efficiency − Insulation
B Hydel power
Daily energy Consumption
C Conventional energy B
Insulation × Efficiency
D Non- conventional energy
4 What is the full form of the abbreviation Insulation × Efficiency
C
TFSC? Daily energy Consumption
A Thin Film Solar Cell Daily energy Consumption
D
B Thick Film Solar Cell Efficiency + Insulation
C Thermal Fast Switching Cell
9 What is the name of the device marked ‘X’?
D Twisted Film Silicon Cell
5 Which PV cells are the most common in use
for solar electric system?
A Indium PV cells
B Germanium PV cells
C Phosphorus PV cells
D Crystalline silicon PV cells
A Loads
B Battery
C Inverter
D Charge controller
A Hybrid system
B Biohybrid system
C Standalone system
D Grid connected system
12 What is the name of the solar electric
system block marked ’X’?
A Cell
B Array
C Board
D Module
13 How batteries are rated?
A Volt
B Efficiency
C Ampere-hour
D Wattage hour
A Hybrid system
B Biohybrid system
C Standalone system
D Grid connected system
A Inverted output
B Rectified output
C Regulated output
D Converted output
A Battery
B Solar panels
C Charge controller
D Comparator
14 What is the efficiency of monocrystalline?
A Low
B High
C 100%
D Medium
Questions: Level 1
A Provide efficiency
B Reverse current flow
C Increase light intensity
D Limiting the load current
A 120 Ω
B 130 Ω
C 140 Ω
D 150 Ω
13 What is the switching speed of LED light to
reach full brightness, compared to other
light sources?
A 10 times faster
B 50 times faster
C 100 times faster
D 150 times faster
14 What is the condition for glowing LED?
A Forward biased
B Reverse biased
C Zener breakdown
D Avalanche breakdown
15 What is the efficiency level of incandescent
lamp?
A 5%
B 9%
C 12%
D 15%
A Colour filter
B Horizontal filter
C Vertical filter
D Crystal molecule
A FM receiver
B AM transmitter
C Infrared receiver
D Infrared transmitter
8 What is the name of the block marked ‘X’ in
the infrared remote control receiver?
A VGA adapter
B DVI to RCA adapter
C DVI to HDMI adapter
D DVI to VGA/D-sub adapter A Sensor
2 How many bits are used for coding to B Inverter
generate 64 functions in the IR remote C Microchip
control system? D Regulator
A 4 bits 9 Which principle is used in IR remote
B 6 bits control?
C 8 bits A RF waves
D 16 bits B Blue tooth signals
3 Why aluminium is used as lamp body? C Photoelectric effect
A Block AC D Magnetic flux linkage
B Produces heat 10 What is the name of the block diagram?
C Dissipate heat
D Eleminate loss
4 Which microwave repeater station consists
of large number of transponders and
repeaters?
A Satellite
B Telephone exchange
C Transmitter
D Earth station A DVD player
B Set top box
5 What is the wavelength of Infra Red light
C Colour transmitter
rays produced by the IR LED?
D LCD television receiver
A 450 to 500 nanometer
B 550 to 570 nanometer
C 585 to 595 nanometer
D 850 to 940 nanometer
6 What is the full form of the abbreviation
OLED?
A Organic Light Emitting Diode
B Organic Layer Enabled Diode
C Organic Level Enhanced Diode
D Organic layer Enhanced Diode
A T flip flop
B D flip flop
C JK flip flop
D Bistable flip flop
12 Which type of connector is used for PCI
express audio- video card in the computer?
A 4 pin connector
B 6 pin connector
C 12 pin connector
D 15 pin connector
13 What is the function of the block marked ‘X’
in the remote control transmitter?
A Filter
B Detector
C Amplifier
D Oscillator