Professional Documents
Culture Documents
Manual
EXPERIMENT # 1
Introduction:
Power World is a great and “powerful” utility for solving power flows. Solving a power
system is a little different from circuit analysis. Instead of being given voltages at certain
nodes or impedances, you are often given load and generator powers. This makes solving the
circuit difficult to do by hand, but easy using a tool like Power World. Most utilities use
Power World or similar programs for solving their systems, such as PSS/E.
1. Add Power World to your CAE start menu. In a CAE computer lab, click Start -> CAE
Applications ->Add Applications to Start Menu, and search for Power World.
Mode of Operations:
There is two modes of operations.
Run Mode
Edit Mode
Page 1
Power System Operation Lab. Manual
Figure No: 1
Run Mode:
In run mode system power flow is analysed. Active and reactive power at each
bus is analysed. All fault analysis can be done in run mode of operation.
Figure No: 2
Page 2
Power System Operation Lab. Manual
Lab Task:
First of all model the system in PWS as shown above. Go to case information
section and then Y bus under solution detail menu.
Page 3
Power System Operation Lab. Manual
Conclusion :
In this lab, we learn about how we use Power World Simulator. And how we
make a power system model and analyse it.
First we make model shown in the manual in Edit Mode.
In the model three types of busses.
1) Slack bus.
2) Generating or PV bus.
3) Load or PQ bus.
Then we use Run Mode to analyse the model. And Find the Y-Bus Matrix of
three busses.
The Y-bus matrix also known as admittance matrix, consists of values of line
admittances and bus admittances including half line charging admittances.
………………………………………………………..
Page 4